Can a Ford Focus cut out when driving?

Its the 1.6tdci and yes it cuts out completely and lights the whole dash. Doesnt always cut as sometime when you go up to 70mph the engine systems fault comes on and puts the car into limp mode. I am fairly switched on could this be something like bad earths?

What kind of engine does a Focus Mk2 tourer have?

I have the same problem, the car is at 86 000 km Focus MK2 Tourer 1.6L TDCi 109hp Durashift CVT ’06 and it won’t start on random basis. Any ideas are highly appreciated. After driving around with this issue for the last 2.5 years I decided to have it fixed.

How to package a Ford Focus dashboard instrument cluster?

Package the Ford Focus dashboard instrument cluster inside a sturdy box with plenty of packaging material (make sure you include your confirmation email in the box). Send us your package by tracked courier (the shipping instructions are on the confirmation email).

Is there a problem with the Ford Focus Turbo?

You should be able to get a scrap turbo quite cheaply, but you would be best with a rebuilt re-con as there is not easy way of telling the condition with running them up. The Focus 1.8 TDci has a very common problem with the rubber turbo pipe on top of the engine….the one with a metal pipe attached that has an electrical connection on it.

How long does it take to repair Ford Focus instrument cluster?

Our Ford Focus instrument cluster repair service will give you better value for money, takes 1-2 working days and comes with an unlimited mile lifetime warranty. Not only this but we also engineer-out the faults to ensure that they do not return.

Why is my Ford Focus hard to drive?

Often the instrument cluster will fail completely and stay that way. When faced with one or more of these symptoms the vehicle becomes difficult to drive due to not being able to read the instruments or the fault symptoms being too unpredictable.

Why does my Ford Focus rev up and down?

Idle Air Control Valve maybe.. Since it only happens when the car is hot, EGR valve gummed up and sticking open? I’m going on the logic that revs bouncing up and down could be a vacuum leak, but i can’t think of anything else that comes in to play only when the cars warm.

Why does my focus cut out at 3000rpm?

Hold the revs at 3000rpm, let go of the throttle and if it cut out it could be this fault as they are very common. Other things to look out for are TPS, MAF sensor, Vacuum leak (split pipe around back of engine) PCM upgrade… I won’t take any responsibility for anyone that tries this!!! Loading…

What to do if your focus Zetec cut out?

The car is fixed by this valve! Hold the revs at 3000rpm, let go of the throttle and if it cut out it could be this fault as they are very common. Other things to look out for are TPS, MAF sensor, Vacuum leak (split pipe around back of engine) PCM upgrade… I won’t take any responsibility for anyone that tries this!!! Loading…

Why does my Ford Focus shut off without warning?

The contact also stated that the check engine indicator illuminated and the vehicle shut off while being driven. Also, after refilling the fuel tank, it took four or five times to restart the vehicle. The failure mileage was 80,000. Down shifts and stalls out in traffic without warning. Engine light comes on and engine shuts off.

What to do if your Ford Focus has no acceleration?

Clean the Map sensor and clean the throttle body . Check your o2 sensors. You can also check for back pressure on the fuel tank . test this buy running the car without the fuel cap . there could also be a plugged Catalytic convertor. Is the car overheating when this is happening ?

What are the problems with a 2002 Ford Focus?

The B+ terminal could break because it had an incorrect harness, leaving the cable loose. Ford Focus RS models built during December 2002 might have had problems with their brake hoses. They could chafe against the rear wheelarch liners causing a failure. Ford should have fixed this for free, so make sure the work has been carried out.

Why does my Ford Focus ST not start?

Click to expand… Pull the cover, and stick the fob inside, if it reads the fob then it would indicate that it thinks the fob battery was low/ dead. Pull the cover, and stick the fob inside, if it reads the fob then it would indicate that it thinks the fob battery was low/ dead. Click to expand…

How do I get Ford Focus to go into self diagnostic mode?

The tripmeter the instrument cluster will exit the Self-Diagnostic Mode. Self-Diagnostic Mode tests, press the SET button. If the set button is depressed Self-Diagnostic Mode. Any codes will be displayed on test 9.

Where are the u codes on a Ford Focus?

The U codes I refer to are through a diagnostic tester not a cluster self test, these codes will be shown as EXXX on a cluster test and only for cluster related codes, the cluster won’t display non cluster related codes stored in other modules on the car. I hope this clarifies things for you, let me know if I can assist further.

Why does my Ford Focus SE stop running?

When this gap is eliminated by carbon deposits or the MAF sensor becomes contaminated, the computer can no longer control idle speed. Start the engine and run it until the temperature gauge in the instrument cluster reads in the normal range.

How does the Ford Focus calculate idle speed?

The air entering your engine is measured by the MAF (Mass Airflow) sensor and the onboard computer calculates the proper amount of fuel for that volume of air, as well as the position of the Idle Air Control valve for the proper idle speed. These calculations rely on the gap between the throttle body and the throttle blade.

What should I do if my Ford Focus stalls?

Reinstall the rubber duct and tighten the hose clamps securely. Test drive the Focus to verify that it no longer stalls. Use the parts cleaner spray sparingly to avoid fouling a spark plug. Excessive amounts of liquid cleaner may settle in the intake manifold and damage the engine upon start-up.

What to do if your car shuts off when stepping on the gas pedal?

In most late model cars, this problem will usually trigger the Check Engine light. A top-rated mobile mechanic will come to your home or office to determine the source and cause of the stalling condition, and will then provide a detailed inspection report that includes the scope and cost of the necessary repairs.

Are there any problems with the Ford Focus?

Hatchback and estate 1.6 TDCi Ford Focus models, manual and automatic, built between January 2006 and January 2007 may have a risk of fire unless they’ve had their cooling fans checked. Salty roads could lead to corrosion, overheating and fire if not sorted. On second-generation cars, some owners have reported water leaking into the cabin.

When did the first Ford Focus come out?

The Ford Focus has been at the top of the sales charts since its introduction in 1998. There have been three generations, the first was built until 2004, and was available in 1.4-, 1.6-, 1.8- and 2.0-litre petrol guises, or as a 1.8-litre turbodiesel. An automatic gearbox was available on the 1.6 petrol.

Why did my Ford Focus catch on fire?

Ford Focus models built between June 1998 and March 1999 might have alternator problems. There was a possibility that the alternators could develop a short circuit, overheat and cause a fire. Some cars built between September and November 1998 might have had problems with their door latches.

Why does my Ford Focus cut out on cold start?

Will cut out almost immediately on cold start, unless I give it plenty of revs. If it does cut out, almost impossible to re-start. Battery appears to turn engine over nicely, but have not had it properly tested.

What did I do when my Ford Focus engine shut off?

Parked the car, turned motor off, smelled smoke, release inside hood, more smoke coming from under hood, could not open hood up,flames started shooting out, called 911 who called fire department, several small explosions before fire department, whole front car engulfed in flames. Vehicle just turned 21000 miles, h.

E510 (or U2510) Missing or invalid security data to Powertrain Control Module. I’d say this was in injector issue, when googling the error code I came across a forum where a guy had your exact issue, he had the injectors replaced and all was fine. Click to expand… Thanks, I’ll forward that on to whoever works on this problem.

Can a Ford Focus cut out when driving?