Easy tips

Should my air compressor leak air?

Should my air compressor leak air? With the compressor off, the unloader valve should NOT be leaking any air at all after the unloading process, a second or two, has completed. If you find that your compressor pressure switch unloader valve is leaking air continuously, then you have located at least one of the leaks on your air compressor. Why is my air compressor leaking from the tank? Common reasons for leaking from an air compressor are the hose, loosen parts, rust leak in the tank and more. But unfortunately, most of the people don’t know how to stop air...
Other

What happens if there is no lubricant in the gearbox?

What happens if there is no lubricant in the gearbox? If there is no lubricant in the gearbox, you could have done major damage to the engine and gearbox components by running the car. You could end up with an expensive repair and even replacement of the whole transmission system. Why do I need to change the oil in my gearbox? Changing the oil often is a proven method of avoiding corrosion. Wear of the gear teeth is something that is both inevitable and unavoidable. However, ensuring the gears have lots of clean and suitable lubricating oil can greatly decrease...
Common questions

What does DTC 1 mean on an Isuzu truck?

What does DTC 1 mean on an Isuzu truck? DTC 1 indicated that the ECMs diagnostic system is operating. If DTC 1 is not indicated, a problem is present within the diagnostic system itself, and should be checked by consulting the appropriate diagnostic chart. While engine is not running, Diagnostic Trouble Code (DTC) 15 may be flashed. What is the pressure limiter code on an Isuzu truck? Code P226 Injection Pump Pressure Supply Or Pressure Limiter Activation Code P247 Pressure Control Valve (PCV1 Or PCV2) Disconnected Or Shorted To Ground Code P248 Pressure Control Valve (PCV1 Or PCV2) Disconnected Or...
Most popular

How do you bleed an electric hydraulic pump?

How do you bleed an electric hydraulic pump? Bleeding Air From Rod Type Hydraulic CylindersOpen the air valve at the upper side of the hydraulic cylinder.Check all hoses or pipes the sure they are connected properly.Set up the hydraulic system and start it up.Extend the piston rod slowly with no pressure built up. Shut down the system and close the air valve. Why are the hydraulics on my Fiat 640 not working? fiat 640 tractor hydraulics are not working the pump is working as the remotes are going the arms will go up very slowly if the motor is revving...
Other

What is the prefix for a Caterpillar C15 engine?

What is the prefix for a Caterpillar C15 engine? You may have heard someone say, Oh, yeah, my 6NZ runs like a champ. A 6NZ is a common prefix for a single-turbo C15. Some prefixes even have reputations. For example, a C15 with a prefix of MBN is known as a Bridge motor (because it was the bridge engine from the mechanical C15 to the electronic C15 ACERT), and is often heavily criticized. How to find your Caterpillar engine serial number? Caterpillar Serial Numbers, Prefix Identification - Depco Power Systems Find your Cat model by using this serial number prefix...
Common questions

How often do you change the oil on a big rig?

How often do you change the oil on a big rig? If you wonder how often to change semi-truck oil, the answer varies between different drivers and vehicles. The average lifespan of an oil change on a truck is anywhere from 10,000 to 25,000 miles. How often should you change the oil in your boat's motor? Most boat manufacturers recommend performing an oil change every 100 hours or once a year, whichever happened first. You should always check your engine's owner's manual for a more specific interval between oil changes. What is the change interval for Mobil 1 synthetic oil?...
Other

Why is the battery on my Toyota forklift dead?

Why is the battery on my Toyota forklift dead? Your forklift battery is dead. Someone left the lights on again, or the battery gave up the ghost while trying to start your forklift. Now what? How to jump start a Toyota forklift battery? Check fluid level of the discharged battery. If low, add distilled water to the correct level. Be sure to install the caps before jump starting. Put the booster battery as near to the truck as necessary for the jumper cables to reach both batteries. Check and make sure that the trucks do not touch each other. How...
Other

Can a mobile home be converted to real property?

Can a mobile home be converted to real property? Before being tied into real property, mobile homes are considered personal property similar to an RV. Mobile homes built prior to June 15, 1976, are not compliant with HUD code standards and might not be eligible for conversion because they do not meet the minimum building standard codes required for real estate. How much does it cost to convert a bus to a mobile home? Natural wood take center stage along with a great wood stove. This bus can be yours for $15,000. That seems like a fair price for such...
Easy lifehacks

How often should you change hydraulic hoses?

How often should you change hydraulic hoses? Hydraulic hoses should last between one and two years with many lasting up to ten years, so if the hoses on your equipment are failing in less than two years, then there are external factors that are reducing their life. Why do hydraulic hoses burst? When hoses are exposed to extreme temperatures, they begin to lose their flexibility and stiffen. High temperatures cause the plasticizers in the elastomeric inner tube to break down, which then hardens and begins to crack. As time goes by, those cracks can eventually reach the outside of the...
Most popular

When does the Cummins exhaust throttle valve come out?

When does the Cummins exhaust throttle valve come out? Cummins Turbo Technologies launches exhaust throttle valve Mar 09, 2020 by Cummins Inc., Global Power Leader A new Exhaust Throttle Valve (ETV) for aftertreatment thermal management and exhaust braking has been developed by Cummins Turbo Technologies (CTT). ETV helps engine manufacturers meet stringent emission requirements. What causes a 5.9L Cummins turbo to fail? The most common point of failure for the factory 5.9L Cummins turbo is the oil seals. Often, worn seals in the center hub rotating assembly will allow the lubricating oil into the intake and also the exhaust. Engine...