Why are the gauges on my Dodge Grand Caravan not working?

If you own a 2001 or later Dodge Grand Caravan or Chrysler Town & Country van and your gauges are dead, the most common cause is a bad module that’s mucking up the digital data on the vehicle’s data bus. Start by performing a self test on the cluster. Ignition switch should be in the locked position.

Why is my Chrysler Town and Country not starting?

No gauges or digital mileage displays, the ABS, and Alarm Set would be lit. Sometimes I couldn’t enter the van with the remote xmitter when the engine was running during this condition. Sometimes the van would fail to start as well. Heard this is an issue with a solder joint on the back of the cluster.

Is there a gas gauge on a 1999 Dodge minivan?

No speedo, gas gauge, tach, temp. gauge,etc. (had this same problem with 1995, and 1998 models of chrysler/dodge minivans, the 1999 would ‘correct’ if I hit the dash board just right, the others would not-I would just drive them without the gauges and eventually they would come back on).

Why is my speed ODM gauge not working?

The cause of problem: bad connection under fuse box going to hazard circuit. The connection plug pins had some corrosion on them. This allowed voltage to travel through that circuit but not enough current.

Why are all of the gauges in my car not working?

There are a lot of different types of instrument cluster designs and configurations, but when all of the gauges in a car stop working at once, the problem is usually either a fuse or wiring problem. The first step in diagnosing this type of issue is to identify the fuse associated with the instrument cluster or gauges.

What to do when your gauges go crazy?

Retouch them with a soldering iron even if you can’t see cracks. They can be tiny. One way to detect them is to smack the dash above the cluster next time they go crazy. If they straighten up then get the soldering iron out.

How to repair Chrysler / Dodge minivan instrument cluster?

How To Repair Chrysler/Dodge Minivan Instrument Cluster Problems is part of the Fixing it Forward series. Not long after Barbara got her van back, she called me and told me her instrument cluster was freaking out. With a little research I found out the problem might be the solder joints on the back of the instrument cluster circuit board.

What was the cause of the instrument cluster failure?

It turned out to be a cold solder joint where the electrical harness plugs to the back of the instrument cluster.

What was the problem with my Chrysler Town and Country?

Cruise control and headlights stayed on but no idiot lights, gas sais empty, said I was going zero no RPM temp gauge all the way down to cold wont show milage or that cruise was still on and the turn signals and hazards won’t work! No gauges or digital mileage displays, the ABS, and Alarm Set would be lit.

What happens when the dashboard instrumentation cluster malfunctions?

A malfunctioning BCM will activate dashboard instrumentation cluster error and warning lights. These lights may flash off and on if the BCM is not able to read the sensors correctly.

What happens when the cluster goes off on a Chrysler Sebring?

Cluster goes off randomly, and starts to work again, randomly. Sometimes it stays off longer than other times. For instance, this time they’ve been off for about 2 straight weeks! The only thing thats lit is where it shows how many miles on the car, and P,R,N,D.

Where does the fault code go on the odometer?

If a fault code is present, the cluster will display it in the odometer display. When all fault codes have been displayed, the cluster will display “end” or “E” for end in the odometer display.

What does it mean when your speedometer is not working?

If the oil pressure, coolant, charge, or gas gauge doesn’t work or works erratically, the problem is in the gauge, wiring, or sender. Speedometers are unique in that some of them use physical cables instead of sensors, so a speedometer not working can also indicate a broken cable or stripped gear.

What to do if your instrument cluster is not working?

If playback doesn’t begin shortly, try restarting your device. Videos you watch may be added to the TV’s watch history and influence TV recommendations. To avoid this, cancel and sign in to YouTube on your computer. Anything and Everything… Beautiful today in Canyon Lake.

What should I do if my cluster does not perform a self test?

Ignition switch should be in the locked position. Hold down the trip reset button until you see the word “Sof” and a number appear in the odometer window. If the cluster will not perform a self test, then the problem is in the cluster itself. If you have a scan tool, try communicating with each module on the data bus.

What happens when the speedometer on a Jeep Grand Cherokee stops working?

One of the most inconvenient things that can happen to your Grand Cherokee is when the speedometer stops working. You don’t really realize how much you look at the thing until it’s just always sitting at 0 MPH while driving down the road.

What to do if your speedometer is not working?

Instrument panel first. If your Jeep Grand Cherokee’s speedometer is not working, the first place to go would be to check the service engine soon light (if applicable). Now, take it out and see if the cruise control still works. If it does, that’s a pretty good indication that the vehicle speed sensor is just fine.

What does it mean when gauges in your car stop working?

