Where is the fuel pump on a Saturn?
Where is the fuel pump on a Saturn?
Climb underneath the vehicle and locate the fuel pump. Follow the fuel line from the tank as the line bends at a 90-degree angle and approaches the motor carriage. Look for a small, cylindrical part jutting from the fuel line, accompanied by mounts on both sides and a valve on the tank side.
How do you close the fuel line on a Saturn?
Twist the fuel line valve near the fuel pump clockwise with a crescent wrench until it tightens. This will close the fuel line from the gas tank. Use a 12 mm socket wrench to remove the electrical connection on the pump. This is secured with a simple bolt. Place a bucket underneath the fuel pump to catch any leftover gasoline that drips out.
Where is the fuel pump shut off switch located?
On Ford, Peugeot, VW, Citroen, Vauxhall, Subaru, Renault, Toyota and Mazda, inertia switch location is usually on one of the following two hidden places: Behind or below glove compartment, sometimes hidden under the carpet; On the driver side, between the footrest area and door, sometimes hidden under the carpet.
Where is the test point for a fuel pump?
Hook the pressure gauge to the fuel pump test fitting. Locate your fuel pump test point, which is usually near the fuel injectors, and locate the point at which the pump hooks up with the filter injector rail. There should be a separation joint or a test port, where the pressure gauge attaches.
Climb underneath the vehicle and locate the fuel pump. Follow the fuel line from the tank as the line bends at a 90-degree angle and approaches the motor carriage. Look for a small, cylindrical part jutting from the fuel line, accompanied by mounts on both sides and a valve on the tank side.
Twist the fuel line valve near the fuel pump clockwise with a crescent wrench until it tightens. This will close the fuel line from the gas tank. Use a 12 mm socket wrench to remove the electrical connection on the pump. This is secured with a simple bolt. Place a bucket underneath the fuel pump to catch any leftover gasoline that drips out.
How do you reassemble a 2000 Saturn?
Reassemble the fuel tank and secure it back onto the 2000 Saturn. Raise the Saturn above the jack stands. Remove the stands and lower the vehicle to the ground. Reconnect the negative cable to the battery. Switch on the fuel pump relay fuse.
Why does my Saturn fuel pump keep leaking?
If you are experiencing problems while driving your Saturn car such as sudden bursts of acceleration when pressing on the gas pedal steady or if the fuel pump is making noise and/or leaking, then the pump may be faulty and need replacing.
How do you change the fuel tank on a Saturn?
Hammer the lock ring on top of the fuel tank loose with a brass punch. Do this carefully to avoid damaging the piece, tapping the ring counterclockwise. Pull the old assembly out of the tank and set the new one inside. Reassemble the fuel tank and secure it back onto the 2000 Saturn. Raise the Saturn above the jack stands.
If you are experiencing problems while driving your Saturn car such as sudden bursts of acceleration when pressing on the gas pedal steady or if the fuel pump is making noise and/or leaking, then the pump may be faulty and need replacing.
