Is there steering issue on my Dodge Ram 3500?

I’m trying to finally diagnose a long-standing steering issue on my 2000 Ram 3500 diesel 4×4 with an automatic transmission. I know these trucks are plagued with steering problems and I’ve already replaced some parts, I’d just rather not keep replacing things at random to fix this.

Why is the steering on my Dodge truck loose?

The steering on my truck is loose and the truck wanders a lot at highway speed. When driving I have to make constant small corrections to keep it headed straight. I’ve replaced the tie rods, track bar, and steering dampener over the past couple years as well as added a stabilizer bar. None of these have corrected the problem.

What causes a Dodge Ram to wander off the road?

Scrub radius is crucial and can be a problem, and if your front wheel offset is incorrect for the loads you describe, that could prevent the wheels from returning to center and could easily cause wander. Dodge Ram front ends are hypersensitive to wheel width and offset.

What should the Steering caster be on a Dodge Ram?

An increase to 5- or even 6-degrees would not be adverse and may alleviate some of this tendency. (Watch for tire wear if you attempt this caster increase and rotate tires regularly. You have HD steering knuckle ball joints, so that’s less of concern. Excess caster does load the ball joints.)

What to do if your steering wheel wanders?

All 3 components showed wear and all 3 components were replaced. Had the toe reset and now the truck goes straight and does not wander. The steering is crisp and when the steering wheel is turned all the joints and front wheels turn instantly. I recommend getting under the front end while someone turns the steering wheel.

What kind of steering issue do I have?

Enter your ride HERE to be a part of this month’s Ride of the Month Challenge! I’m trying to finally diagnose a long-standing steering issue on my 2000 Ram 3500 diesel 4×4 with an automatic transmission.

What’s the difference between a gas 4×4 2500 steering gear?

Get an alignment, and make sure that the toe is NOT set to 0 degrees, as having tires that are dead ahead will cause a vehicle to wander and feel “darty”, as if something were loose, or it was in “ruts”…. hope this helps. What’s the difference between a gas 4×4 2500 steering gear and a diesel 4×4 2500 steering gear?

Why is my Dodge Ram hard to steer?

The uppers must have a slight up and down play… If seized your 04 ram 2500 will dangerously dart especially over any bumps!!! Make sure all steer joints are tight, sames with wheel bearings and wheel allignment. My 98 Ram 1500 is hard to steer.

What kind of steering shaft does a Dodge Ram have?

000951 Borgeson 2003 – 2008 2500 & 3500 4WD Models This heavy duty shaft consists of two precision needle bearing u-joints, a vibration reducer and a telescoping shaft which corrects the classic Dodge “steering wander”. Tighter steering and better handling is felt as soon as..

Which is the best steering damper for Dodge?

I ONLY recommend the Dodge Wobble Resistant DTP Dual Steering Damper, because it seems to be tighter and work better for stopping Ram Death Wobble than the other manufacturers of steering dampers and stabilizers on the market (and I’ve tried them all, trying like hell to get rid of a Death Wobble problem years ago).

Is there an upgrade for the Dodge 2500?

Dodge finally admitted to the issues with their gearboxes for the 2003-2008 HD Rams. Dodge/Mopar has released a gearbox upgrade for the 2003-2008 2500 and 3500 Rams that comes complete with an extreme duty gear box, pitman arm, and upper tie rod.

How does a Dodge Ram steering box stabilizer work?

They are enough to be very tiring and annoying to drive, and make you look like a DUI candidate. This product is designed to solve the “very common” steering and handling problem found on Dodge Ram trucks/van. 1) This is done by adding an additional bearing to the bottom of the steering box sector shaft (opposite of the pitman arm).

How can I fix loose steering on my Cummins diesel?

You can also have your allignment checked, and make sure they adjust your caster, Most shops will cheat and only adjsut toe. As caster will pull away from bumps and slight convexes in the road (crown). Anyways, i hope this helps.

What kind of steering do I need for a 1998 Dodge Ram?

The MOOG DS1458 Left Inner Tie Rod for your 98-99 Dodge Ram 2500 4WD incorporates proven design and engineering features for like new steering, ease of installation and longer life. MOOG is the preferred steering and suspension parts brand of professional technicians and NASCAR Crew Chiefs.

What kind of steering stabilizer do I need for my Dodge Ram 3500?

The BD-Power 1032004 Steering Box Stabilizer (SBS) eliminates steering wander and wobble in your 1994-2002 Dodge Ram 2500/3500 4WD. Most steering issues are caused by excessive shaft play in the steering box of your Dodge Pickup.

What kind of steering hose does a Dodge Ram use?

The Borgeson 925116 Power Steering Hose Kit for your 1997-2002 Dodge Ram 2500/3500 features OEM Style Rubber hoses and fits Diesel models with Hydro-Boost Brakes. Includes all pressure and return hoses for both the power steering and Hydro-Boost brake system.

When does a Dodge Ram have a shudder?