But when the gauges in your car stop working, it’s not a situation you can safely ignore. When one gauge stops working, the problem may be in the gauge itself or a bad sensor, while all the gauges cutting out at the same time often indicates a blown fuse or a defective instrument cluster.

What kind of wiring does a Grand Caravan have?

Always start your diagnosis by checking the fuses. The wiring diagrams are different based on year and model, but the caravan wiring diagram shown here is for a 2009 Grand Caravan. The instrument cluster in late model Chrysler vehicles contain analog and electro-mechanical instrument cluster gauges (EMIC).

Why are the lights on my caravan not working?

Repair Topics > Instrument panel > Caravan instrument panel… A Caravan instrument panel lights not working condition can be caused by a fuse, wiring harness, grounding, digital bus or defective instrument cluster problem. Always start your diagnosis by checking the fuses.

What is the emic on a Chrysler Caravan?

The instrument cluster in late model Chrysler vehicles contain analog and electro-mechanical instrument cluster gauges (EMIC). The instrument cluster also contains the body control module and is referred to as the Cab Compartment Node (CCN). It is connected to the digital bus in the vehicle.

What to do if your YouTube gauges are not working?

Easy fix. How to reset. – YouTube Gauges not working? Instrument cluster not working ? Easy fix. How to reset. If playback doesn’t begin shortly, try restarting your device. Videos you watch may be added to the TV’s watch history and influence TV recommendations. To avoid this, cancel and sign in to YouTube on your computer.

What to do about a broken plug on a Dodge Caravan?

I have a 99 Dodge Caravan (same thing) that was doing the same thing. Just pulled the cluster out, removed the circuit board and badabing, I found a broken solder joint where the plug snaps in. Soldered it, now working great. Easy but little time consuming process. Hope this helps.

What kind of problems does a Dodge Caravan have?

I have a 1998 Dodge Caravan and was having intermittent problems. Van would start, run about 2 seconds then die, this would repeat several times then not start at all. My fuel, temp, etc. would not function. I could hit the top of the dash and all would begin to work and then the van would start. Never knew when this would happen.

Why are the warning lights on my car not working?

One or more dashboard warning lights don’t work. If one or more warning lights fail to illuminate when you first turn the key on, it usually indicates a blown bulb. If none of the lights come on at all, check the fuses and wiring to the instrument cluster first.

What to do if your coolant gauge is not working?

Using your coolant temperature gauge as an example, the diagnostic procedure involves locating and disconnecting the sending unit. With the ignition on, the gauge should register cold. If you connect the sending unit wire to ground, the gauge should switch to read hot.

How does the speedometer work on a Dodge Caravan?

A modern vehicle’s speedometer takes the input from the Vehicle Speed Sensor and sends that data to the ECU. The ECU is programmed with your Caravan’s gear ratios and stock tire height. It combines this data to send the speed reading to the instrument cluster.

What causes a car speedometer to stop working?

1 When The Sensors Have Failed… Find the location of the sensors and check them along with the wires connecting to them for any visible damage. 2 When The Wiring Is Bad… The wires can short or worn out in an older car and cause the fuse to blow out. 3 If The ECU Is The Culprit Here…

What happens when a speed sensor stops working?

A speed sensor does not only indicate the vehicle speed but also help with cruise control operation and regulation of the fuel’s flowing and ignition timing. A speedometer may stop working due to a bad sensor.

What can a faulty speed sensor do to a car?

VSS – A faulty speed sensor will often be accompanied by the P0500 (VSS circuit malfunction) trouble code. The speed sensor does more than just control the speedometer, it also helps to control the cruise control system and may even affect the way that the engine runs.

When did the Dodge Caravan 2001 come out?

Unveiled at the 2000 North American International Auto Show on January 10, 2000, the redesigned 2001 Dodge Caravan and 2001 Chrysler Town & Country were released for sale in August 2000. . what could be the problem?

Why are the lights on my Dodge Caravan going out?

A common issue with the Dodge Caravan (and Chrysler Town & Country?) is the instrument panel lights going out. This makes it almost impossible to see your fuel gauge or speedometer during night driving. In this video I show how I was able to replace those lights with replacement parts for less than $20. The process takes around a half hour.

Where are the control wires in a Dodge Grand Caravan?

These wires are made to be bent, time and time again, as the drivers door is the most used. But there is a control module that is also located inside the drivers door and it uses a “twisted pair” of really small gauge SOLID wire (that goes back to the onboard computer).

What was the problem with the Dodge Grand Caravan dash?

One of the small wires broke inside the rubber boot between the door and body. The tech told me what he found and spliced the wires with a 50 cent connector. The guy was honest and “kudos” to Salsbury Dodge in Baton Rouge.

