How to troubleshoot the air conditioning in a Ford Taurus?

It can be found under the trim panel of the dashboard on the passenger side if the car. Unscrew three retaining screws and pull the blower motor off the of its mount. Start the engine of the car and allow it to run while looking at the compressor. Look for obvious signs of malfunction. Touch both of the hoses attached to the compressor.

Where is the fuse box on a Ford Taurus?

If they seem to work properly, but have no effect on the air at all then a fuse will need to be replaced. In a Ford Taurus, the fuse box is located near the brakes below the steering wheel. Pry off the panel and replace fuse number 12 with a replacement fuse.

What does it mean when your AC compressor does not spin?

It is an ominous sign when the clutch engages but the compressor does not spin. Changing the compressor clutch could be the only solution in this case. A bad AC compressor clutch needs immediate fixing. A delay can cause serious damage to the air conditioning system and the engine.

Where does the power go in an air conditioner compressor?

In other vehicles the power flows through the air conditioning switch to the fuse and from the fuse through the low pressure and evaporator temperature sensor to the clutch coil. It’s important to note that air conditioning compressors need a constant supply of oil to prevent catastrophic failure.

How do you install a bypass pulley on an AC compressor?

Then remove the compressor drive belt. Remove the compressor, but keep the mounting bolts. Place the bypass pulley in place of the compressor and install the bolts to the proper torque. Re-install the compressor belt and tension properly.

How do I add refrigerant to my AC compressor?

AC compressor refrigerant oil capacity is usually stamped on the compressor. After you add oil to the ac compressor you should cycle the ac compressor by rotating the clutch plate three to four times. Remember to check the compressor to see how much refrigerant oil is recommended.

How to check oil level in AC compressor?

Examine the oil level in the compressor. Add oil if the level is below the normal point. Check the owner’s manual to check the correct instructions for checking up the compressor oil and level and filling it up. Unplug the single wire connector on the front side of the compressor.

How can I Check my AC compressor clutch?

Use a digital voltmeter to measure the ground and voltage of the battery at the detached connector cable. Go on to check the fuse if you cannot read the voltage readings. Move on to the clutch relay if the fuse turns out fine.

Why does my car blower motor not shut off?

If you have a vehicle with climate control system and a variable speed blower motor and the blower motor won’t shut off and stays on HIGH with the car turned off and the key out, chances are the blower motor motor control processor is toast or the HVAC control module is damaged.

What happens when you turn off the AC blower?

It doesn’t blow out the defrost vents, it just shuts off. There is no change in the AC controls, they all continue to think the AC blower is on. Turning the AC off/on with the power button does nothing. And as suddenly as the blower shuts off, 30 seconds to a minute later it starts back up on its own.

What causes a fuse to blow on a blower motor?

If the blower motor relay develops any sort of problem that hinders its ability to properly limit and distribute power, it may cause the blower motor fuse to blow. Any sort of electrical spikes or excessive current from a bad relay will blow the fuse and cut power in order to protect the system.

What causes a bad or failing blower motor relay?

Blown fuses. One of the first symptoms of a bad or failing AC blower motor relay is a blown AC blower motor relay circuit fuse. If the blower motor relay develops any sort of problem that hinders its ability to properly limit and distribute power, it may cause the blower motor fuse to blow. Any sort of electrical spikes or excessive current…

What to do if your cooling fan won’t turn on?

Pull the cooling fan relay out of the box. Replace the cooling fan relay with a new one. A stuck closed relay is the only thing that can operate the cooling fan continuously with the key off. The computer looses power with the key off and the same applies to the coolant temperature sensor.

Why does the radiator fan not come on when the AC is on?

In order for the AC Condensor to do its job it must stay as cool as it can. As for the engine coolant temp sensor, if the coolant is not hot enough to make the fan come on, then there is no need for the fan yet and there is no problem.

When does a computer turn on a cooling fan?

When the temperature exceeds a specific value — usually 215 degrees Fahrenheit — the computer will turn the fan on. The operating components in the cooling fan circuit include the cooling fan fuse, relay, coolant temperature sensor and the computer.

Why are the cooling fans not working on my car?

1. Engine running hot 2. Cooling fans do not function 3. Cooling fans stay on at all times Average rating from 129,472 customers who received a Vehicle Engine Cooling Inspection. Most modern vehicles use electric cooling fans to help pull air through the radiator so that it can keep the engine cool.

What are the symptoms of a bad cooling fan relay?

1. Engine running hot One of the first symptoms commonly associated with a bad or failing cooling fan relay is an engine that runs hot or overheats. If you notice that your engine is running at higher temperatures than normal, that may be a sign that the relay is not functioning properly.

What should I do if my radiator fan is not working?

A blown fuse is no big deal, and changing one does not cost a lot of money. If your car’s radiator fan is non-functional, check your car’s user manual and locate the fuse for the radiator fan controller or the fan. The fan itself often uses a big fuse of around 50A, while there might also be a separate small fuse to the fan control module.

When does the radiator fan kick on in a 2010 Ford F150?

2010 Ford F150, Radiator fan seems to be running on high more than it should. Fan kicks on about 30 seconds after vehicle is started and is extremely loud. Even kicks on when its a cooler day. Also stays on when driving down the highway.

Why does my car AC keep blowing cold air?

If you feel that there is a meager amount of air blowing through the vents, it could absolutely be a clogged air filter. When you turn the heat controller on the AC control unit, there needs to be something that controls the heat inside the car.

What should I do if my AC is not blowing cold air?

When the actuators are not working, you will either receive only cold air and no hot air or hot air but no cold air. In such a case, take your car to an auto specialist who will fix the blend air door. The average cost will come between $130 and $530. The parts itself cost about $85 but the labour cost varies from vehicle to vehicle.

What to do when your car AC is running?

Check the radiator fans to make sure at least one fan turns one when the AC is switched on. However, some cars operate both fans at low speed while driving and switch into high speed mode when the AC is running. So get tricked into thinking your fans are ok simply because they’re running.

Why is my Ford Taurus air conditioner not cold?

Most of the time, when your Taurus’s air isn’t blowing cold enough, it is going to be a lack of refrigerant causing the problem. We recommend having a professional recharge your A/C if it does end up being a coolant issue.

Why is my car AC not blowing cool air?

It’s a nightmare to find your car AC not blowing cool air in burning summers. But, people generally face this issue. Your car includes various parts that are interconnected with each other. Therefore, even if you have recharged the AC of your vehicle, the issue in other car machinery can affect its working too.

Where is the fuse on the Ford Taurus air conditioner?

