What was the problem with the brake caliper on my Dodge Caravan?

The contact owns a 2008 Dodge Grand Caravan. While driving 30 mph, there was a grinding noise coming from the front driver side wheel. The vehicle was taken to the dealer, but the technician could not find a failure. The brake caliper was repaired. The manufacturer was notified of the failure.

Where are the brake pads on the Dodge Grand Caravan?

See all problems of the 2017 Dodge Grand Caravan . This vehicle has had multiple issues with premature brake pad wear. In fact, in October 2017, the vehicle had the following components replaced: calipers (both front and both rear), rotors (both front and both rear), brake pads (both front and both rear) replaced by pep boys in eastgate, ohio.

When to use handbrake or front brake caliper?

The handbrake prevents the car from rolling when the car is at a complete halt. In extreme circumstances, the driver can use the handbrake to stop the car when the brakes fail. The front brakes often play a greater role in bringing the car to a halt than the rear ones. This does not mean you should replace one and ignore the other.

What to do if your brake caliper fails?

I was able to return it by lightly tapping the e-brake lever to the off position. At that point the brake caliper mostly worked as it should. However, re-applying the e-brake would again refreeze the brake to full on. I replaced with a mopar oem caliper and all is well again. I suspect the e-brake mechanism within the caliper failed.

How do you replace brake line on Dodge?

>>Join the conversation about replacing the brake line right here in Dodge Forum. Installation of the new brake line is the reverse of removal. Attach the banjo bolt end to the caliper first, and then attach it to the metal line fitting. Place the line in the bracket that attaches it to the frame, and tighten everything up.

Where does the brake line go on a car?

On most cars and trucks, a flexible rubber brake line goes from the brake reservoir, through the frame, and into the brake caliper, which is attached to the wheel. This allows the wheels to move up, down, and turn while also making sure that the brake line can move with it without interfering.

What causes rear brake caliper to jam while driving?

Rear calipers jamed because of excessive and unusual rust. Steering wheel jamed few times while driving, being necessary to stop the car, turning the engine off and on to be able to continue driving (this happened on the highway, and in the city, extremely dangerous).

Where are the brake caliper guide pins located?

To fix this, you have to remove the brake pads and clean the brake pad bracket with a file or sandpaper and lubricate it with copper paste or something similar. The brake caliper guide pins are located at the brake caliper bracket and help the caliper to slide forward and backward when you are braking.

Do you have to bleed all 4 brakes when changing a caliper?

That’ll be the right hand rear wheel on most cars. If your car or truck has one brake line feeding both rear wheels, you’ll need to bleed both of these first before moving to the passenger side front (next closest). Then finally the drivers wheel. Most brake fluid types are hygroscopic, they absorb moisture from the atmosphere.

Are there any problems with the Dodge Grand Caravan?

See all problems of the 2010 Dodge Grand Caravan . Calipers seized up going down the highway had to stop back right tire was smoking van is in the shop being repaired. The contact owns a 2008 Dodge Grand Caravan. While driving 55 mph, the abs, esp, and brake warning indicators illuminated.

What’s the transmission problem on a Dodge Caravan?

Dealer assured us that Dodge had fixed the notorious transmission problems associated with Caravans. This car should be called the Dodge Random; everything simply works randomly. Doors, windows, locks, engine – you never know from day to day when things will work. Expensive repairs to make them work are only temporary.

Is there a problem with my 2008 Dodge Grand Caravan?

No one has added a helpful site for this 2008 Grand Caravan problem yet. Be the first! Read reviews of repair shops in your area. Enter your zip code: I replaced the left rear bearing and about 6 months later the right rear bearing has gone out. I have replaced the brake pads all around several times.

How long has my Dodge Grand Caravan wheel bearing been failing?

Still have two years to pay on this turd before I will trade it in on something new. I’ve had this 2008 Dodge Grand Caravan for 4 years now. My driver side wheel bearing is failing for the 3rd time. I have replaced the pass side bearing hub twice as well and I just now clicked over 100k miles.

What kind of noise does a Dodge Caravan make?

Tl- the contact owns a 2016 Dodge Grand Caravan. The contact stated while driving 45 mph, when he heard an abnormal noise. The contact stated check engine warning light was illuminated. The contact was able to park on the side of the road. The vehicle was not drivable.

Are there any suspension problems with the Dodge Grand Caravan?

283-horsepower 3.6L V6 6-speed shiftable automatic FWD Shocks rattling in rear. Dealer replaced under warrany. Rear shocks were replaced after “thunk” noise noticed. Replaced rear srut for the second time. Wheel bearing failed and was seized on axle. Left rear wheel bearing howling. Repalaced wheel bearing Rear shocks very noisy.

Why does my Dodge Caravan whine when accelerating?

Power Steering The power steering pump is a very common reason why your Dodge Caravan might whine when accelerating. If it gets too low on fluid they’ll make the it’ll whine a lot. You need to check the fluid level and fill it back up to the factory fill line. The pump can also go out.

What kind of brake fluid does Dodge Caravan use?

Dodge requires DOT 4 brake fluid for the Caravan. This type of brake fluid is recommended because of the kinematic viscosity requirements of ABS and ESC systems. Also, the soft seals inside the master cylinder are designed of DOT 4.

What kind of brake problem does Dodge Grand Caravan have?