Why does my Dodge truck have no gauges?

Fortunately when I finally broke down out of utter frustration and took it to the dealer to have it repaired the first time it didn’t cost me an arm. $108 later the service guy said it was a loose wire connection in the PDC.

How long does it take for no bus gauges to work?

After 15 minutes and all the dash panels have been removed for the second time (why didn’t I off load this the first time) it starts working again. But, What did I do??

Why does my van surge at stop lights?

Well immediately after that problem was solved the van started wanting to surge while at stop lights, it is also bogging down when i push the excelarator pedal from a stop to go then takes off fine after 1 or 2 little bogs? Any thoughts on what problem is would be greatly appreciated!

What happens when speedometer on Dodge Caravan stops working?

One of the most inconvenient things that can happen to your Caravan is when the speedometer stops working. You don’t really realize how much you look at the thing until it’s just always sitting at 0 MPH while driving down the road.

What is the ECU on a Dodge Caravan?

ECU – Your Caravan’s Engine Control Unit (ECU for short) is the computer that takes all of the information that the vehicle sensors compile and uses it to control the vehicle systems, and sends important vehicular telemetry data to the driver via the instrument cluster.

If the cluster will not perform a self test, then the problem is in the cluster itself. If you have a scan tool, try communicating with each module on the data bus. However, if you don’t have a scan tool, you’ll have to unplug each module one at a time until the data communication comes back up and the cluster responds. Then replace that module.

Why is my speed ODM not working on my Dodge Dakota?

I have a 2000 dodge dakota 3.9L. The instrument cluster is not working for it. I had replaced the cluster 4 different times. Contacted the dodge dealership and made sure the cluster was the right part number i have. Which it is. I had replaced the fuse for the cluster and cleaned the connections.

What to do when your odometer is not working?

When the key is in the ON position with the engine not running, the MIL will remain illuminated for regulatory purposes. With the ignition switch in the OFF position, depress the TRIP ODOMETER RESET button.

How do you reset the odometer on a Honda Accord?

With the ignition switch in the OFF position, depress the TRIP ODOMETER RESET button. Continue to hold the TRIP ODOMETER RESET button until “Sof” and a number (software version number appears briefly in the odometer window, then release the button. If a fault code is present, the cluster will display it in the odometer display.

Where are the airbag warning lights on a Dodge Caravan?

Instrument cluster display layout and warning light location may vary depending on the age / generation and model of your Dodge Grand Caravan, though the warning lights below have the same meaning. Name: Dodge Grand Caravan airbag warning light.

What causes a dash light to go out on a Dodge Grand Caravan?

Strenuous driving with hot ambient temperatures and high load weights or trailer towing can cause the light to illuminate. Stop the vehicle as soon as possible. Secure the vehicle and allow the engine to run at idle until the warning light goes out.

What does the brake warning light on a Dodge Grand Caravan mean?

Name: Dodge Grand Caravan brake warning light. Description: The red ‘BRAKE’ warning light is displayed on vehicles destined for USA markets. The red is used for vehicles destined for Canadian markets. The warning light comes on for the following reasons: ▷ The parking brake is applied. ▷ The brake fluid level is low in the reservoir tank.

How to check the brake fluid in a Dodge Grand Caravan?

Dodge Grand Caravan Dashboard Warning Lights 1 Check that the parking brake is fully released. 2 Open the hood and check the brake fluid reservoir tank has fluid up to the ‘full’ mark. 3 If the light remains on after adding fluid or the tank is at acceptable levels, have your brake system serviced immediately.

Why does my brake warning light keep flashing?

• If the light remains on after adding fluid or the tank is at acceptable levels, have your brake system serviced immediately. The brake warning light may on occasions flash. This is due to brake levels temporarily changing when cornering in the vehicle. Name: Dodge Grand Caravan ABS warning light.

Why do the lights flicker on and off in my Dodge Caravan?

I have a 2005 Chrysler Town and Country where the lights keep flickering on and off and the gauges go all crazy and it seems like if you slow down at a stoplight it will cut off and I checked the battery and the alternator and they test out okay. Does anybody have any answers thank you 49 people found this helpful.

What can I do if my Dodge Caravan wont start?

I 2003 Dodge Caravan will not start so we jumped it second home let it run for a little bit next morning went out to start it wouldn’t start but the gauges started going crazy but when they opened up my hood of my car the jump it snow fell inside of it so I had my son take a hairdryer to dry the fuse box doing the same thing what can I do

Why does my Dodge Caravan door lock go crazy?