Adjust the air controls on the dashboard. If they seem to work properly, but have no effect on the air at all then a fuse will need to be replaced. In a Ford Taurus, the fuse box is located near the brakes below the steering wheel. Pry off the panel and replace fuse number 12 with a replacement fuse.

What should the pressure be on the AC to blow cold air?

Keep checking the pressure gauge to confirm if you don’t overfill. The ideal pressure is 40 psi. Once the refrigerant is filled, head inside the car and with the thermometer placed inside one of the AC vents, note the temperature. An ideal AC should blow cold air which is about 28 degrees.

Why does my 2002 Taurus have no heat?

Had similar problem with 2002 Sable where heat was only cool at best. Had core flushed and no change. Reached down by the fire wall and felt the in hose and out hose going to the heater core to determine if both were hot. They seemed to be, but what I found was a small leak in one of the heater hoses on the fire wall.

What kind of heater does a Ford Taurus use?

A year ago, I installed an “EVERCO” heater control valve in the bypass line, controlled manually by a choke pull off cable from inside the cabin, by the driver. Not easy to install this, but I did er’.

Why does my Ford Taurus air conditioner keep blowing hot air?

Video Description When the air conditioner in your 2002 Ford Taurus starts blowing hot air, you likely have a freon leak. Recharging the freon in your AC system is an inexpensive and easy first step to restoring the cooling capacity of your A/C system.

How to add refrigerant to a 2002 Ford Taurus?

2002 Ford Taurus SE 2-Valve 3.0L V6 Change a rear blinker Don’t send mixed signals – if your turn signal doesn’t blink, or blinks rapidly, you likely have a burnt out bulb 2002 Ford Taurus SE 2-Valve 3.0L V6 Change a flat tire Learn where your spare tire and jack are located before you need it on the side of the road

What kind of a / C system does a Taurus have?

The A/C system in your Taurus consists of a compressor that is belt-driven, an evaporator and freon. If there is a problem with your compressor or evaporator, adding freon will not restore cooling.

What are the most common Ford Taurus problems?

Most Common Ford Taurus Problems. The engine oil pan gasket can develop a leak. The engine may misfire and/or buck while driving at freeway speeds with no fault code stored in the powertrain control module (PCM). Engine Stalling and/or Hesitation on …

What kind of stereo does a Ford Taurus have?

It competes with the Chevrolet Impala, Hyundai Azera and Toyota Avalon. Ford also offers a high-performance all-wheel-drive Taurus SHO. A new Sony premium stereo is standard on Limited and SHO models. SHO stands for Super High Output, and this model is the luxury and performance leader of the Taurus lineup.

How old does a 2017 Ford Taurus have to be to be blue?

The 2017 Ford Taurus has not been tested. Gold Certified: Ford models up to 6 years old with less than 80,000 miles Blue Certified: Fords and many non-Ford vehicles up to 10 years old with less than 120,000 miles Disclaimer: See your dealer for warranty coverage details.

What kind of refrigerant do I need for my 2005 Ford Taurus?

There are different models of the 2005 Ford Taurus, such as the SE and SEL, and each has a different recommended refrigerant level. Contact your local Ford dealership and ask the service department what the recommended refrigerant level is for your specific model of Taurus.

How long does refrigerant last in a Taurus?

Refrigerant has a lifespan of up to 10 years, so the air conditioner in your automobile should last a long time before you need to recharge it. Recharging the air conditioning system in your Taurus yourself will save you the cost of having a mechanic do it for you.

Why are my cooling fans not turning on?

If the compressor is running long enough to build heat in the high side of the system, and the cooling fans don’t turn on, I would begin finding the fan relays and add power to the appropriate circuit to see if the fans turn on at all. This will require a wiring diagram.

Why does my PCM not turn on the fans?

You are looking to see if the PCM sends power to one or both relays to turn on the coolant fans. This should happen as the high side of the system approaches 214 psi. If it exceeds this amount of pressure and the system doesn’t turn on, one of the sensors in the system that the PCM uses to know when to turn the system on and off has failed.

How much does it cost to replace an AC compressor in a Ford Taurus?

Upfront and transparent pricing. Our certified mobile mechanics can come to your home or office 7 days a week between 7 AM and 9 PM. Ford Taurus Car AC Compressor Replacement costs $1150 on average. What is the AC Compressor all about?

What should I do if my AC compressor is faulty?

Check for power and ground at the compressor. If compressor is found to be faulty, remove all of the refrigerant. Remove the compressor, receiver drier, orifice tube, and/or expansion valve. Flush all foreign materials from the AC System. Install new compressor, receiver drier, and orifice tube. Evacuate and recharge the AC system.

What are the best parts for a Ford Taurus?

Control your car’s speed and sound with hot high Ford Taurus Performance Parts. High performance Ford Taurus part like car exhaust mufflers and headers can transform your Ford Taurus into a cherry customized driving machine. Plus, these custom car parts can add up to 20+ HP to your car, truck or SUV.

What kind of problem does a Ford Taurus have?

Transmission troubles are widely considered the bane of Ford Taurus owners because they crop up fairly often and cost a lot to fix. The most commonly reported Ford Taurus transmission problem involves the transmission failing, which can prove dangerous if you’re driving.

Why does my car heater keep blowing cold air?

If one of the heater hoses (there are 2 of them, approx 1 inch in diameter) going from the engine to the firewall right underneath the windshield is hot when the engine is warmed up but the other hose is still cold or maybe only luke warm then the heater core is plugged up and needs to be replaced. Good Luck, Kenny/MrBlueOval

What should I do if my heater is blowing cold air?

Check the radiator, it’s probably bone-dry. if not, then check the heater core as it might be plugged up.

Where is the air conditioner blower motor located?

Turn the air conditioning on full blast. Listen for the accompanying sound of the blower motor. If the sound does not increase with increased air or there is no sound at all then the blower motor will need to be replaced. It can be found under the trim panel of the dashboard on the passenger side if the car.

Who was responsible for the quality of the Ford Taurus?

Deming told Ford that management actions were responsible for 85% of all problems in developing better cars. Based on Deming’s advice, Ford management was charged with primary responsibility for automobile quality. Ford also adopted a quality culture employing statistical process control across all aspects of automobile design and manufacture.

When was the last year the Ford Taurus was made?

Ford Taurus. It was discontinued in 2006, with production initially ending on October 27, 2006, and 2007 being the last model year. Ford had decided to replace the Taurus with the fullsize Five Hundred and midsize Fusion sedans, as well as replacing the Taurus wagon with the Freestyle crossover SUV.

When did the Ford Taurus front wheel drive come out?

