Why does my gauge quit working on my Chevy Silverado?

20″ of a cooper braided ground wire on the drivers rear side came out on a chunk of snow that I kicked off. My voltage meter quit working today … read more Auto repair pro, 30 years ex… Hi, I have a 1999 chevy silverado with gauge problems. I see it’s a common problem, but my problem may be the result of a parasitic draw, … read more

Why did my instrument cluster quit working on my 2003 Silverado?

I have a 2003 GMC Serria 1500HD 4WD that the gauges quit working today from the Tach, gas, oil, temp and etc. How can this be fixed? Thanks … read more MY 2003 Silverado XT instrument gauges didn’t work anymore after getting gas. I’ve checked fuses. Everything else seems to be working fine. … read more

Why are my dash gauges not working on my 2002 Chevy 2500HD?

I have a 2002 chevy 2500hd 4×4 my fuel,trans temp,and engine temp,gear select and message center flashes what is the problem it happens and stops and starts up again went almost a year and started again You can’t post conmments that contain an email address.

What should I do if my gauges are not working?

The first step in diagnosing this type of issue is to identify the fuse associated with the instrument cluster or gauges. The fuse should have power on both sides when the ignition key is turned to the on position.

Why are my fuel gauges not working on my Chevy Silverado?

In fact, this is,unfortunately, a common problem among most GM vehicles built from 2003-2006 – various gauges in the instrument clusters of these cars and trucks tend to fail as the mileage starts to get into the “high” zone. This problem is caused by defective drive motors that were used on the circuit boards of these instrument clusters.

Why is my speedometer stuck on my GM Silverado?

This section will outline all the most common problems that have been identified. The most common instrument cluster problem seen on the 03-06 GMs is faulty analog gauges. This is usually the first gauge problem the vehicle owner sees and is experienced as a stuck, sticky or jumpy gauge needle.

Why are all of the gauges in my car not working?

There are a lot of different types of instrument cluster designs and configurations, but when all of the gauges in a car stop working at once, the problem is usually either a fuse or wiring problem. The first step in diagnosing this type of issue is to identify the fuse associated with the instrument cluster or gauges.

Why does my GMC 2500 6.6L Duramax stop running?

My GMC 2500 6.6L Duramax… My GMC 2500 6.6L Duramax Diesel stopped running and will not start. Turns over but sounds like it gets no fuel. Has happened in past and dealer fixed short in wire. That time it would blow fuse but not this time.

Why is my Chevy 2500HD oil gauge not working?

04 2500 HD DURAMAX DASH PROBLEMS. Tach works for awhile then stops altogether, will work when I drive the next time. Know my oil gauge is acting up. Checked with GM dealer, they informed me that the warranty on the dash ran out at 70,000mi. (85000) when my problems started. Whole panel has to be replaced. 04 2500 HD DURAMAX DASH PROBLEMS.

Why is my GMC Duramax instrument cluster not working?

There are 2 pins with 12v to the cluster, but no “spin” of stepper motors, when the key is in the on position no battery light, no seatbelt light, the bright light indicator doesnt come on. No obvious damage, no bent pins, no resistor or led wires touching.

Why are the dash gauges on my Chevy Silverado not working?

There are known issues with the gauges on the 03 silverado. Even though the cages appear analog, they are stepper motor controlled by the computer. This is a fancy way of saying digital. Check with the dealer about a recall! Since all gauges appear to have quit at one time I would agree with a previous post that the computer program is flawed.

What makes a Chevy Silverado 1500 stop working?

I have a 2004 chevrolet silverado 1500. I was going down the road and noticed the gauges had quit working except spedometer and tach. Then I noticed windows, door locks and radio quit working. The battery light, abs,and a car with a lock symbol was on.

Why is the message center not working on my 2003 Silverado?

An expert who has achieved level 1. An expert that has 1 follower. I have a 2003 silverado 2500hd and sometimes when I start the truck the message center won’t come on but if drive it about five miles and shut the truck off and start it again it will come on You can’t post conmments that contain an email address.

Why is my Cluster gauge on my Tahoe Yukon not working?

After a little research it turned out to be a common problem where the seven little surface mount resitors that power the display overheat and break the solder connections. It was simple to reflow the solder with a little flux and a drop of fresh solder.

How to repair a stuck or dead GM tachometer?

In this tutorial you’ll learn how to repair a sticky, stuck, jumpy or dead GM speedometer, tachometer, fuel gauge, oil pressure gauge, volt meter, water temperature gauge and transmission temperature gauge.

Why does my Chev Silverado have no tach?

2003 Chev Silverado. All instrument cluster gauges quit today. No speedo, tach, fuel ,temp, oil etc. Never any problem 2003 chevy: All instrument cluster gauges quit today..speedo..tach… My oil pressure, fuel, coolant temp, and battery voltage gauge don’t work. My Speedo and tach work fine. I also have a battery and abs light on.

Why did my voltage meter quit working on my Chev Silverado?

20″ of a cooper braided ground wire on the drivers rear side came out on a chunk of snow that I kicked off. My voltage meter quit working today … read more

What to do if your gas gauge fails to move?

If the float is OK and the float arm seems to be swinging freely through its full range, replace the tank unit. Ground the gas tank terminal post of the tank sending unit using a jumper wire. If the dash gauge now reeds empty, the gas tank unit is defective. If the dash gauge needle fails t move, the dash gauge is defective.

When does the Speedo stop working on a Chevy Silverado?