When I bought the car I had a OBD door lock dongle installed (it’s an plug and play dongle that goes to the car’s On Board Diagnostic plug that will automatically lock your doors when you put the gear to D) and since I noticed that the door lock goes crazy, I figured maybe the dongle is causing the problem (plus it’s a third party dongle).

Where is the check gauge light on my car?

Location The Check Gauge light is located on the dashboard. This area is also known as the instrument panel. How the dashboard looks and what gauges are included will vary by the type and brand of vehicle you are driving. Gauges that usually make up the panel watch the amount of oil, gas and battery power, in addition to the engine.

What is the Mil light on a Dodge Grand Caravan?

Description: The check engine warning light, also called the malfunction indicator light (MIL) is related to the onboard diagnostic system called OBD II which monitors exhaust emissions, engine systems and automatic transmission control systems. The check engine warning light when illuminated with either stay on constantly or flash:

What does the ABS light on a Dodge Grand Caravan mean?

Name: Dodge Grand Caravan ABS warning light. Description: The anti-lock brake warning (ABS) light monitors the health of the system. The ABS light turns on briefly when the ignition is placed in the ON/RUN or ACC/ON/RUN position and may stay on for as long as four seconds.

Why does my Dodge Caravan cluster not come on?

My 1999 Dodge Caravan cluster for gas, temp, fuel, rpms and speedomoter will not come on any longer. I have replace the Dodge Repair Questions?

How to find the DTC code on a Dodge Caravan?

Continue to hold the TRIP and RESET buttons until the word CODE appears in the odometer windows (about five seconds) then release the buttons. If a problem exists, the system will display Diagnostic Trouble Codes (DTC’s) If no problem exists, the code 999 (End Test) will momentarily appear . Please write down any codes that appear, Thanks Scott,

Can you replace the instrument cluster on a Dodge Durango?

While quality is a trademark of Dodge, any dash cluster is susceptible to problems at any time. Whether you’ve got a stuck needle on your Durango, a flickering light that’s driving you nuts, or an entirely dead LCD display in your Dodge Caliber, Instrument Cluster Store can help you replace or repair your instrument cluster with ease.

Where can I get Free Dodge instrument clusters?

Free Shipping in the US excludes HI, AK, PR, CA, WA. Search our inventory to get started, or order by phone at 1-800-590-2716 , we’re happy to help! Dodge is a company that’s been relied on for over a century.

Why are the fuel gages on my Dodge truck not working?

Next I pulled up the 1/16 inch on the connector and while I didn’t loose all the gages this time the oil temp and fuel gages dropped to zero! I found that the PCM wire bundle is putting pressure on this connecton against a poorly designed draw down bolt that caused the contacts to become disconnected.

Where are the fuses in a Dodge Caravan?

Dodge Caravan 2017, 2018, 2019. Cigar lighter (power outlet) fuses are the fuses M6, M7 and M36 in the engine compartment fuse box. The integrated power module (IPM) is located in the engine compartment near the battery.

Why does my gas gauge keep pegging full?

The gas gauge might interpret voltage feedback from a dead sender as FULL or EMPTY, consequently pegging the gauge no matter the actual fuel level. Circuit Problems can cause the gas gauge to stop functioning normally.

What’s the problem with my Dodge Grand Caravan AC?

Air vents blew warm air when both temperature controls were turned to cold. Had to use AC when outside temperatures were above 15’C even on cloudy days. Passenger side blows hot air only regardless of heater/air settings. Dealer updated HVAC software to comply with the recall and replaced actuator.

Is there an extended warranty on a Dodge Grand Caravan?

An extended warranty can provide peace of mind. Chart based on 553 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance. 283-horsepower 3.6L V6 6-speed shiftable automatic FWD

Are there warning lights on the Dodge Caravan?

This page covers the dashboard warning lights for the Dodge Caravan and Dodge Grand Caravan. Warning lights are specific to the Dodge Grand Caravan f ourth generation (Mk 4, 2001–2007) and fifth generation (Mk 5, 2008–present). The warning may however be relevant to earlier models also.

Why does the ESC light come on on a Dodge Grand Caravan?

Name: Dodge Grand Caravan Electronic stability control warning light. Description: The electronic stability control system (ESC) combines various stability systems that help to maintain traction when accelerating and help to stabilize the vehicle when cornering. The ESC light comes on for the following reasons:

When did the 2002 Dodge Caravan come out?

Why is my Dodge Caravan not turning over?

Check the body ground under the battery tray and the wires leading to it. While the battery and tray are out of the way it’s an opportune time to remove the adjacent fuse and relay box and check the connectors underneath it for corrosion. It’s a less common cause for the problem, but the hard work to get to it is already done,

Do you need to replace the engine in a Dodge Caravan?