Launched on December 26, 1985, as a 1986 model, the front-wheel-drive Taurus was a very influential design that is credited with saving Ford from bankruptcy, bringing many innovations to the marketplace and starting the trend towards aerodynamic design for the American automakers in the North American market.

When was the millionth Ford Taurus sold?

In 1989, the millionth Taurus was sold after three years in production. The 1986 Taurus continues to receive positive press, recognizing its lasting influence on the automobile industry. It was number 6 on USA Today ‘s 2007 list of “25 Cars That Made a Difference”, and was named a “Future Classic” by Autoblog.

When was the last Ford Taurus made in Atlanta?

Production ended on October 27, 2006, as Ford idled the Atlanta plant, as part of its ” The Way Forward ” restructuring plan. The last Ford Taurus rolled off the assembly line around 7:00am, destined for delivery to S. Truett Cathy, owner of Chick-fil-A. Mr. Cathy’s original restaurant was located across from the Ford Atlanta plant.

When do you need to replace the throttle position sensor?

As soon as you see a mix of these throttle position sensor symptoms, you should test the TPS and if it isn’t functioning properly, it needs to be replaced. Unfortunately, a TPS cannot be repaired as it is a tiny sensor but the good news is that a new sensor “usually” isn’t too expensive so you can get back on the road soon enough.

What causes idle surges on a car ECM?

Idle surging can be caused due to other issues in the car, but if it happens in conjunction with other throttle position sensor symptoms, the culprit is often the TPS. At idle, the ECM will not get the correct information and the throttle will variate randomly causing idle surges.

What is the climate control system on a Ford Taurus?

Copyright  2002, Ford Motor Company Last updated: 2/16/20062003 Taurus/Sable, 8/2002 412-00-2 Climate Control System – General Information 412-00-2 DIAGNOSIS AND TESTING(Continued) Manual Climate Control Vacuum Schematic Item Part Number Description Item Part Number Description

How to diagnosis and test a Ford Taurus?

412-00-1 Climate Control System – General Information 412-00-1 DIAGNOSIS AND TESTING Climate Control SystemSpecial Tool(s) Refer to Wiring Diagrams Cell 54 for schematic andRefrigerant Leak Detector connector information.216-00001 or equivalent Refer to Wiring Diagrams Cell 55 for schematic and connector information. Special Tool(s)

What is the vacuum number on a Taurus?

V = vacuum NV = no vacuum 2003 Taurus/Sable, 8/2002 412-00-4 Climate Control System – General Information 412-00-4 DIAGNOSIS AND TESTING(Continued) Electronic Automatic Temperature Control Vacuum Schematic Item Part Number Description Item Part Number Description

What does DTC stand for in Ford Taurus?

(DTC) INDEX or the REMOTE CLIMATE used as a plug when it is necessary to plug one end of the vacuum hose for leak test purposes. CONTROL MODULE DIAGNOSTIC TROUBLE CODE (DTC) INDEX to continue 3. As pinpoint tests and measurements are being diagnostics. carried out, be sure to inspect for any 8.

Why does my Tauri have a cooling fan?

If not, the engine will overheat due to heat from the A/C condenser and the additional engine strain. Many Sable and Tauri (plural ) cars used a module to control various functions including cooling fan, A/C, fuel pump, etc. This module is essentially a box of relays with a fancy title like Integrated Controller Relay Module, etc.

Where are the radiator hoses on a Taurus?

Open your Taurus’ hood and locate the two radiator hoses. The hoses are black, made of rubber and connected to the radiator. Touch the top hose and notice if it feels hot. Look for the bottom radiator hose connected to the bottom of the radiator. Touch this hose and notice if it’s cold or warmer than the top hose.

Why does my Ford Taurus stall at idle?

Problem With Idle Air Bypass Valve May Cause Engine Performance Problems Engine Stalling and/or Hesitation on Acceleration due to Faulty Idle Air Bypass Valve on Ford Taurus Problem Description

What’s the cost of a Ford Taurus idle valve?

This valve helps the vehicle idle steady when the accelerator pedal is not pressed. The average cost for a Ford Taurus Check Engine Light Diagnosis & Testing is between $88 -$111. Learn More My Taurus want stay running unless I keep my foot on the gas.

Is the 1997 Ford Taurus in good shape?

Tires were new two years ago. Recently checked out. In good shape. Great car for beginner. Needs to be cleaned. Selling as is. Ignore your previous judgements of this car or of Ford as a company. This car designed with comfort in mind without paying a fortune for it.

Is the Ford Taurus reliable after 171, 000 miles?

It has 171,000 miles and it still runs good. i say it is pretty reliable. And it does make a dfference if a 2001 or a 2006 has the same high mileage, out of the 2, the 2001 is more reliable because the miles wasn’t put on the vehicle as fast as the 2006 vehicle. 31 people found this helpful. It all depends on the year, and the engine.

How old is the transmission on a Ford Taurus?

I have spent less than $700 in repairs in the past 9 years on this vehicle. The transmission is starting to slip and it is on its original fluid from 1996. I feel that if the car had been better serviced it would last an easy 20 years. 38 people found this helpful. Update.. I think the timing chain cover gasket is going bad on my car.

How to add Freon to a 2002 Ford Taurus?

How to add freon to your 2002 Ford Taurus: hook up the can of refrigerant (likely r-134a) to the low pressure port. When your compressor kicks on, add freon to the correct pressure.

The A/C system in your Taurus consists of a compressor that is belt-driven, an evaporator and freon. If there is a problem with your compressor or evaporator, adding freon will not restore cooling.

What kind of refrigerant does a Ford Taurus use?

Most refrigerants include a leak sealer that will seal small leaks in addition to filling the R134a refrigerant. The A/C system in your Taurus consists of a compressor that is belt-driven, an evaporator and freon. If there is a problem with your compressor or evaporator, adding freon will not restore cooling.

Where did the 2000 Ford Taurus come from?

No accident or damage reported to CARFAX. 1st owner purchased on 04/03/00 and owned in WV until 08/31/04 • 2nd owner purchased on 11/17/04 and owned in WV until 11/15/18 • 3rd owner purchased on 11/15/18 and owned in WV until .

Why does the AC blow cold air when the car is moving?

My car has an automatic transmission. When the car is moving, versus stopped, there is more air flow over the condenser (the heat exchanger in front of the radiator) and that airflow is essential to system operation. To maintain airflow when the car is in stop and go traffic, or is completely stopped, condenser fans will come on automatically.

Why does my Mazda 626 blow cold air?

