When do Mercedes Benz Sprinters start to have problems?
When do Mercedes Benz Sprinters start to have problems?
The majority, but not all of the problems occurring with these vehicles occurred after the initial 100,000 miles. It is my belief that the problems I have experienced, will occur with a vast majority of every Sprinter as the mileage of each vehicle approaches 120,000 miles.
When did the Mercedes Benz Sprinter become a Dodge?
Units sold to the rest of North America were badged as Mercedes-Benz until 2003 when they received Dodge branding. Units in the United States and Canada, but not in Mexico, could be purchased as a Dodge or Freightliner from 2003.
What causes a Mercedes Benz engine to not start?
Engine Cranks but no Start, Dies, Stalls, or Backfires. A failed crankshaft position sensor can cause your engine to stall or not start at all. Your Mercedes-Benz may start and run for a short time, or until it gets warm and then it dies.
What’s the life of a Mercedes Sprinter van?
by Jordan Almond on June 12, 2020 The Mercedes-Benz Sprinter is a top choice for both the workhorse utility van s and vanlife camper builds. It’s a great choice, too. In fact, with a diesel engine, a Sprinter will easily see a lifespan of over 300,000 miles.
What does it mean when a Dodge Sprinter won’t start?
The first and most common is when it won’t turn over. This just means that the engine doesn’t move when you turn the key. The second way that your Sprinter won’t start is when the engine turns when you engage the starter, but it won’t fire and run on its own.
What happens when you unplug fuel pressure sensor in sprinter?
If I unplug the fuel pressure sensor and crank for about 20-30 seconds I can get it to hit on what sounds like one cylinder and make a little bit of fumes. The actual pressure matches the desired after 10-15 seconds of cranking. The actual pressure gradually builds and when you quit cranking it gradually drops.
Where is the culpret on a Daimler sprinter?
If you have access to a DRB (Daimler scan tool) check fuel pressure. You must have at least 2500 PSI to start. 3. If no or low fuel pressure the nasty little culpret may be a 25 cent o-ring. The fuel pressure regulator is located at the rear of the fuel rail on 2002 to 2004 trucks.
What kind of pressure crank does sprinter have?
This van is dead, makes no smoke or fumes when cranking. According to two scanners (SDS MB factory tool, and Snap on Solus) I have 5000PSI pressure cranking. If I unplug the fuel pressure sensor and crank for about 20-30 seconds I can get it to hit on what sounds like one cylinder and make a little bit of fumes.
Why is my MISC sprinter losing so much power?
Had a major fuel injector leak for quite some time (now fixed) but the dealer has told me numerous times that that fuel leak caused big problems in the topend of the motor. Motor is losing power (even at full throttle). Services are all up to date – mind you – so it’s not fuel filter.
How many miles can a Mercedes Sprinter go?
In fact, with a diesel engine, a Sprinter will easily see a lifespan of over 300,000 miles. As long as you stay on top of regular maintenance, the longevity of a Mercedes Sprinter will serve you well.
How much does it cost to fix a Mercedes Sprinter?
We have had numerous “repairs” performed at various dealerships at costs of $2000, only to have the engine light appear again within a few hundred miles. Then when taken to another dealership the “problem” is diagnosed as another sensor or valve and once again we have been charged up to $2000.
Are there any problems with my Mercedes Sprinter?
As long as you stay on top of regular maintenance, the longevity of a Mercedes Sprinter will serve you well. But these vans are not devoid of some major common issues, and these problems are expensive to repair. Sourcing Mercedes parts is a potentially difficult task. And buying parts gets expensive.
What causes boost to fail on Sprinter van?
Turbocharger Actuator On the modern diesel engine used in the Sprinter van, boost pressure is controller using a vane-system. The control valve for the vane system is electronically controlled and can fail. The turbocharger is still healthy, only the control valve has failed.
In fact, with a diesel engine, a Sprinter will easily see a lifespan of over 300,000 miles. As long as you stay on top of regular maintenance, the longevity of a Mercedes Sprinter will serve you well.
How to reset service indicator on MB sprinter?
1. Switch on ignition. If the exceeding of the maintenance interval is shown in the display, you have to wait until the readout in the display automatically jumps over to total km. Only then is it possible to get into the service menu. 2. Press button 0 on the instrument cluster for approximately 30 seconds until a beep sounds. 3.
The majority, but not all of the problems occurring with these vehicles occurred after the initial 100,000 miles. It is my belief that the problems I have experienced, will occur with a vast majority of every Sprinter as the mileage of each vehicle approaches 120,000 miles.
Where are the temperature sensors on a Mercedes Benz Sprinter?
In the first SCR Cat section there is another temperature sensor, and the last SCR section has one more N0x sensor. Once the exhausted fumes and particles have passed through this area they are passed through a particulate filter.
How much does it cost to change an oil on a Mercedes Sprinter?
In addition to the complexity of the system, you now must deal with each dealership and their pricing for parts and services. Sprinters are serviced by Mercedes Benz dealerships across the country. An oil change can cost as little as $170 at one dealership to as much as $400 by many others.
How much does a sprinter exhaust system cost?
When you couple the excessive charges for routine maintenance with the astronomical charges for repairs to the items associated with the EGR-DEF- Exhaust System, the cost of ownership is an expense that can greatly affect your bottom line. Our expenses for a fleet of 28 Sprinter vans (2012’s & 2013’s) in 2014 was a staggering $270,000!