Whether you see steam from your hood, oil patches on your driveway or puffing smoke from your tailpipe, a complete engine replacement is necessary. Dodge Caravan engine parts from AutoZone are fine-tuned for your vehicle’s specific configuration.

Is there an electrical problem with my Dodge Caravan?

Re: Dodge Grand Caravan electrical problem with dash… Hi, I also have a Dodge Grand Caravan 2008 with similar problems.

Where can I Fix my Dodge Grand Caravan?

Here at south Jersey auto body we fix this issue .phone number is (609)-965-7850.I just fixed my 2009 grand caravan. I sodered new wire in so it doesn’t happen again. And srunk wrapped the wires.call us we will fix it.

How does the resistance of a gas gauge change?

The fuel float contacts run on a potentiometer, or variable resistor, whose resistance changes depending on float level, effecting a change in output voltage. Some systems are wired so that high fuel level contacts the low-resistance section, gradually increasing resistance as fuel level drops.

Where is the temp sensor on a Chevy Venture?

Some thermostats can be put in upside down, so pay attention to the arrows on the thermostat. The water should flow from the engine towards the radiator. The temp sensor I think is in the rear passenger side of the engine on top.

Why does my Jeep gauges go crazy with the key off?

JUST NOTICED THAT WITH KEY OFF IF YOU HIT THE WINDSHIELD WIPERS THAT GAUGES WILL MOVE. JEEP DEALERSHIP CAN’T FIGURE IT OUT AND NEITHER CAN MY MECHANIC. MECHANIC THINKS ITS A ELECTRIC PROBLEM? WHAT ABOUT IGNITION? OBVIOUSLY THERE MUST BE SOME JUICE GETTING TO GAUGES WITH KEY OFF. ALSO, JEEP IS IN WON’T START MODE NOW.

Why does my 2002 Jeep Grand Cherokee not start?

SOMETIMES VEHICLE (2002 JEEP GRAND CHEROKEE) WON’T START. YOU GET NOTHING WHEN YOU HIT THE KEY, NO CLICKING, NO NOTHING. YOU MAY GO BACK LATER AND IT WILL START. GAUGES GO CRAZY. WILL COME ON. ODOMETER AND CLOCK WILL FLASH. SOMETIMES SPEEDOMETER WILL GO FROM 60 TO ZERO AND BACK. WILL NOT LOSE POWER THOUGH.

Why does my Ford gauge cluster stop working?

I am assuming the cluster is never the issue in the condition it continues to work koeo and you flexed the board, and it never stopped working in those conditions. If it is dead while running, voltage is killing it or THE CHEAPEST EASIEST FIX EVER IS NEEDED. read the next trouble maker.

Why does the Check Engine light flicker on and off?

At times the car door lock goes crazy (on and off rapidly for a few seconds, sometimes minutes). It goes back to normal after start/stop for many times or driving for about 10-20 minutes and the stop/start, but I wasn’t comfortable with doing that. And even after it goes back to normal the check engine light is lit.

What to do if your Dodge Caravan stalls?

I drove very cautiously with both feet on the petals, keeping an eye on the RPMs checking for a stall, and leave both hands on the wheel basically almost 100 percent of the time in-case it happened during a turn.

Why does my Dodge Caravan shut down while driving?

The dials sweep and the power cuts in and out frequently. Sometimes happens at 30 mph but more frequently when idling at a stop or going 10 mph. Started also dying after 3 months. Worsened to every time it was driven. We checked all apparent grounds, replaced upstream and downstream O sensors.

What kind of engine does a 2006 Dodge Caravan have?

I’ve got a 2006 Dodge Caravan w Cali emissions. The dials sweep and the power cuts in and out frequently. Sometimes happens at 30 mph but more frequently when idling at a stop or going 10 mph. Started also dying after 3 months. Worsened to every time it was driven.

How do you reset fault codes on a Dodge Ram?

When all fault codes have been displayed, the cluster will display “end” or “E” for end in the odometer display. You can also try a reset by disconnected the negative battery cable and leave it over for about 1/2 hour. This should reset most of the codes on your Dodge (just remember that it will also reset the codes on your radio:-)”

How to test the turn signal on a Dodge Grand Caravan?

To test the multifunction switch, use an ohmmeter and connect to the terminal pins in the switch. When the switch is in the left turn position, expect to see 2.7Ω +/-5% between terminals 2 & 3. When the switch is in the right turn position, expect to see 1KΩ +/-5% between terminals 2 & 3.

How does the MUX switch on a Dodge Grand Caravan work?