The p0301 code could be caused by a bad spark plug or coil pack on the engine. I would have a technician perform a tuneup and test the coil pack to see if this clears up the misfire. As far… Hey there. On a 2000 Mazda 626 2.0L it is in the passenger side of engine compartment on the firewall.

What happens when your Ford Taurus heater stops working?

At this point, the blower motor blows air across the it and the newly heated air blows on to the driver and passengers. If the heater has stopped working in your Taurus, this process has failed in one way or another.

How can you tell if your air conditioner evaporator is bad?

However, there are 4 other warning signs of a damaged AC evaporator: 1. The cool air is weak or no cold air is blowing at all. When the AC Evaporator coil or core is leaking, it will impact the effectiveness of the air conditioning system. Generally speaking, the greater the leak, the cooling capacity is reduced.

What makes up the core of an AC evaporator?

As warm air passes along the evaporator coils, it collects the heat from the air and makes it cool. The cold air is then circulated through time cabin. Two specific components that make up the evaporator: the core and the coils. When issues occur, in most cases it’s due to leaks created in between these two parts.

What causes the seals on an evaporator to leak?

It’s also quite common for corrosion inside the evaporator core to cause seals to leak. Corrosion occurs when debris finds a way into the air intake such as dirt caused by damaged or clogged air filters. 3. The Connection between Coil and Core. Another leak source is the connection between the ac evaporator coil and the core.

Where is the air conditioning on a Ford Taurus?

Find the control panel in a Ford Taurus by prying off the instrument trim panel on the front of the dash and find the control panel directly underneath it. Turn the air conditioning on full blast. Listen for the accompanying sound of the blower motor.

How does the evaporator work in an air conditioner?

An air conditioning system is designed to remove heat from the air. The job of the evaporator is to harness the cold refrigerant in its liquid state. As warm air passes along the evaporator coils, it collects the heat from the air and makes it cool. The cold air is then circulated through time cabin.

Why does my air conditioner keep turning on and off?

With recirculating the air and the outside temperature around 80 degrees, the car was putting out about 44 degree air from the A/C vents. So next time that your air conditioner compressor rapidly turns on and off in your car, it may not be due to low freon levels – but because it is over-charged!

How can you tell if your AC switch is failing?

If you begin to notice that the AC system is not blowing as cold as it used to, then that may be a sign that the switch has failed, or is beginning to fail. If the switch is not operating correctly, the AC system will not be pressurized correctly and will not work as efficiently in cooling the air.

Why is my air conditioner compressor cycling on and off?

The air conditioner compressor was rapidly cycling on and off. I turned the A/C off and stopped putting R-134a into it becuase the compressor cycling was almost causing the car to die from the load it was putting on the engine. Onto Google I went.

When is the a / C compressor supposed to run?

According to the factory manual and Haynes, the A/C compressor is only supposed to run when outdoor air temperature is above 50F. Wrong! The compressor runs on every setting except the 11 O’clock position where air enters the passenger compartment via the dashboard diffuser ports.

What causes an AC compressor to not engage?

If the clutch doesn’t engage, the problem could be a blown fuse, an open in the wire to the clutch coil, a bad clutch coil, a poor ground, or a low pressure lockout. AC compressor clutches receive power in a number of ways. They can activate through a relay that’s energized directly by a proper condition of the low and high pressure switches.

How does an AC compressor clutch receive power?

AC compressor clutches receive power in a number of ways. They can activate through a relay that’s energized directly by a proper condition of the low and high pressure switches. Or, the relay can be operated by the PCM which has interpreted the condition of the low and high pressure sensors.

Is the AC still working after a battery change?

AC only blows hot air, compressor working, after battery change. Followed instructions in manual for resetting idle and fuel trim. Did it 2x, but still no AC.

Why is my Ford Taurus AC not working?

Ford Taurus AC Is Not Working Repair Symptoms. You may not realize there’s a refrigerant leak until the air conditioner stops blowing cold. Refrigerant may slowly leak out of the system over days, weeks or even years. When the compressor fails, the most common symptom is warm air from the vents.

AC only blows hot air, compressor working, after battery change. Followed instructions in manual for resetting idle and fuel trim. Did it 2x, but still no AC.

Why does my AC compressor clutch not engage?

Look into This! Engaging the AC compressor clutch at home is not rocket science. There are a couple of ways you can fix the problem to bring back the air conditioning system in order. What is the most common reason for an air conditioning compressor not to engage?

Where is the defrost on a Ford Taurus?

Having the same problem, regardless of the position selected, air will only flow through dash registers. I can three of four actuators, but I cannot locate the defrost actuator, it appears by following some wires, that it is on the top of the dash on the drivers side.

Can you blow out the vents on a Ford Taurus?

If you shop at Amazon.com (for anything), use this link to support FordTaurus.net! I have a 2014 Taurus SEL. Yesterday I get in the car and I discover I can only get the blower for AC/Heat to blow out dash vents.

Where is the blend door actuator on a Ford Taurus?

I used a flat bladed screwdriver to turn the door manually and the air did go from hot to cold as I turned the door. On the passenger side behind the glove box I found another blend door actuator to the left that was a little tricky to get to.

Why does my Ford Taurus only blow out the dash vents?

Only mine was because the cabin air filter got wet and swelled up and blocked the door from moving. It got wet because the drain under the windshield was blocked and the water came in over the filter. I removed the blockage and replaced the filter.

How to troubleshoot power steering in a Ford Taurus?

While the engine is idling, turn the steering wheel to the left and right a few times to allow air to escape from the system. Shut the engine off and remove the cap. On OHV models, remove the cap, wipe it off and replace it. Remove the cap again and check the level. It must be in the range marked ” Full Hot.”

How to check the fluid level in a Ford Taurus?

Check the fluid level by starting the engine and allowing it to warm up. While the engine is idling, turn the steering wheel to the left and right a few times to allow air to escape from the system. Shut the engine off and remove the cap. On OHV models, remove the cap, wipe it off and replace it. Remove the cap again and check the level.

How to add freon to your 2002 Ford Taurus: hook up the can of refrigerant (likely r-134a) to the low pressure port. When your compressor kicks on, add freon to the correct pressure.

Is there a problem with the transmission on my Taurus?

Problem seems to be worse the warmer the car is. By the way- my car has 245K highway miles and it is a 1998 Taurus LX. I was warned about bad transmissions in Ford Taurus, but I bought this car anyway, as the transmission worked perfectly during test drive.

Do you need a wiring diagram for a Ford Taurus?

Fernando and pauleo you WILL need a by-pass module for sure for temporarily by-passing the factory installed immobilizers. I need the wiring diagram for the factory radio in a 2004 Ford Taurus SES. If anyone can help me with this info, I will really appreciate it. Are you people ALL just stupid?