When subjected to this vibration, the vehicle experiences a shudder type disturbance, generally occurring less than 25 mph. This disturbance will increase as the suspension moves further from its design load (typically two front passengers).

Is it normal to have a shudder at take off?

The genral consensus is that its not tranny related (with 1000 miles on the truck of easy driving I would hope not) but that its Axle swap, ujoints, carrier, etc.. Most dealers say it is normal. Several owners have said they have had it since new and simply live with it?

What should steering axis inclination be on Dodge Ram?

Dodge Ram front ends are hypersensitive to wheel width and offset. Also, Steering Axis Inclination (SAI) is very important for return-to-center and should certainly be checked in your case. Beyond this, I don’t want to upset anyone’s plans, but I am dead set against a cab over camper combined with a travel trailer.

When did the rock solid ram steering kit come out?

Overview of our “Rock Solid Ram Truck Steering” upgrade kit for the 2nd Generation Dodge Ram Trucks, years 1994-2001.5. This kit fixes the bad lower OEM bearing in the steering column, eliminating steering slop & play and greatly increases precision to our Ram trucks steering.

What are the alignment specs for a Dodge Ram?

Here are the alignment specs. Ram steering specs Also, its important to note that over the years, its been pointed out and discovered that the 2nd gen Dodge Rams respond VERY well to as much negative caster as you can get.

Why is the camber off on my Dodge Ram 2500?

Discussion in ‘ Heavy Duty ‘ started by Kev12, Apr 19, 2018 . finally found out why my 2500 has been going off the road when steering wheel is straight, camber is off.

Why are the bolts on my Dodge Ram too long?

Tried to mount it and the bolts that had been ordered initially were too long. They were the bolts that Dodge calls for. Now they are having to contact Dodge and try to find out why the bolts they recommend are too long. I think this could have been the problem that caused the most recent box to come loose.

What kind of vibration does a Dodge Ram have?

Have a 2017 1500 limited with the air suspension and 17k miles. I have suffered since new with vibrations above 65-75 mph. I have had the tires balanced several times. The dealership said that they balanced the tires…again and all was well they said.

When to change the steering fluid on a Dodge Ram?

Change your power steering fluid ASAP, before its too late.Your old fluid isnt lubeing its foaming. Metal to metal contact isnt good. Click to expand… I have a 2001 3/4 ton Dodge Ram and I just put in a new Gearbox and I made the adjustment on the steering so I had no play.

What kind of bushing does a Dodge track bar use?

Our SuperDurometer Track Bar Bushings are about TWO TIMES as hard as the typical polyurethane bushings that come in most aftermarket track bars, (which typically are made by Daystar or Energy Suspension for most of the various aftermarket manufacturers).

Why does my steering wheel shake in my Dodge Ram?

However, a front-end that’s out of alignment, loose fasteners, improperly balanced tires and even over-or-under-inflated tires can also contribute to this uncontrollable shaking of your steering wheel. To ensure your ’94-’08 Ram never enters the equivalent of its steering death throes, keep close tabs on the vital components mentioned below.

What is the gear ratio for a Dodge Ram 3500?

The Nitro Gear and Axle GPRAM-3.73 Gear Package Kit is a complete kit that provides your 2003-2010 Dodge Ram 2500/3500 4WD (Diesel Only) with a 3.73 gear ratio. Nitro Gear and Axle stands behind their products and backs this kit with a 2 year limited warranty.

How big of a shock does a Dodge Ram need?

Y you think they make dual shock it’s for 2500 and 3500 trucks. I have contacted tuff country, sky jacker, etc, and if lift in with bigger tire and wheels, foget it. The shocks can’t control the 110 pound tire, it just crashes into bumps etc.

I have a Dodge Ram 1500 WS with a 3.9-liter V6. It has an annoying vibration between 45 and 55 MPH. Symptoms are a lot like bad U-joints, but the U-joints are fine and the truck only has 4000 miles on it. I’ve had the drive shaft rebalanced and that helped a little, but the vibration is still there.

What kind of steering shaft does a 1994 Dodge truck have?

The Borgeson 000945 Steering Shaft for your 1994 Dodge Truck features a heavy-duty telescopic design that connects from the factory column to the steering box. Includes one billet universal joint and vibration reducer universal joint.

Which is the best steering pump for a Dodge Ram 3500?

The Borgeson 800328 Hi-Flow Power Steering Pump for 94-02 Dodge Dodge Ram 2500/3500 Cummins is a direct replacement for your existing pump. This pump has the out-put pressure/flow calibrated to 1450-1550 PSI and 3.5 GPM to provide your Ram with all of the power it’s steering needs.

Where is the power steering fluid in a Dodge Ram?

Power steering fluid reservoir located to the right of the engine, near the upper radiator hose. Use a turkey baster to remove the old power steering fluid from the reservoir. Turn the steering wheel left and right to remove any remaining fluid in the reservoir.

Is there a steering damper for Dodge Ram?