A mux switch doesn’t switch power to bulbs. It’s built with a series of resistors and is connected to the body control module (BCM). The BCM uses the multifunction switch as an input to tell it what you want the BCM to do.

How does the BCM work on a Dodge Grand Caravan?

So the BCM provides voltage on one wire and depending on the return voltage, the BCM determines what action to take. To remove the switch to test or replace, remove the three Philips screws holding the plastic cowling. The screws are accessed from the bottom of the cowling.

How do you reset the fuel gauge on a car?

If this happens, reset your fuel gauge. Each make and model of car has its own specific instructions on how to reset the fuel gauge, but the process is basically the same. Turn the ignition switch to the “On” position. Press the “Odo/Trip” button until the odometer is put into “ODO” mode. Turn off the ignition.

How do you change the battery in a Dodge Grand Caravan?

Reattach the negative battery cable end to the the negative post on the battery by pressing it firmly onto the post. Tighten the bolt on the negative battery cable until you are unable to move the cable on the battery post. Close the hood of the Grand Caravan.

How do you reset the computer on a Dodge Grand Caravan?

In order to verify that the cause of the problem has been fixed, the computer on your Grand Caravan will need to be reset. This process is simple and takes less than 10 minutes. Pull the hood release lever under the dash to release the hood. Locate the hood latch under the center of the hood and push the latch to the left.

What happens when your gas gauge is not working?

The gas gauge tells you how much fuel is in your gas tank and alerts you when it’s time to refuel. If your gas gauge is not working, the inaccurate information it provides may cause you to run out of gas unexpectedly.

What should I do if my gauges are not working?

The first step in diagnosing this type of issue is to identify the fuse associated with the instrument cluster or gauges. The fuse should have power on both sides when the ignition key is turned to the on position.

Why are my wipers not working on my Dodge Grand Caravan?

If you own a Dodge Grand Caravan, or other Chrysler products, and have a problem with the wipers or other similar accessories, you must first understand how these systems work. First, the switch does NOT connect or disconnect power to the accessory.

What was the cause of the 2014 Dodge Grand Caravan fire?

The contact owned a 2014 Dodge Grand Caravan. The contact stated that while the vehicle was parked and turned off, flames were discovered coming from the rear driver’s side of the vehicle. The fire department was called to the scene and extinguished the fire.

How to fix automatic sliding door on Dodge Grand Caravan?

My wife came home and said the door on our grand caravan was not opening and closing automatically but would work Manually. The easiest thing for me to do was check for a broken wire where there is flexibility. I believe this will work on Chrysler Town and Country vans as well. It was a quick fix even with taking pictures. Loading…

What kind of engine does Dodge Grand Caravan have?

283-horsepower 3.6L V6 6-speed shiftable automatic FWD Flush and recharge freon. Door actuator in sliding door, right side. Also had new key lock installed in driver’s door. Bought van used in 2017. Emergency key did not fit the doors. Dealer that we purchased the vehicle from sent new lock and keys.

Are there any problems with the Dodge Grand Caravan?

Dodge Grand Caravan owners have reported 10 problems related to vehicle shudder (under the power train category). The most recently reported issues are listed below. Also please check out the statistics and reliability analysis of Dodge Grand Caravan based on all problems reported for the Grand Caravan.

Why does my Dodge Grand Caravan make a grinding noise?

March of 2016, 28648 miles, vehicle began making vibration/squealing type noises under the hood. Noise only occureed during idling/in park. Flexplate was replaced. December 2016 upon starting vehicle made a loud squeal/grinding sound. Vehicle was put in park and turned off.

Why does my Dodge Grand Caravan shudder when I downshift?

At slow accelerations vehicle shudders/hesitates to shift. When downshifting it “bumps” down. At 35-40 mph engine races without accelerating. Dealer says clutch plates need 5-10,000 miles to break in after transmission was rebuilt at 2,400 miles.

What should I do about my Dodge Grand Caravan suspension?

Drivers side front hub bearing making growling sound. Replaced both front hub assemblies because I prefer to replaces front end parts in pairs. NOTE: Bad bearings are a known issue on these vans with an extended warranty to 90,000 miles. Front suspension clunking going over bumps. Replaced stabilizer bar bushings.

Why is my Dodge Grand Caravan making noise?

Had low frequency rattling noise from rear suspension. Dealer spent about 1.5 hours to diagnose as noisy shock. Required second trip for repair. Update: within 2000km, the noise has returned. Actually was fixed briefly. Either more defective shocks, or was something else disturbed when shocks were replaced.

Why does my minivan make a clunking noise when going over bumps?