What should I look for in a used Ford Taurus?

Description: Used 2019 Ford Taurus SEL with AWD/4WD, Tire Pressure Warning, Audio and cruise controls on steering wheel, Remote Start, Stability Control. At Carvana, we want to help everyone Live Feelessly�. That’s why we never charge last-minute, bogus fees.

Why does my air conditioner make a clicking noise?

If air conditioning could be totally silent, most people would love summer even more. Other folks enjoy a little white noise courtesy of the air conditioner blowing. Nobody wants a repetitive, annoying sound like clicking, though. Air conditioner clicking sounds can be categorized (and fixed) based on where the sound comes from.

What does it mean when your AC is making a pulsating noise?

An air conditioner making a pulsating noise isn’t necessarily a bad sign — a little pulsing noise can be perfectly normal when the air conditioner is operating. But if your outdoor A/C unit is making a pulsating noise that you can hear from inside the house, it could be a sign that something has come loose inside the unit and needs to be replaced.

Why is my car making a clicking noise?

My car has an automatic transmission. The noise you are hearing is one of the HVAC door actuators that control air flow or temperature for the a/c. There are at least 4 of these actuators in your system and one of them is going bad and would need to be replaced.

What is the code for Ford Taurus idle air control?

Use Code: DIYSAVE10 Online Ship-to-Home Orders Only You love your Ford Taurus because it’s safe and dependable. But vehicle performance goes downhill if you have a faulty idle air control valve, which controls the air going into the engine, allowing your Taurus’ computer to match it with the correct amount of fuel.

How to tell if Taurus IAC valve is clogged?

Use the form above to tell us what you drive. Symptoms of a Taurus IAC valve that is clogged with dirt and debris include the valve’s slowed response time, the engine’s RPM dropping significantly and instant, irregular deceleration and backfiring when you lift your foot off of the gas pedal. There’s no need to suffer through decreased performance.

Problem With Idle Air Bypass Valve May Cause Engine Performance Problems Engine Stalling and/or Hesitation on Acceleration due to Faulty Idle Air Bypass Valve on Ford Taurus Problem Description

What should I do if my car a / C is blowing hot air?

Check the front of your vehicle for debris, the engine cooling fans for proper operation, and your cabin air filter for debris and dirt. The refrigerant in your system also needs to be able to flow properly through the system. Check your compressor for proper operation, clogs in your system and the proper amount of refrigerant.

Why is my car a / C blowing hot air out of the vent?

Your car’s A/C system is one that operates a little differently than you might think. Instead of actually creating cool air, it instead removes the heat and moisture from the air inside of your car, leaving you with cooler feeling air.

What to do if your air conditioner is blowing hot air?

If you discover this to be the reason why your car air conditioner is blowing hot air add Red Angel A/C Stop Leak to your vehicle’s air conditioning system to seal any leaks no matter how small they are before you recharge the system.

What happens if the clutch on the AC fails?

No cooling at all In more severe cases, where the switch has completely failed, your AC system will completely cease to blow cold air. Without the cycling switch to activate the compressor’s clutch, the AC system will not be pressurized correctly, and the system will be unable to produce any cold air as a result.

Why does my car AC blow cold air then blow warm air?

But that cold air turns warm fairly soon after because the high side pressures build to the point that the high pressure switch shuts off the compressor clutch. Once pressures equalize, the high pressure switch allows the compressor to start up again. The cycle repeats over and over, providing a short period of cold air, followed by warm air.

What was the coolant leak on my Taurus?

Ford Taurus 2000. Story, I could not find a coolant leak so ended up taking it in. Was the resevour, fixed, alls good. Just before I drove off I asked the guy if anything else needed attention, he said “nope, wait, your air compressor stays on for all control settings except off”.

Why does my Ford a / C compressor keep running?

If the coolant is brown, and rusty with a lot of sediment then the chance are good. Sounds good, thanks. The a/c compressor even runs in vent mode. The only way to shut it down is to turn the whole system off. Still seems wierd why Ford would keep it on for all modes.

How old is Thomas Clay Rogers Ford Taurus?

To avoid this, cancel and sign in to YouTube on your computer. My name is Thomas Clay Rogers and I am now 43 years old about to turn 44 I’ve been working on car since I was 12 at a small auto repair shop in Whitney Texas ran by my next-door neighbor and I really didn’t do much but the first thing I learned how to do was plug a tire.

When was the Ford Taurus first made in the US?

Ford Taurus. Jump to navigation Jump to search. automobile manufactured by the Ford Motor Company. The Ford Taurus is an automobile manufactured by Ford in the United States. Now in its sixth generation, it was originally introduced in the 1986 model year, and has remained in near-continuous production for more than three decades.

What kind of equipment does a Ford Taurus have?

The interior equipment depends on model. The most basic model, the L (see below), came standard, with just an AM radio and a front cloth bench seat, while the LX, the more luxurious model, came with a greater number of features as standard equipment. The Taurus was well received by both the public and the press.

What are common reasons my Ford Taurus has air conditioning problems?

What are common reasons my Ford Taurus has air conditioning problems? While there are a variety of reasons your Ford Taurus air conditioning won’t work, the most common 3 are a refrigerant leak, an electrical climate control issue, or a problem with the air conditioning compressor.

How does ABS work on a Ford Taurus?

The ABS module is the microprocessor that controls the hydraulic pressure applied to the brakes. The module receives signals through sensors in the wheel hub that lets the module know how much hydraulic pressure to release to the brakes, allowing for faster and safer braking.

When did the Ford Taurus go out of production?

In the late 1990s and early 2000s, sales of the Taurus declined as it lost market share to Japanese midsize sedans and as Ford shifted resources towards developing SUVs. The Taurus was withdrawn after the 2007 model year, with production ending on October 27, 2006.

Why is my blinker not working on my Turn signal?

A direction signal system is designed to operate with a flasher or blinker unit which interrupts the signal which created the blinking action. Learn more – Locate turn signal flasher in Google Images. Step 4 – When a turn signal switch fails the system will short or go “open” causing the blinker not to operate.

Why is my left turn signal light not flashing?

Operate the switch to turn the left turn signal light. Back probe the wire that supplies power to the switch; the test light should flash. If the test light doesn’t flash, there is a problem with the flasher unit or an open or short between the switch and the battery power source.

Is there a 2015 Ford Taurus that won’t switch?

