When to replace the EGR valve on a Mondeo?

When to replace the EGR valve on a Mondeo?

I have a 2007 (On a 06 plate tho) 2.2lt TDCi mondeo estate with a duratek engine, I’ve owned the car for just over 2 years and am about to replace the EGR valve for the second time. I have been told that this is a common fault and these valves only seem to last 18 months to 2 years at a time…..

What are the common problems with Ford Mondeo engines?

Solution: A common problem with this year TDCi engine is a bad connection for the fuel pressure sensor. To rectify the problem, a gold electrical connector should be used instead of the tin connector. Problem: Engine does not run properly or fails to start.

Why is the fuel flap on my Mondeo not opening?

Problem: Fuel flap does not open. Solution: The probable cause is insufficient spring pressure from a lack of material on the flap. A revised filler flap should be fitted. The revised flap has an extra 1mm of material to ensure spring contact. Problem: Noise from the rear brakes.

How can I get my Check Engine light to go off?

One of the possible ways of getting your check engine light to go off is pulling off the engine control unit’s fuse and then putting it back again. Although this won’t solve the problem in newer cars, it may solve the problem in a little bit older cars, and it is easy to try. Check your repair manual to find the fuse to the engine control unit.

What to do if your engine management light comes back on?

If the light returns, then you probably have an issue that requires the attention of a mechanic. Alternatively, your local garage will be able to reset your engine management light. An even simpler way to clear the engine management light is to turn the ignition on and off.

What should I do if my EGR light is not working?

The repair of this condition is removal of the EGR valve and inspection of the passageway to check for a blockage. Each model vehicle has different procedures for clearing the passageway due to many different configurations of the system. Some Fords have a removable tube.

What does a red engine management light mean?

If you see a red engine management light, it means your engine has a serious fault and you should pull over and seek roadside assistance. The engine warning light, or engine management light (eml) as it is properly named, can appear for a number of issues.

What to do if your Ford dashboard light comes on?

Make an appointment with your local dealer as soon as possible. Charging System: If you’re driving while this light comes on, switch off all unnecessary electrical equipment that you may have running and get your vehicle checked by an authorized mechanic immediately.

What’s the average speed of a Ford Mondeo?

Max speed km/h (mph) 0-100 km/h 0-62 mph (sec) 50-100 km/h 31-62 mph (sec)* 1.0L EcoBoost petrol 6-speed manual 125 119 6.3 (44.8) 4.4 (64.2) 5.1 (55.4) 200 (124) 12 13.1 1.5L EcoBoost petrol 6-speed manual 160 134 7.8 (36.2) 4.6 (61.4) 5.8 (48.7) 222 (138) 9.2 8.2 1.5L EcoBoost petrol 6-speed automatic 160 146

Which is the best blanking plate for a Mondeo?

Best with a sold (ones with holes in are a waste of time), stainless steel (mild steel can rust, aluninium can melt) blanking plate

What causes smoke from split pipe in Mondeo?

(the split pipe reduces the boost pressure/ air going into the engine, this can be the smoke from the exessive diesel being burnt )

What kind of engine does second generation Mondeo have?

For the second generation Mondeo, the Zetec engine was replaced with 1.8 and 2.0 litre Mazda L engines, branded Duratec by Ford.

How much does a Ford Mondeo 5 estate weigh?

The 2016 Ford Mondeo 5 Estate 2.0 TDCi 150HP PowerShift Trend has 150 PS / 148 bhp / 110 kW. How much does a Ford Mondeo 5 Estate 2.0 TDCi 150HP PowerShift Trend weighs?

How much gas does a Ford Mondeo 3 use?

For example, quite easily (by today’s standards) Ford Mondeo III with 2.0 Duratec engine consumes 12 – 13 l / 100 km in the city and has an average fuel consumption of 9 l / 100 km. Those who believe that high consumption can be avoided by installing “gas” will be disappointed. The Duratec engine family has too soft valve seats.

When did the Ford Mondeo Mk III come out?

The Ford Mondeo MK III (second generation) model was launched by Ford in October 2000. This Mondeo was considerably larger than its predecessor, and although Ford abandoned its New Edge design theme for the second generation, it was their first vehicle to fully benefit from the Prodigy concept car.