Every Chrysler minivan owner eventually complains about front suspension noise. The suspension makes clunking sounds when going over bumps. The problem can be narrowed down to two components—the stabilizer bar end links, and the stabilizer bar bushings. The stabilizer bar connects to the strut with an end link that contains two ball joints.

What causes a Dodge Grand Caravan to roll?

If the vehicle is in “reverse” and being accelerated up the incline and I remove my foot from the accelerator the vehicle will roll forward down slope without stopping. The closest comparrison is that it feels like driving a vehicle with a manual/standard transmission.

What kind of truck has no bus gauges?

I have a 2000 ram 1500 2X with the 5.9 automatic, however I believe that this is applies to all gen2 trucks regardless of drivetrain or engine type. My Story… See the end to get straight to my find. I’ve had my gauges go out with the “no bus’ message in the odometer window three times now!

After 15 minutes and all the dash panels have been removed for the second time (why didn’t I off load this the first time) it starts working again. But, What did I do??

What should I do if my gauges go out?

I’ve had my gauges go out with the “no bus’ message in the odometer window three times now! Checked all the fused, disconnected the battery, to no avail…..Sound firmilliar?

What to do if your instrument panel lights are not working?

Chrysler does NOT sell replacement LEDs. If you have power and ground to the instrument panel and the LEDs do not work, you must replace the entire instrument panel with a rebuilt unit. The same is true if one of the VFD units fails.

Why does my Chrysler minivan have no crank?

If you still don’t have power coming out of those wires from the PCM, you have a bad PCM. If you now have power, you’ve got a short in the wiring harness to those sensors. A short will cause the PCM to appear dead. Shorts in the CMP and crankshaft position sensor are COMMON.

Why does my Dodge Grand Caravan not start?

It’s a less common cause for the problem, but the hard work to get to it is already done, My 2004 dodge grand caravan wouldn’t turn over. Replaced the battery, and still wouldn’t start. It ended up being the solenoid wire to the starter is loose. If I wiggle it, it will start. Looking to get a replacement wire. Was this answer helpful? Need help.

What makes a 2002 Dodge Cravan stop running?

2002 Dodge Cravan quit running at hwy speed. All instrument lights are working. No service engine light is on. When you turn the key, instrument lights go out and there is a faint click at the fusebox. the battery is charged and the terminals are clean. Wiring at fuse box and computer checked. Fusebox and computer replaced with working ones.

When did the 2001 Dodge Caravan come out?

Why does my car gauge read cold when I Turn on the ignition?

With the ignition on, the gauge should register cold. If you connect the sending unit wire to ground, the gauge should switch to read hot. If the gauge moves as expected, then you can suspect a bad sending unit. If the gauge doesn’t move when you ground out the sensor wire, then you can suspect a bad gauge.

Where did the Dodge Grand Caravan come from?

1st owner purchased on 03/15/06 and owned in FL until 11/21/18 • 2nd owner purchased on 08/27/19 and owned in GA until 01/07/20 • 3rd owner purchased on 01/07/20 and owned in GA until 05/08/21. 1st owner drove an estimated 8,492 miles/year • 2nd owner drove an estimated 0 miles/year • 3rd owner drove an estimated 0 miles/year.

Where can I get a new Dodge Caravan?

Fortunately, CarParts.com can help you fix up your vehicle with a great selection of excellent replacement Dodge Grand Caravan parts available at prices that won’t break the bank. Some Grand Caravan owners have reported issues with its interior parts, specifically with the seats.

Are there any problems with the Dodge Caravan?

Other interior components may have problems over time, such as malfunctioning doors and dashboard accessories. If you’re having interior trouble with your Grand Caravan, you’re absolutely not alone. In addition to the interior, some owners have also observed that its stock components may wear out and fail.

Is the Dodge Caravan a reliable family vehicle?

We’ve Made a Site Update. Refresh to the latest version. The Dodge Grand Caravan is a dependable vehicle with excellent safety features, making it a reliable family vehicle for all your driving needs.

How do you fix a radio in a Dodge Caravan?

Turn off the ignition and set the parking brakes. Open the hood and disconnect the negative battery terminal. Remove the frame from around the radio. Remove four Philips screws. Pull out the radio. Disconnect the main wire harness. Disconnect the antenna wire. Remove the radio and install the new one. Reinstall the radio and frame.

Where is the control module on a Dodge Grand Caravan?

But there is a control module that is also located inside the drivers door and it uses a “twisted pair” of really small gauge SOLID wire (that goes back to the onboard computer). If any of you out there have ever used Ethernet wire you know exactly what I am talking about.

Why does my Dodge Grand Caravan need to be reset?