I have a 2015 Ford Taurus SHO that the air won’t switch from the defrost mode to vents or floor, i found the two temp. I have a 2015 Ford Taurus SHO that the air won’t switch from… twice this week, in cold weather, my heat/ac/defrost fan would blow.

Why was the Ford Taurus the most anticipated car?

(The full-size Ford LTD Crown Victoria remained as part of the Ford line up.) The release of the Ford Taurus was one of the most anticipated ever, mostly because it was a first in car design and also the start of new quality standards for Ford.

When did Ford discontinue the Ford Taurus truck?

On April 25, 2018, Ford announced plans to discontinue the Taurus (along with the Fiesta, Focus, and Fusion), in order to focus more on its line of trucks and SUVs. The announcement was part of a plan by Ford Motor Company to cut costs and increase profits.

What should I change in my Ford Taurus?

Now you need to change the climate control seat filters and the engine air filter to maintain optimal performance. Rolling over to 100,000 miles is a big milestone for your vehicle. Treat it to new platinum spark plugs. Also replace the carbon air filter and orange coolant.

When to change the air filter on a Ford Taurus?

At 20,000 miles it’s time to change the carbon air filter if your Taurus has one equipped. Also perform the standard multi-point inspection, which should be done with every oil change and maintenance service. At this point you will want to change the climate control seat filters if equipped as well as the engine air filter.

When to replace the seat belts in a Ford Taurus?

The climate control seat filters will also need to be replaced as well as the engine air filter. If you have not already, within the last 100,000 miles, now’s the time to replace the drive belts. By keeping your Taurus maintained according to the maintenance schedule, you will extend the life of the vehicle and keep it running efficiently.

Do you need an AC compressor for a Ford Taurus?

Whether your Ford Taurus is your main mode of transportation or an alternate one, you don’t want to end up driving around in a sweat box when it’s hot outside. Order and install a new Ford Taurus AC compressor to transform the life and performance of your AC so it keeps you cool for many miles to come.

Why does my Taurus se Vulcan have no AC?

99 Taurus se Vulcan engine I have no ac ~rest of system works fine . blend door works. Fuse and relays all look ok. resistor swapped out~ same as before/ no ac I attached a gauge and Freon can r134 to low pressure side. likely the unit is not low on Freon as the gauge and can are not filling into the system. It says the pressure is high.

Why does the clutch on my Taurus not engage?

The clutch does not engage. The blower blows warm air/ ambient Now before I have a shop fix it I’d like to know if there is a place to jump the compressor clutch/ engage it by bypassing the pressure switch or applying voltage direct? to see if the compressor works or not. Maybe this is stupid I don’t know.

What to do if your a / C compressor won’t engage?

HOWEVER, if you cannot turn the compressor on, you cannot recharge your AC levels (grrrr). So you need to use a paper clip to bypass the relay switch and force the clutch to engage. You can then recharge the freon and re install the relay switch and it will sense more pressure and the clutch will engage by itself. Loading…

Why is my Ford Taurus air conditioner not working?

Lack of Refrigerant – Your Taurus’s air conditioner will not work if the refrigerant has disappeared due to a leak. In fact, most won’t even cycle on without the right amount of refrigerant pressure. This is far and away the most common reason that your Taurus’s air conditioner is not functioning.

Why is my AC not blowing cold air?

The chemical Freon or simply you can call it coolant is the reason why the AC cools hot air quickly. The chemical can run out if there is any leakage in the AC. Thus, AC would not work, as there is no Freon in the system.

Why does my AC make noise when I turn it on?

Belt: If the serpentine belt is worn, it can slip when the compressor engages, causing noises. Idler Pulley: It’s possible that the noise is actually from the idler pulley if its bearings are failing. The noise would start when the compressor engages due to the increased load on the engine.

How is the air conditioner connected to the engine?

While your air conditioner is technically a separate system, it’s tied to the rest of the engine by the serpentine belt. The serpentine belt is what’s responsible for turning the pulley at the AC compressor, and pressurizing the refrigerant lines.

Why is my AC compressor not working properly?

The health of the AC compressor in your vehicle is what determines whether you’ll have cool air when you need it. When there are leaks, broken seals or other deficiencies, your compressor isn’t able to function properly, thus blowing hot air or no air at all into your vehicle’s cabin.

When do I need to replace my air conditioner compressor?

A compressor may also fail if there is sludge or debris in the air conditioning system. If there is sludge or debris, the hoses, evaporator, and condenser should be flushed to get rid of the contaminants. When it is not possible to flush the parts, you may need to replace those parts.

When to replace AC compressor in Ford Taurus?

Replace what’s broken with a new, bullish AC compressor for Ford Taurus to restore your AC system’s performance and your vehicle’s cabin’s comfort before the next time you hit the road.

What happens to a car when the AC is on?

A hot car is not only discomforting but also leads to serious damage to several other components. The symptoms of the car overheating due to the air conditioner involve the heating up of the engine, dashboard, and the seats a few minutes after turning on the AC. The restoration to normal temperature is pretty quick to once you turn off the AC.

What are the functions of a Tauri module?

Many Sable and Tauri (plural ) cars used a module to control various functions including cooling fan, A/C, fuel pump, etc. This module is essentially a box of relays with a fancy title like Integrated Controller Relay Module, etc.

Why does my air compressor shut off when it gets too hot?

If the compressor oil gets too hot, the switch sends a signal to the on-off controller to disengage the air compressor’s clutch. This shuts down the system and prevents high temperature related damage. Why is my compressor shutting off? If your compressor trips on over temperature, it could be for any of the following reasons:

Why does my air conditioner keep shutting down?

Electrical complications are among the most common reasons for an AC shutting down suddenly—these incidents are often accompanied by a breaker trip, though not always. Absolutely never try to troubleshoot AC electrical problems on your own!

How to get AC compressor to stop turning on?

To avoid this, cancel and sign in to YouTube on your computer. An error occurred while retrieving sharing information. Please try again later. Here’s some footage to expect! Welcome to All 4 Him Racing Videos!

Why does my AC keep turning on and off?

Why does my AC unit keep turning on and off? If your air conditioner keeps turning on and off your AC system is most likely short cycling . An AC system may turn on and off repeatedly due to dirty, broken, or failing parts or for various other mechanical or electrical reasons.

How often does your AC turn on and off?

Depending on indoor and outdoor conditions, this could mean that your system turns on and off every 5 to 10 minutes. An air conditioner that is switching on and off repeatedly is bad for both homeowners and your AC system.

Is the Ford Taurus difficult to start in the winter?

If your Ford Taurus is difficult to start during the cold winter months, there could be a variety of problems with the vehicle. It is important to know that all cars, not just the Taurus, can experience difficulty in starting during winter months.