Rear Passenger Caliper pin had seized causing rapid uneven wear of pads and rotor. Replaced caliper bracket, pins and boots, brake pads and rotor. 283-horsepower 3.6L V6 6-speed shiftable automatic FWD Parking break cable and harness broke.

How much does it cost to repair a Dodge Grand Caravan?

SLIDING DOOR TRACK WIRING HARNESS was replaced, brake pads, rotors, oil pan, front calipers, tune up, and finally will have to replace transmission, that is another $2000 dollars added to this lemon nightmare. Total repair amount $4000 dollars and counting.

What causes front brake to lock up on Highway?

Caused front brakes to lock up on highway.Fluid not changed when brakes repaired. Rebuilt brake caliper, piston sticking in caliper due to corrosion. Piston in brake calipers sticking. Brakes not releasing all the way. Removed caliper and disassembled, sanded inside of caliper and outer surface of piston.

Can you stop a 2008 Dodge Grand Caravan?

Stopping your 2008 Dodge Grand Caravan safely means maintaining the entire brake system and not waiting until something wears out completely or breaks.

Why does my brake caliper lock up when I drive?

The most common reason for the calipers locking up when you are driving is that the caliper piston is seizing in the bore and not releasing. If this is the case, then a piston replacement is necessary.

What should I do if my brake caliper keeps sticking?

Car Pulling – This is one of the most common symptoms of a sticky brake caliper. If you notice your vehicle pulling too far to the right or too far to the left, then replace your brake caliper immediately.

Why did my brakes go out on my minivan?

They may have dropped the caliper and/or damaged the hose in some way. Bottom line is that calipers do act up but not two at a time this early in their life usually. I have seen older calipers go within a month of each other. There is a TSB on the brakes – specifically the rear calipers and brakes.

How to compress rear brake caliper piston on Dodge Grand Caravan?

If you are replacing the rear brake pads on Dodge Grand Caravan or Chrysler Town and Country with regular non HD brakes and you are trying to figure out how to compress the rear caliper piston so you can install we will show you how to compress the rear brake caliper piston with caliper compressor tool.

Why are the brakes on my Dodge Caravan not working?

See all problems of the 2013 Dodge Grand Caravan . Rear calipers continue to seize even after repair and replacement. This causes the rear brakes to grind down the pads and rotors. A quick online search revealed over 200 consumers with the same complaint.

What to do if you have a seized brake caliper?

Unsticking a Seized Brake Caliper If the cause of your brake issue is the parking brake cable/mechanism, a skewed pad, or the pads sticking to the disc, the remedy is fairly simple. Lubricating the parking brake system should fix that issue, and removing the pads and applying a small amount of grease to the edge should fix skewed pads.

What happens when you have a problem with your brake calipers?

Whenever you have issues with the brake calipers, you will have problems stopping the car. This can be dangerous, especially when you are traveling at high speeds. The brake calipers have pads attached to them that clap on the wheel rotors.

When to replace brake pads and calipers in Dodge Ram?

If planning to replace the brake calipers as well as brake pads, the brake line should be loosend prior to removing the caliper. This will allow for more leverage as the brake line can often be frozen in place and difficult to loosen if the caliper has been removed.

How do you replace the front brake caliper?

With the front brake caliper removed from the steering knuckle (see Step 2), remove the brake line from the caliper using a 3/8″ combination wrench or socket. Figure 8. Brake line removal. Install the the brake line into the new brake caliper.

What do you use to tie brake pads on Dodge Ram?

The use of a rubber snubber, wire hanger, or bungie strap are popular methods of tying the caliper up and out of the way without damaging the brake line. The rear brakes on the 2nd Generation Ram are of a drum design and are a bit more complex than contemporary disc brakes.

What happens if you have a bad brake caliper?

Over time disc brake calipers can leak brake fluid or the caliper pistons can freeze-up, greatly reducing overall braking efficiency. A failing brake caliper can even cause erratic handling during braking. NAPA has brand new brake calipers and premium 100% remanufactured calipers for almost every application.

Are there rear brakes on a 2009 Chrysler minivan?

There is no TSB about rear brakes on a 2009 Chrysler van. I wonder if Andy is on to something. If someone didn’t know better, used some tool to try to compress the caliper, I could see that locking the caliper up as the calipers screw out and in and do not compress only by brake fluid pressure.

How much does it cost to replace brake caliper on Dodge Grand Caravan?

Dodge Grand Caravan Brake Caliper Replacement costs $237 on average. Following is a breakdown of the labor and parts estimates. What is the Brake Caliper all about? Most cars come with disc brakes in the front, and many models also have disc brakes in the rear. A caliper is part of the disc brake system.

Where can I get a brake caliper replacement?

Dodge Grand Caravan Brake Caliper Replacement at your home or office. Our mobile mechanics offer services 7 days a week. Upfront and transparent pricing. Our certified mobile mechanics can come to your home or office 7 days a week between 7 AM and 9 PM.

What causes brakes to shimmy right after rotor and pad?

The shimmy feeling that comes from brakes is usually due to uneven friction material build-up on the rotor. This transfer from pad to rotor is supposed to happen, indeed it makes the brakes work better, which is why brakes function better after break-in.

What was the problem with the brake caliper on my Dodge Caravan?