When did the Ford 4R70W transmission come out?

The Ford 4R70W came in 1993 alongside the Lincoln Mark VIII luxury coupe. It has the lowest first and second gear ratios of its series, allowing for better takeoff and was designed for better gearset strength. An upgrade was provided in 1998 models and onward of a mechanical diode for extra holding capacity and longer service.

When did the tenth generation Ford F-150 come out?

Also in 2003, a special trim package “Heritage Edition” version with special badging was produced to mark the 100th anniversary of Ford trucks, available only in the 139-inch wheelbase SuperCab model. Sales of the F-150 surged in the tenth generation from 750,000 to over 900,000 in 2001 as products from General Motors and Chrysler lagged.

What kind of engine does a Ford F-150 have?

With the cancellation of the Panther platform (Ford Crown Victoria, Mercury Grand Marquis, and Lincoln Town Car) and Ford’s movement to a predominantly V6 based lineup in their F-150’s, the smooth and hardworking 4.6 liter V8 is almost extinct. The 4.6 liter engine was the replacement for the Windsor family of Ford V8’s.

What’s the name of the new Ford transmission?

While not used on all 2003 model year vehicles, the 4R75W/E transmissions eventually replaced the 4R70W/E. Newer transmissions that are referred to as 4R70E or 4R75E have modifications that compliment Fords switching to throttle by wire. The PCM was given a more powerful microprocessor and Ford added a turbine speed sensor to the transmission.

Which is Ford 4R70W transmission do I have?

Which Transmission Do I Have? The Ford 4R70W came in 1993 alongside the Lincoln Mark VIII luxury coupe. It has the lowest first and second gear ratios of its series, allowing for better takeoff and was designed for better gearset strength.

What kind of truck was the 1997 Ford F150?

1997 F-Series Model Lineup Standard, XL, XLT, and Lariat comprise the four trim levels for 1997 Ford trucks. The light-duty F-150/250 trucks were available in Regular or SuperCab format with either a short or long Styleside bed. F-150s could also be equipped with a Flareside bed.

What are the trim levels of a 1997 Ford F150?

Standard, XL, XLT, and Lariat comprise the four trim levels for 1997 Ford trucks. The light-duty F-150/250 trucks were available in Regular or SuperCab format with either a short or long Styleside bed.

When did the new Ford F150 come out?

Ford was rolling the dice with its all-new, tenth-generation F-Series for 1997. A similar redesign of the company’s hot-selling Ford Taurus for 1996 was proving to be a flop, and with such a reputation to uphold, expectations for the new truck were exceptionally high.

Are there any changes to the AOD-E 4R70W?

These changes have affected nearly every part used in the AOD-E, including two name changes, 4R70W and 4R75E. This “Update Handbook” will explain each change, the parts affected by the change, and any parts interchangeability concerns created by the change.

How big is the reverse sun gear on AODE 4R70W?

The 4R70W has 38 teeth on the Reverse Sun Gear Shell and the outside diameter of the gear is approximately 2.438”, as shown in Figure 12. (5) FORWARD SUN GEAR – The AOD-E has 30 teeth on the sun gear and the outside diameter of the gear is approximately 2.225”, as shown in Figure 13.

What kind of case bearing does a 4R70W need?

The 4R70W transmission requires a three piece closed (needles not exposed) rear case bearing that is approximately .144” thick (See Figure 9). (2) OUTPUT SHAFT RING GEAR – The AOD-E has 72 teeth on the Output Shaft Ring Gear, and the direct drum will not pass through the front side of the ring gear, as shown in Figure 10.

What kind of transmission does a 97 Ford have?

For example, if you drive 97 Ford, it has an earlier pre-97 connector but at the same time the 4.6/5.4L bolt pattern is available in this car. In 98 and up to 2000, the internals are the same, but there are little changes. What vehicles have a 4r70w transmission?

Are there any problems with the AODE 4R70W?