Is the Taurus battery bad in the winter?

It is important to know that all cars, not just the Taurus, can experience difficulty in starting during winter months. During winter months, the car battery can have a greater discharge than in summer months due to the harsher conditions.

What’s the trouble code for a cold Ford?

It may run extremely rich, which you will notice with rough idle and poor MPG. It may also store trouble codes P0172 and P0175. However, once the engine warms up, it runs fine and will restart just fine.

What causes a car to have a hard start when cold?

If you have a Ford vehicle and find that has a hard start when cold condition, here are the common things to check. The issue appears as an engine that will crank but has a hard time firing up. Once it does start, it doesn’t run well. It may run extremely rich, which you will notice with rough idle and poor MPG.

What to do when your Ford engine is cold?

If you have access to a scan tool, check the FLEX FUEL DATA reading. If the reading is 70% or higher, your first job is to reset the PCM by disconnecting the battery terminals for at least 5 minutes. Then reconnect and take the vehicle for an extended road test. Let the vehicle cool until the engine is cold.

What happens when one part of the AC system fails?

When one part of the system fails to operate like the air conditioner then one part of the system stops working in this case the cold air. The AC system has four basic parts: A compressor, which is powered by the engine using a serpentine belt.

What are the symptoms of a bad AC pressure switch?

The most common symptom of a bad AC pressure switch are that you will notice that the AC compressor is cutting on and off rapidly when you are idling your car. These switches between on and off can be noticeable on the engine’s rpm, and you may see or feel fluctuations from it.

What happens when Acura RDX AC unit fails?

When the compressor fails, the most common symptom is warm air from the vents. A squealing or grinding noise may also be heard from the compressor in the event of mechanical fai…

What should the AC pressure be when the engine is on?

When the engine is on When the engine is on and the AC is on high, low pressure readings should be around 30 psi and the high pressure side should be about 250 psi depending on your car. The correct reading will display once the clutch engages and the gauge stops cycling.

What should my AC low side pressure be?

When the engine is on and the AC is on high, low pressure readings should be around 30 psi and the high pressure side should be about 250 psi depending on your car. The correct reading will display once the clutch engages and the gauge stops cycling.

What causes high air pressure when the engine is not running?

When there is higher than normal air pressure if the engine isn’t running, this means that there is high pressure in the condenser fan, which is what cools the AC system by passing air through it. This high pressure is commonly caused by two problems:

Why is the air pressure in my AC too high?

High pressure when the engine is off When there is higher than normal air pressure if the engine isn’t running, this means that there is high pressure in the condenser fan, which is what cools the AC system by passing air through it. This high pressure is commonly caused by two problems:

What is the air filter on a 2002 Ford Taurus?

The cabin air filter in your 2002 Ford Taurus filters the air that is blown from your heater or air conditioner into the cabin of your Taurus.

How many miles does a 2000 Ford Taurus drive?

1st owner purchased on 08/22/00 and owned in PA until 08/28/13 • 2nd owner purchased on 09/13/13 and owned in PA until 12/17/19 • 3rd owner purchased on 12/17/19 and owned in PA until 04/24/21. 1st owner drove an estimated 1,647 miles/year • 2nd owner drove an estimated 14,070 miles/year • 3rd owner drove an estimated 7,123 miles/year.

How often do you need to change the air filter in a Taurus?

We are still working to obtain content for your car, however the video above is believed to have similar characteristics as your car. The cabin air filter in your 2002 Ford Taurus filters the air that is blown from your heater or air conditioner into the cabin of your Taurus. You need to change it at least once a year or every 20,000 miles.

Where was the 2000 Ford Taurus last serviced?

1st owner drove an estimated 16,235 miles/year • 2nd owner drove an estimated 0 miles/year • 3rd owner drove an estimated 7,487 miles/year. Last serviced at 108,869 miles in Alexandria, KY on 04/29/21 • Vehicle serviced.

Can a bad catalytic converter lead to engine failure?

A bad or clogged catalytic converter can ultimately lead to engine failure, so it’s important to address the issue promptly. However, having catalytic converter problems doesn’t necessarily mean that the converter has to be replaced.

What was the problem with my Ford Taurus?

I have a 2004 Ford Taurus, and the transmission did the same as yours. There was no gears that would engage, forward or reverse. I looked on the Internet to find what the problem was, and found most was saying it was the torque converter.

Why is the torque converter on my Taurus not working?

The torque converter is suspect. They will be fine one second, and dead the next and often die without warning. The splines for the pump shaft wear out. Known issue on these as well as Windstars. On one Taurus it was clockwork.. 80k failed, 165k failed. Another Taurus 160k failed.

Where are the cooler lines on a Ford Taurus?

The transmission cooler lines run almost behind the front bumper. I have seen some get scraped against tall parking curbs and spring leaks. Check the fluid with the car RUNNING in park fully warmed up. Read the dipstick it will tell you where it should be. With the car off and the key in, foot on the brake pedal.

How to check the transmission fluid in a Ford Taurus?

Check the fluid with the car RUNNING in park fully warmed up. Read the dipstick it will tell you where it should be. With the car off and the key in, foot on the brake pedal. Rapidly go through all of the gears. Sometime the PRNDL switch can get gummed up. How many miles are on the car and when was the last time the fluid and filter were changed?

What kind of engine does a Ford Taurus have?

There have been various forms of this basic design through the years. When the Ford Taurus made its debut in 1986, it had a newly designed V6 nestled under hood. That V6 was the 3.0L Vulcan. A basic push-rod OHV design, the engine quickly became known for its reliability.

Why does my check engine light turn on?

Check Engine Light Turns On An illuminated Check Engine Light is one possible symptom of a problem with the ECM. The Check Engine Light usually illuminates when the computer detects a problem with any of its sensors or circuits. There are cases, however, where the ECM illuminates a Check Engine Light mistakenly, or when there is no issue present.

Why does my air conditioner cut out when I accelerate?

Typically this occurs due to a bad vacuum check valve under the hood. During hard acceleration the AC door system loses vacuum, causing the doors to default to the windshield. This check valve keeps this from occurring. It is located under the passenger side of the hood.

When does air conditioner cut out when going up hill?

Q: Air conditioner cuts out when accelerating or under pressure going up hill. I noticed today that whenever traveling and accelerating like going uphill for an extra length that my a/c will quit blowing and as soon as I level off or the need to accelerate levels off it will resume blowing. My car has 197000 miles.

What to do if your Ford Taurus has a leak?

