Do you need AWD transfer case for Astro Safari?

AWD Transfer Cases. If you have an AWD or 4WD vehicle, please ensure that your tires are the same size(diameter) and properly inflated all around, this is extremely important on AWD and 4WD vehicles. If you find that the front prop shaft has been removed, it would be wise to check that the rear end ratio matches the front.

Can a Borg-Warner full time AWD transfer case be removed?

If you find that the front prop shaft has been removed, it would be wise to check that the rear end ratio matches the front. Some will pull the shaft if they replaced the rear with a different ratio (dumb, but it happens). 90-98 used a Borg-Warner 4472 full time AWD transfer case, uses regular ATF.

Can a new venture case be used as a transfer case?

Can be disabled by removing the Automatic Transfer Case 20amp fuse in the under hood convenience center. Uses ONLY AutoTrak2 fluid! You can also install the Borg-Warner case in place of New Venture case, you would just need to grab the front and rear propeller/drive shafts that fit the Borg-Warner case.

Is the Valvoline transfer case fluid compatible with auto Trak II?

It appears that Valvoline states that their universal transfer case fluid, Valvoline Transfer Case Fluid Part # 855459 (~$10 a quart) is compatible with Auto Trak II.

Can a Astro AWD be converted to 4WD?

This time I’m documenting converting the Astro from All Wheel Drive (AWD) to proper Four Wheel Drive (4WD) with a 2-speed NP233 Transfer Case from a 2000 S-10 Blazer LS 2-door. (Thanks again, General, for making parts-interchange work so well!)

Can you change transfer case on AWD car?

Wiring in the shift-selection switches would have also required potentially cutting up part of the dashboard and making a few other non-reversible changes. First things first. The transfer case and eBay replacement front driveshaft (to cure my clunk/knock/click issue) bolt in without modification. This is down to careful parts sourcing.

What is the encoder motor for Astro Safari AWD?

99-05 encoder motor: http://amzn.to/2tV0Y3K Rectangular Plug w/2 Pins, Fits New Venture Gear 136/236/246, RPO Code NP4 (All Wheel Drive Transfer Case) Torque to 15ftlbs. 99-05 Transfer case actuator (encoder motor)insulator https://amzn.to/2qQdmmq and front shaft spline seal (Shaft To Yoke)GM 12544077

How to change AWD fluid in Astro Safari?

First check tires for even wear and pressure, rotate/swap tires around. Second step is to replace the fluid with AT2, then do a bunch of figure 8s, put 50-100miles on it, and then replace the fluid again with AT2. Note that the clutch packs can hold the old fluid for several hundred miles.

Is there a 2000 Chevy Astro conversion van?

2000 chevrolet astro vanhightop conversion van4.3l v6 f ohv 12v enginerear… To see all the great qualities this 2000 chevrolet astro van. Has to offer… Wownbsp this conversion astro van is like newnbsp super clean, inside and out.Nbsp previous one owner vehicle.Nbsp plenty of interior room.Nbsp equipped…

What kind of car is the Chevy Astro?

1999 chevrolet astro base with 138,676 miles for $3,310. Located in rapid city, sd. 1999 chevrolet astro base passenger dark forest green… 2002 chevrolet astro van, 2002 chevrolet astro cargo van, six cylinder auto, ac, (exempt from odometer disclosure – reads 166,030 mis) (starts…

When did the Astro 4 wheel drive come out?

Starting in 1990, antilock brakes acted on all four wheels (front-disc/rear-drum). Full-time 4-wheel drive also arrived as an option for 1990. An extended-length body was added during the model year, with ten inches tacked onto the rear for nearly 19 extra cubic feet of cargo capacity.

What should ESP be on Astro Safari AWD?

All tires should be within 1/4″ of each other esp on BW4472. If you find that the front prop shaft has been removed, it would be wise to check that the rear end ratio matches the front. Some will pull the shaft if they replaced the rear with a different ratio (dumb, but it happens).

When did I Buy my used Chevy Astro?

No accident or damage reported to CARFAX. 1st owner purchased on 05/10/00 and owned in NY until 02/01/10 • 2nd owner purchased on 05/25/11 and owned in SC until 02/11/12 • 3rd owner purchased on 03/28/12 and owned in NC until .

Who was the original owner of the Astro?

No accident or damage reported to CARFAX. 1st owner purchased on 04/06/01 and owned in CA until 01/07/05 • 2nd owner purchased on 05/29/05 and owned in CA until 02/16/21. 1st owner drove an estimated 11,462 miles/year • 2nd owner drove an estimated 5,102 miles/year.

How many miles does a Chevy Astro drive?

1st owner purchased on 02/10/04 and owned in CA until 04/03/04 • 2nd owner purchased on 05/11/04 and owned in CA until 10/16/20. 1st owner drove an estimated 0 miles/year • 2nd owner drove an estimated 8,198 miles/year.

When was the last time I serviced my Astro?

1st owner drove an estimated 0 miles/year • 2nd owner drove an estimated 0 miles/year • 3rd owner drove an estimated 0 miles/year • 4th owner drove an estimated 0 miles/year. Last serviced at 213,699 miles in Loris, SC on 04/02/21 • Vehicle serviced • Brakes serviced • Serpentine belt replaced • Brakes checked.

What are the values of a 2003 Astro?

Kind of rough around the edges went through two families what is mechanically sound runs great drives great everything works carpets and Headliners a little worn got a dent on the driver door front passenger fender all doors open all power windows go down second transmission

How many extra miles does Chevy Astro have?

RV friends caravanned with us, but we usually drove when group went sight-seeing. Has drivetrain disconnect so could be towed behind the motorhome, therefore, has 20K to 25K additional miles since odometer does not record towed miles.

Is there a wheel chair lift in the Astro?

This Van has a Hyd. Lift rated at 1K lb capacity. Difficult in HIGH Wind, NOT IMPOSSIBLE. Engine is in great condition. Vehicle has been and is serviced at regular intervals. Very good on highway travel and city travel. It is a high top with a wheel chair lift in rear for Handicap use.

What kind of drive does Chevy Astro have?

Still available with either rear-wheel drive (RWD) or all-wheel drive (AWD), the Astro is positioned between Chevys FWD Venture and the full-size, RWD Express. For the 2003 model year, the Astro minivan gets standard four-wheel disc brakes.

When did the Chevy Astro minivan come out?

Introduced in 1985 as a rival to the first front-wheel-drive (FWD) Chrysler minivans, the midsize, truck-based Astro was Chevrolets original entrant into that market. Still available with either rear-wheel drive (RWD) or all-wheel drive (AWD), the Astro is positioned between Chevys FWD Venture and the full-size, RWD Express.

What’s the towing capacity of a 2003 Astro?

A RWD passenger model can tow up to 5,400 pounds, while the Cargo Van is capable of pulling 5,800 pounds. AWD Astros offer towing capacities that are 200 to 300 pounds lower.

How does the transfer case output shaft work?

Inside the case are a series of gear reductions and chain drives that work together to accomplish their task of supplying power to the drive axles, making the vehicle four wheel drive. The transfer case output shaft is the part that connects the case to the axle.

How does the transfer case in a car work?

The transfer case completes the activation between two-wheel drive neutral, to low four-wheel, and then to drive four-wheel. Inside the case are a series of gear reductions and chain drives that work together to accomplish their task of supplying power to the drive axles, making the vehicle four wheel drive.