Spotting any issues can just mean that it needs to be reset to confirm that none of the problems have lingered. Any Dodge Grand Caravan PCM will draw all of its sustenance directly from the car battery. Once the car battery has been disconnected the module is going to shut down.

What does the computer do on a Dodge Grand Caravan?

The Dodge Grand Caravan PCM, or powertrain control module,is the computer that controls everything from the fuel mixture to the emissions regulation system.

How big is a 1999 Dodge Grand Caravan?

Consumer Ratings Rank Vehicles HP #2 2003 Ford Windstar Cargo 200 #3 2001 Ford Windstar Passenger 200 #4 2002 Kia Sedona 195 #15 1999 Dodge Grand Caravan Passenger 158

What should I replace in my 1997 Dodge Grand Caravan?

I have replaced 1 alternator,1 power steering pump,1 water pump,1 cooling fan assembly (with both fans),1 radiator,3 front bearing hubs assemblies, 1 rear rear brake cylinder,1 brake master cylinder,2 front brake calipers among few other things like shocks,struts,brake pads,shoes and rotors, and I have done most of the work myself.

When did I Buy my 1996 Dodge Caravan?

Showing 3 of 375 reviews. I am the original owner of my 1996 Caravan SE, which I bought in July of 1995 It has never left me stranded or had any major repairs. Early on, I heard that many owners of Dodge minivans had problems with their transmissions, so I have been changing the trans fluid and filter every 10,000 miles.

What happens when I repair my instrument cluster?

When you repair your original instrument cluster panel, it will not need to be coded to your vehicle VIN, since it is still the original cluster, and repairs will not change the odometer reading. When UpFix repairs yours instrument cluster, we use new parts that are better than the originals.

What are the warning lights on a Dodge?

What follows is easily the most complete list available of symbols and warnings that may appear in and on your car’s dashboard or instrument cluster. The following are warning lights and indicators found in vehicles built by Dodge. Click a link to learn more about each one.

Why are my dash lights flashing and gauges fluttering?

Eventually it no longer would keep the battery charged. Since replacing it its been running fine since, other than this new issue. These instrument clusters are essentially computers getting digital messages from other vehicle computers which tells what to set the needles at and which lights to light.

Why does my car’s gauge cluster keep flickering?

Seriously, though, if the fuses are fine, there are two paths to investigate and neither is much fun. This kind of thing can usually be narrowed down to a corroded ground wire or a bad connection between the gauge cluster and the main wiring harness.

Why are all the gauges shooting up and down?

All gauges in dashboard shooting up/down like crazy and all indicator lights turn on! Yesterday my wife complained that the gauges on the dashboard are suddenly shooting up and down like crazy, and also all the indicator lights, abs, coolant, door indicators, etc. light up when this happens.

Why are the dash lights flashing on my Chrysler van?

I had this problem on my ’99 van causing the security system to disable the van after the second start of the day and ended up finding a bad solder joint on the ground pin of the communications plug.

How does the security system on a Dodge Caravan work?

The security system on a Dodge Caravan acts as an anti-theft deterrent. The security system uses a proximity sensor and ignition kill switch to help prevent unauthorized vehicle use. While the system is designed to work reliably, there are times when you may experience a false alarm.

Can a Dodge Caravan have a false alarm?

While the system is designed to work reliably, there are times when you may experience a false alarm. When this happens, it can be somewhat embarrassing, especially when you are trying to get in the van.

How do you unlock a Dodge Caravan door?

Turn the key counterclockwise to unlock the door. Turn the key clockwise to initiate the alarm activation sequence. Turn the key counterclockwise. The alarm will stop and reset itself. “Dodge Caravan, Chrysler Voyager, Chrysler Town & Country Repair Manual 2003-2006”; John Wegmann, John H. Haynes; 2006

What to do if your Dodge Caravan shuts off?

While the car is still rolling straight the we can put the car in neutral and restart the vehicle and continue driving but usually we have to make a full stop in the middle of the traffic lane because the wheel is too hard to turn to pull over. There is many instances of other Dodge grand Caravans doing this.

Dodge Caravan owners have reported 26 problems related to engine shut off without warning (under the engine and engine cooling category). The most recently reported issues are listed below. Also please check out the statistics and reliability analysis of Dodge Caravan based on all problems reported for the Caravan.

Is there an engine check light on a Dodge Caravan?

There is no engine check light, and no error in log. The car has already undergone the ignition key recall repair and a 3 day diagnostic at a local Dodge dealer in schaumburg IL, without them finding anything wrong. This is very dangerous as the driver looses power steering, 2 times we almost got into an accident because the car stalled mid turn.

Why are the gauges on my Dodge Grand Caravan not working?