When the air conditioner in your 2003 Ford Taurus starts blowing hot air, you likely have a freon leak. Recharging the freon in your AC system is an inexpensive and easy first step to restoring the cooling capacity of your A/C system. Most refrigerants include a leak sealer that will seal small leaks in addition to filling the R134a refrigerant.

How to add Freon to a 2003 Ford Taurus?

How to add freon to your 2003 Ford Taurus: hook up the can of refrigerant (likely r-134a) to the low pressure port. When your compressor kicks on, add freon to the correct pressure. In addition to cooling, freon lubricates the compressor when it runs. Advance Auto coupon for 20% off entire order: KIOSK20 Author

What kind of engine does a 2002 Ford Taurus have?

2002 Ford Taurus SE 2-Valve 3.0L V6 Change a rear wiper blade The rear wiper that you forgot you had until it streaks horrifically on a rainy day? Change it now! 2003 Chevrolet Suburban 1500 LT 5.3L V8

Why does my car heat up when the AC is on?

The cooling system works to keep the air conditioning’s condenser cool, which heats up after you turn the AC on. The overheating could be the result of clogged condenser fins, defective condenser fan, or a faulty water pump that does not properly circulate the coolant.

Why does my car overheat when the engine is off?

With the engine off (and cold) try rotating the blade by hand. It should turn freely. I will also point out that whenever the A/C compressor is running (A/C, DEFROST, Bi-Level) the radiator fan MUST be running. If not, the engine will overheat due to heat from the A/C condenser and the additional engine strain.

What are common reasons my Ford Taurus overheats?

What are common reasons my Ford Taurus overheats? While there are a variety of reasons your Ford Taurus is overheating, the most common 3 are a coolant leak (water pump, radiator, hose etc.), the radiator fan, or a failed thermostat. See what others are asking about their Ford Taurus.

Why is the heater not working on my Ford Escape?

If the neither hose has any heat, you may have air in the cooling system, low fluid, or low pressure. If you look at your temperature gauge, and the engine is running hotter than normal, but there is not heat coming from the heater you may be having issues with the water pump.

Why is my a / C blowing warm air?

A refrigerant leak is unique in the sense that refrigerant evaporates instantly into a gas once it isn’t under the pressure of your closed loop A/C system. A/C systems are sealed and therefore don’t require refrigerant top-off’s. If the refrigerant level is low then there is a leak that needs to be addressed.

Why does my air conditioner blow cold air while driving?

Similarly, if your AC condenser fan isn’t working, your air conditioning would blow cold until the condenser got heat soaked then it would stop working until you were up to cruising speed then the air blowing over the condenser while driving would cool it down and keep things working. Thanks again for your question!

What are the most common problems with Ford Taurus?

We dove in to find out more about some of the most common problems, based on the accounts of Taurus owners that you should know. A good number of consumers experienced issues with the Ford Taurus’ automatic headlights not working. Possible failures with the sunload sensor or the Smart Junction Box (SJB) are probable.

What kind of gasket does a Ford Taurus have?

The 2.5L four-cylinder, 3.0L V6 DOHC, 3.0L V6 SHO, 3.4L V8 SHO, and 3.8L V6 show consumer issues with this gasket. If you’re in the market to find a larger sedan and are on a budget, the Ford Taurus is worth a look. When buying used, it’s always recommended that you consult a vehicle history report.

Why does my AC not work in auto mode?

The AC auto mode will not work Most modern vehicles have an auto AC setting that will allow the vehicle to automatically set and regulate the temperature. The AC system will simply read the ambient and cabin temperature sensors data and continuously cycle the AC system on and off as required to keep the cabin cool.

What kind of problems does a Ford Taurus have?

Most Common Ford Taurus Problems. Ford Taurus vehicles have 16 reported problems.The most commonly reported Ford Taurus problem is: Engine Oil Pan Gasket May Leak. Engine Oil Pan Gasket May Leak. The engine oil pan gasket can develop a leak.

Why AC clutch won’t engage If the clutch doesn’t engage, the problem could be a blown fuse, an open in the wire to the clutch coil, a bad clutch coil, a poor ground, or a low pressure lockout. AC compressor clutches receive power in a number of ways.

How can I tell if my compressor is running or not?

Not really. DIY kits come with a low pressure side gauge and they’re designed to provide a static pressure (engine not running or AC off) and a running pressure. Static low side pressure won’t give you any idea of system charge. You could have a low side target range of 50-psi and see that static pressure on your gauge.

What should the temperature be in a Ford Taurus?

The vehicle If the scan tool still does not allow with the vehicleinterior temperature should be between 4°-38°C selection to be entered, refer to the scan tool (40°-100°F) when carrying out the self-test. If the manual. temperature is not within the specified range, false in-car temperature sensor DTCs will be displayed.

What are the ports on a Ford Taurus?

Port Number Line Color Function position 1 White Air inlet door 21 — Floor airflow 22 — To vacuum distribution 2 Red floor door 23 19A566 Vacuum reservoir tank 3 Black Source vacuum 24 19B888 Function selector switch 4 — Not used 25 18A318 Vacuum control 5 Blue floor door motor—panel/floor door 6 Yellow Defrost door a

When do you know something is wrong with your blend door actuator?

Noise: If you’re hearing a sort of droning or squeaking repetitive sound from somewhere within your dashboard around the Center area, in the more or less general area that you are control knobs for the HVAC system are located, that’s a good sign there’s something wrong with the blend door actuator.

Why is my Ford Taurus not blowing cold air?

One of the most inconvenient vehicular problems is when the A/C won’t blow cold air. If your Ford Taurus isn’t keeping you cool, we’ve outlined some of the most common reasons why this might be happening. The only thing that the air conditioning system has in common with the heater is that they both use the climate controls and the blower motor.

Is the coolant tank on a 97 Taurus leaking?

The coolant tank on the 97 Taurus is notorious for getting a crack in it and when the pressure builds up it will leak. It can be very hard to find because it often will not leak until there is pressure in the system. I have a 97 Taurus that I use for a work car and I thought I had a head gasket problem too but I found a crack in the coolant tank.

Why is my Taurus heater not working properly?

Now if you have good flow threw your heater core then it is probably a blend door actuator. The blend door actuator controls the amount of heat that you get with your heater. On the taurus it tends to fail quite a lot. The little plastic gears go bad and the heater will not work as if fails in the cold position.

Where is the heater on a Ford Taurus?

The blend door actuator controls the amount of heat that you get with your heater. On the taurus it tends to fail quite a lot. The little plastic gears go bad and the heater will not work as if fails in the cold position. I think they are around $70 at ford and fairly easy to replace yourself. It is located under the center consul.