After driving for an hour and a half to two hours the speedo will stop working. The speed reading will keep going up and not return to 0. The reading on the volt gauge … read more

What kind of car is a 2003 Chev Silverado?

Vocational, Technical or Tra… I have a 2003 Chev Silverado Quad Cab 2500 4×4 and the dashboard has gone dead. Leading up to now it would periodically reset itself … read more

Why is the speedometer on my Chevy truck not working?

Inaccurate readings after changes to your Chevy: This is common with truck and SUV owners who change their wheels and tires, but can also happen if the wheel/tire combo is changed on a car. Larger combos, or those with different dimensions, will cause an inaccurate reading and the speedometer must be re-calibrated to regain accuracy.

Are there Trans temp gauges on GM trucks?

If you were to get a Escalade Dash Cluster,which has the Transmission Temp gauge.The only item that needs to be done, is to have the Mileage programmed into the Escalade Cluster……the 99′ and up NBS Siverado’s/Sierra’s Were-n-Are Already Pre-Wired from the Factory for the Trans Temp Gauge.

What causes a bad gauge cluster in a Chevy Silverado?

Individual gauge problems are almost universally caused by failing gauge motors. Each gauge is controlled by one gauge motor called a stepper motor. For example, an instrument cluster with 6 analog gauges will have 6 stepper motors.

Why are all the gauges on my GM Truck not working?

Last night I was comin home from the store and realized my speedometer wasn’t working (ins’t the first time) so i hit the dash, then realized NONE of the gauges were working.. Gas gauge, almost empty. Water temp, cold. No oil pressure. The alt wasn’t charging. No tac and no speedometer.

Can you replace an instrument cluster in a GM Silverado?

GM will replace instrument clusters with used instrument clusters that have been rebuilt when a replacement is required. They then send your old instrument cluster to their 3rd party repair partner to be rebuilt and sold to the next customer needing it.

How to de-soldier GM instrument cluster gauge stepper motor?

It doesn’t take much heat to de-soldier. Temp at 375, and a quick touch for 2 or 3 seconds max. I only used the soldier sucker on the stepper Motors. 2. The stepper motors are pinned through the circuit board, but the lights are surface mount.

What is the instument cluster on a 2003 Chev Silverado?

Vocational, Technical or Tra… Hi my name isXXXXX have a 2003 Chev Silverado ext 4×4, 5.3 ltr and my instument cluster is on the “blink”. When i turn the key on all the lights … read more

What to do if your coolant gauge is not working?

Using your coolant temperature gauge as an example, the diagnostic procedure involves locating and disconnecting the sending unit. With the ignition on, the gauge should register cold. If you connect the sending unit wire to ground, the gauge should switch to read hot.

Why does the temperature gauge on my AC not work?

The temperature gauge dropping should not matter to the AC system as it only cares that the coolant temperature is below 253 degrees. However it could be a symptom of the problem.

Why is my coolant temp gauge not working?

The coolant temp gauge gets its input from the BCM and the AC gets told to do its thing there as well. You could have anything from a dirty connector (“fretting”) to a failed BCM.

Why are all my instrument cluster gauges quitting?

2003 chevy: All instrument cluster gauges quit today..speedo..tach… My oil pressure, fuel, coolant temp, and battery voltage gauge don’t work. My Speedo and tach work fine. I also have a battery and abs light on. My … read more Vocational, Technical or Tra… Vocational, Technical or Tra…

What does it mean when your speedometer is not working?

If the oil pressure, coolant, charge, or gas gauge doesn’t work or works erratically, the problem is in the gauge, wiring, or sender. Speedometers are unique in that some of them use physical cables instead of sensors, so a speedometer not working can also indicate a broken cable or stripped gear.

20″ of a cooper braided ground wire on the drivers rear side came out on a chunk of snow that I kicked off. My voltage meter quit working today … read more

When does the Speedo stop working on a 2005 Chevy subrban?

I have a 2005 chevy subrban. After driving for an hour and a half to two hours the speedo will stop working. The speed reading will keep going up and not return to 0. The reading on the volt gauge … read more

Where is the gas gauge located on a Chevy truck?

The gas gauge, often located in the instrument cluster, consists of two small coils spaced 90 degrees apart with an armature and a needle placed at the intersection of the two coils. A dampener is also located on the armature to prevent excessive needle movement on rough roads.

Are there any problems with the GM gauge clusters?

The next most common problem seen on GM instrument clusters are failing digital displays. This problem is unrelated to the stepper motor problem but is often seen in the same clusters. Most GM gauge clusters of this time frame have two digital displays – the odometer and the gear indicator (commonly called the PRNDL screen).

Why does my Chevrolet have intermittent electrical problem?

The likely hood of the positive cable as the root cause of a Chevrolet intermittent electrical problem just got a boost. Interestingly enough, when people have problems with the General Motors positive battery cable they often complain about the power door lock actuators activating by themselves.

Why is my oil pressure reading low on my GMC?

In this video we show common causes and solutions for GM vehicle experiencing low or no oil pressure reading on the instrument panel. This condition may also include a low oil pressure warning on the drivers information display and an illuminated check engine light and/or stored codes P0521 P0523 Watch this video for more information.

Vocational, Technical or Tra… Hi my name isXXXXX have a 2003 Chev Silverado ext 4×4, 5.3 ltr and my instument cluster is on the “blink”. When i turn the key on all the lights … read more

Why does my gauge quit working on my Chevy Silverado?