There is nothing electrical about reverse gear in the AODE or 4R70W transmissions. You could have a bad Low/Reverse Band, or a bad Reverse clutch pack. To top i have a 2004 f150 with 4r70w tranny. installed a factory tech plate mod shift kit last weekend. all kinds of problems now.

What are the solenoids for Ford AODE / 4R70W?

When you build, use new Torringtons if possible. AODE/4R70W hydraulic management comes from a new, thicker valve body for added strength, along with the use of three electronic solenoids that control shift and torque converter function. Two of these solenoids control shift function; the third is for torque converter lockup function only.

Is there a way to drain a 4R70W transmission?

There should be plug on the torque convertor to use in draining it. Some other Ford sites have nice how-to’s for draining it. Try the sites for Ford Trucks and Pickups. (E-mail me if you can’t find the right boards!) They basically have the same setup in the 1/2 ton F series (4.6l or 5.4l V8 with the 4R70W tranny).

What’s the difference between the AOD and the 4R70W?

The AODE/ 4R70W differs from the AOD in input. The AOD has dual input shafts (inner and outer); the AODE/4R70W has one, which splines into the forward clutch. Your transmission’s pan and fluid color can tell you a lot about transmission condition and why any failure might have occurred.

What kind of gearset do I need for Ford 4R70W?

The 4.6L V-8 needs the 2.84:1 and 1.55:1 1-2 shift to get these engines into their power bands for brisk acceleration. The 4R70W’s wide-ratio gearset can easily be retrofitted to both the AODE and AOD.

Do you need 4R70W transmission troubleshooting tips?

Are you looking for 4R70W transmission troubleshooting help, 4R70W rebuilding tips, 4R70W technical service bulletins, 4R70W diagnostics or technical information? Do you just have 4R70W questions and need some answers? Do you have diagnostic trouble codes (DTC’s) and need 4R70W troubleshooting information?

What kind of oil does a Ford 4R70W use?

Once you step up to the V10 or the PSD, you will NEED the 4R100. The 4R70W is used on Crown Vics/Mustangs that pump out more than 400+ hp and torque. So its all good. The stock oil to air tranny cooler should be adequate, when Ford installs coolers from the factory, they pick out the decent stuff.

Ford 4R70W Technical Speci˜cations 1993 1/2: Ford AODE transmission introduced for passenger cars. Ford also introduced the 4R70W transmission the same year which is basically the same transmission except has lower gear ratios in 1st, 2nd, reverse and more overdrive ratio for economy.

Is there a warranty on a Ford 4R70W?

JASPER® remanufactured Ford 4R70W/4R75W transmissions are built to meet, or exceed, OEM measured standards and have a 3 year/100,000 mile nationwide, transferable parts and labor warranty. Click here for complete warranty information.

What should I replace in my Ford AODE 4R70W?

Adjacent is the converter clutch solenoid, which receives a pulse input for smooth engagement. This TCI Automotive transmission overhaul kit has just about everything needed to complete an AODE/4R70W rebuild. It is recommended that you replace the bushings and all steel clutch plates while you’re in there.

What kind of sensor does a Ford 4R70W have?

To better tie the engine, vehicle, and transmission functions together, Ford went to an output shaft speed sensor and manual shift lever sensor, along with a multiplex electrical connector to simplify service. As the 4R70W evolved to the 4R75W, an input shaft sensor was added.

Which is the best 4R100 or E4OD transmission?

4R100 and E4OD Transmissions Level 3 Enforcer, turn your 4R100 or E4OD transmission into a much stronger transmission. 4R70W Transmission: 4R70W AODE Level 3. Red Direct Power Pack, Diode Kit, Black Carbon Fiber Band, Billet Shaft, 10 Inch Converter . . . . 4R70W RAYBESTOS PERFORMANCE STAGE-1 RED CLUTCH MODULE #RCPS-35. 1994-UP.

When did the Ford 4R70W transmission come out?