The Mopar 2nd Generation Dodge Ram Pickup Steering Linkage Upgrade Kit from KLM Performance includes the following MOPAR parts: NOTE:There is no steering damper included in this kit. KLM Performance recommends the installation of a new steering damper be installed with this steering upgrade kit.

Is there a steering upgrade kit for Dodge Ram?

This Mopar 2000 to 2002 Dodge Ram Steering Upgrade Kit is a complete kit with all the parts necessary for the installation of this steering upgrade kit into the DANA 60 front axle on your Second Generation Dodge Ram truck. NOTE:There is no steering damper included in this kit.

What kind of steering problem does Dodge Ram have?

I have a 2004 Dodge ram 2500 5.9 turbo deisel. I have replaced tires, up/low ball joints, tie rod ends, axle shaft ujoints, brakes. The truck seems to wander or dart from side to side.

Why are front wheels tied together on Dodge Ram?

This is Dodge’s solution to the problem that doesn’t exist. These kits tie the front wheels together eliminating independent toe in and out. The idea is to cut down on tire wear and death wobble. In our experience this kit will not make up for other worn front end components such as steering gear..

What’s the fix for my Dodge Ram truck?

Ram Truck Steering Fix: Upgrade fixes steering play & wander on 2nd Gen Dodge Ram Trucks. If playback doesn’t begin shortly, try restarting your device.

Is there steering fix kit for Ram Trucks?

” The Rock Solid Ram Truck Steering Fix kit has given my truck a very solid feel to the steering. The truck feels like it’s new. Very confidence inspiring”

What is the diagnostic code for engine stall?

Diagnostic trouble codes P0120, P0121, P0122, P0123, and P0124 are what will commonly appear. The engine can stall for no reason and without any warning. This happens when the TPS gives incorrect information to the ECM. The engine can stall at high speed, at low speed, or even at idle.

Can a car stall with a bad throttle position sensor?

The engine can stall for no reason and without any warning. This happens when the TPS gives incorrect information to the ECM. The engine can stall at high speed, at low speed, or even at idle. A faulty throttle position sensor will not let your car accelerate normally. Though this doesn’t happen all the time.

Is there a 2004 Dodge Ram that will not shift?

This was a major update including an all new frame, suspension, powertrains, interiors, and sheet metal. 2004 Dodge Ram transmission will not shift? I was riding at normal speed and something sounded like a pop, transmission down shifted to 3rd gear, just as if you had changed to tow mode. Rpms went up and trans would not shift, stayed in 3rd gear.

What’s the best steering box brace for a Cummins diesel?

There are plenty aftermarket steering box braces-they are REALLY good for your handling. As to the hard steering, best thing IMO is a high flow ps pump. Assuming something else is not wrong-like maybe a bad steering damper shock like Lucky said.

What can I do to get my steering back to normal?

Replacing coil springs or adjusting torsion bars can bring alignment back into specs. WOOF! Even if the front wheels are perfectly aligned and tires properly inflated, you may still have to steer constantly in one direction or the other to keep the vehicle going straight up the road.

What kind of steering does a ram truck use?

98-99 Ram 2500/3500 trucks came with either the light duty inverted Y steering or the optional heavy duty T steering. The drawing below shows the 94-97 light duty inverted Y steering and the 98-99 heavy duty T steering. The HD steering option was only available for the 98-99 model trucks.

Can a 94-97 Ram have steering wobble?

If you own a 94-97 Ram 2500/3500 4×4 then your probably aware of the steering related issues these trucks can have, most notably the dreaded “death wobble” and steering wander. You may have replaced all the ball joints, tie rod ends, track bar, and even the control arm bushings on your truck but still have wandering or death wobble issues.

What kind of steering does Dodge Ram 2500 use?

The factory Y style steering. This kit bolted right up to my 2001 ram 2500 with the diesel. In all honesty, it didn’t take away much play because I believe my previous steering linkage was in good condition, but nonetheless it still helped. Next step will be a steering box, as I already did a 3rd gen track bar.

What’s the problem with the steering on a ram truck?

On 2nd Gen trucks, 1994-2002 the fault lies hidden deep in the steering column lower bushing: it’s designed with too much play from the start & prone to wear quickly. ” The Rock Solid Ram Truck Steering Fix kit has given my truck a very solid feel to the steering. The truck feels like it’s new.

Where is the power steering pump on a 1998 Dodge Ram?

1998 Dodge Ram with the Diesel motor. Power steering pump is located on the back of the vacuum pump. Symptoms of it failing are a noisy (think Ford F series in the mid 80’s) pump, foaming pump oil and a loss of breaks. I changed it myself over 2 days total was about 4 hours but that had a lot to do with the 20F weather.

What kind of power steering pump do I need for Rams?

Fixing rams .com has o kit with instructions on how to rebuild vacum pump.I did both pumps for less then $200.00.Use reman power steering pump from carquest.

Is there steering issue on my Dodge Ram 3500?