Why is my Ford Mondeo TDCi cutting out?

However, when they were removing the fuel pump they noticed a diesel leak from one of the pipes into the pump. The connection was tightened and the car has been running perfectly for the last week. Still set me back £100 though. I have just bought a Ford Mondeo TDCi 52 plate (2003) 130bhp.

What are the common problems with Ford Mondeo engines?

Solution: A common problem with this year TDCi engine is a bad connection for the fuel pressure sensor. To rectify the problem, a gold electrical connector should be used instead of the tin connector. Problem: Engine does not run properly or fails to start.

When did I Buy my Ford Mondeo III?

Bought it 2 years ago, 2004 TDCi, and was as pleased as punch with the fuel economy and power ratio…great car. Then the problems started. I have been doing a lot of reading of posts on forums, and know this is a common problem that has driven better people than me to dispair!

Why does my Ford TDCi cut out in 5th gear?

On the test drive after blanking the EGR, the car cut out again at 65mph in 5th gear. What am I missing that needs replacing and checking? As for the glow plugs, one of them is currently snapped, so they haven’t been changed in a while.

Why does my Mondeo TDCi randomly cut out?

My mate’s 51 mondeo tdci had a similar fault. He eventually pinned it down to a blockage in the fuel tank/lines but had tried allsorts to get it fixed including spending a few hundred on new fuel pump. It could be lots of things especially on a diesel so start off with the cheapest/easiest fixes first.

When does a Ford TDCi randomly cut out?

This topic has 14 replies, 12 voices, and was last updated 8 years ago by Inbred456. 2.0ltr ford tdci randomly cuts out… Have an 07 smax and over the last 3 months it has randomly cut out…enough in it to coast to hard shoulder but everything cuts out including power steering.

When to change fuel filter on Ford TDCi?

First port of call would be to change the fuel filter, this should be done at least every second service at 25k and is cheap enough to do at every service. Your engine is the later euro 4 pug /Citroen unit.

How often should you change the oil on a 2002 Mondeo?

I have had my 2002 TDCi from new, now on 125k miles, I have had it serviced around every 10 to 11k miles without changing the oil in between. However the general recomendation would be to change as often as possible so yes, a change every 6000 or so would be worthwhile. I’ve seen on various sites the Oil to use is 5w30.

How much does it cost to fix a Ford Mondeo?

£288 million pounds a week – The ADDITIONAL cost of Brexit customs bureaucracy alone – stuff that on the side of a bus. Drop one of the odb plug-ins and see what errors the engine management system is reporting. These are a couple of quid of the bay.

What are the warning lights on a Ford Mondeo?

Find out how to mend it for free. Ford Mondeo warning lights? i have a 51 plate Mondeo 1.8 petrol. there is an orange warning light on constantly on the right hand side of the dash which i believe is ‘engine shaped’ but i don’t know what the fault is. All fluid levels are ok and the oil pressure warning light does not come on.

Do you need to Mend Your Ford Mondeo?

Mend – ford, mondeo, warning, lights Need to mend your Ford Mondeo car? Snowflake is warning that temperature is near freezing so take care when driving because there could be ice on road. how do i reset the abs warning light and service light on w reg 2000 1.8 ford mondeo seems to be a changover year and manual no help. with this problem.

What is the malfunction light on my Mondeo 2.0?

Twice now when driving along my car (2013 Mondeo 2.0 TDCi 140bhp) the engine malfunction light has come on and the car has lost power and seemed unwilling to rev. On both occasions pulling over, shutting it all off for a minute and then restarting has resulted in the car driving fine after.

When does the green light come on on a Ford Mondeo?

Green light illuminates when the adaptive cruise control system is engaged and active and goes off when the speed control system is switched off. This light comes on indicating that the engine and/or coolant temperature is too high. Continued driving will likely result in engine damage.

Why is my Mondeo business edition losing power?

I have a 2012 Mondeo 2.0 Diesel Business Edition and was getting a loss of power to start with when driving off which was probably “Limp Home Mode” and the display would say Engine Malfunction. It would also be prone to stall easily.

Can a 2 month old TDCi engine start?

I have a 2 month old TDCi that intermittantly is difficult to start. When the problem occurs the engine cranks but does not fire.There is a beeping sound from under the bonnet and the glow plug dash light flashes. At first when the problem arose the engine would fire on the second attempt but it now takes 3/4 attempts.

What should I do if my Ford TDCI is stalling?

Glow plug indicator and engine warning lights come on…..took in for investigation and there is nothing Ford can do. took in for investigation and there is nothing Ford can do. The dealer should have been able to act upon that trouble code and proceed with a repair.

What should I look out for in a Mondeo?

Hope to rejoin the blue badge club very soon in a Mondeo diesel estate, either the 140PS 2.0l or 175l 2.2l. They would be high mileage (120-140k) in the price range that I’m looking at, what should I look out for?

Which is better 2.0 or 2.2 TDCi?

The 175 2.2 is one of the best (if you can find one, it was replaced by the 162PS 2.0, and the 200PS 2.2) it can be tweaked to give more power than the 200PS (up to 220HP) and is more “tunable” than even a remapped 200PS 2.2 The Titanium x is nicely appointed/ kitted out and some real bargains can be had (compared to BMW/ Audi etc)

What to do if your Mondeo has eMLS?

If the EGR is blanked (solid plate) it can throw up EMLs, and many owners just clean out the EGR/ manifold and dissconect one of the plugs/ wires to disable the EGR The DPF can be phisically removed and deleted in software, some companies offer a remap/ DPF removal and stainless sports exhaust as a package

Why is my Ford Mondeo TDCi cutting out?