Can you reuse diesel injector seals?

Can you reuse diesel injector seals?

If they are off the injector, Get a propane torch and anneal them heat them up till they glow red and stick them in a cup of cold water and reuse.

Is the TDCi injector trouble on the Mondeo?

Mondeo Fans – TDCi injector trouble – how imminent is breakdown? 142,000 mile 2.0TDCi, all the classic signs of injector angst: white smoke, diesel smell and rough idle from cold start, 30 seconds later it seems fine. Slightly clattery at 1750rpm under load (DMF knacked too, or injectors?) I’ve heard this could be a £1,000 job.

Is there a problem with my 1.6 TDCi injector seal?

I have a 1.6 tdci (2006) and i think i may have a problem with the injecter seal on cylinder number 4 (or number 1, its the one nearest the gearbox). Looks like oil/fuel is pooling around the bottom of it. Also getting white-ish smoke on start up which stinks of burnt diesel, which is getting worse and starting to stink the cabin out.

What is the problem with the Mondeo diesel pump?

“The problem is in the diesel pump which has a manufacturing defect. the cams and rollers are case hardened but a number of pumps have a problem whereby the case hardening fractures and contaminates the whole fuel system with small chards of hardened steel.” well well well well, some companies NEVER learn.

When was the last time a Mondeo had a breakdown?

This topic has 13 replies, 5 voices, and was last updated 11 years ago by AB. Mondeo Fans – TDCi injector trouble – how imminent is breakdown? 142,000 mile 2.0TDCi, all the classic signs of injector angst: white smoke, diesel smell and rough idle from cold start, 30 seconds later it seems fine.

Can a bad injector cause a Ford Mondeo to go bad?

That being said, bad fuel injectors are one of the more common issues that happen to any vehicle (Ford Mondeo included). There’s always more than one, and one going bad is enough to make a noticeable impact on the drivability of the vehicle. There are two main ways that your injectors can go bad.

What to do about diesel fuel leak in Mondeo?

A replacement of the copper washer fitted to the base of a diesel fuel injector to stop engine compression leaking past the injector and building up tar like deposits. The engine shown can be found in ford mondeo 2litre diesel and peugeot expert vans, euro cabs and peugeot e7 taxi cabs. Loading…

What is the problem with Mondeo 2 LTR TDCi injector?

The problem is in the diesel pump which has a manufacturing defect. the cams and rollers are case hardened but a number of pumps have a problem whereby the case hardening fractures and contaminates the whole fuel system with small chards of hardened steel. Total replacement of fuel system and flushing of tank is the only cure.

How much does a DMF cost for a Mondeo?

Upside is that the DMF wasn’t in fact knackered, it was the fuel pressure dropping due to the loss from back flow of the injectors so don’t need to change that. Injectors were £200 + VAT each + fitting so you’re looking at ~£1300.