Why does my Chevy Silverado blow hot air on one side?

This article applies to the Chevrolet Silverado (1999-Present). Does your Silverado blow hot air on one side and cold air on the other? If you have dual zone controls you may have run into this problem before. There is a way to fix this if you’re patient and willing to troubleshoot your way through it.

What to do about HVAC issues on a Chevy Silverado?

If you’ve noticed the control issues happening after disconnecting the battery or having repair work done, then the quickest fix is to recalibrate the HVAC. Turn the ignition off. Find the three HVAC fuses; Two are under the hood and one is in the cab fuse box.

Why does my GM Truck AC keep blowing out?

The 1995 and earlier have a different circuit board layout, the transistor numbers and concept should still apply but the the locations shown in the video will be different. If you find that the transistor keeps blowing out after replacement, then its because of too much current passing thru due to a short to ground in the circuit.

Where are the HVAC fuses in a Chevy Silverado?

Turn the ignition off. Find the three HVAC fuses; Two are under the hood and one is in the cab fuse box. Turn the AC and heater switches to the off position, and turn the temperature controls to the coldest setting. Set the HVAC to automatic. Plug in the fuses. Start the engine and let it run for five minutes.

Why is my heater not working in my Chevy Tahoe?

One or more heater & AC (HVAC) air delivery and/or temperature mode door actuator may fail. This can result in incorrect air delivery or temperature. If this occurs, fault code(s) stored in the HVAC control module should be available to assist with diagnoses. Chevrolet Tahoe Vehicles With This Problem.

Why is my Chevy Tahoe not blowing cold air?

One of the most inconvenient vehicular problems is when the A/C won’t blow cold air. If your Chevy Tahoe isn’t keeping you cool, we’ve outlined some of the most common reasons why this might be happening.

How much does it cost to fix a Chevy Tahoe heater?

One or more heater & AC (HVAC) air delivery and/or temperature mode door actuator may fail. This can result in incorrect air delivery or temperature. If this occurs, fault code (s) stored in the HVAC control module should be available to assist with diagnoses. The average cost for a Chevrolet Tahoe AC Diagnosis is between $53 -$67.

How can I get my Chevy Tahoe AC back on?

I can get the AC back on only by shutting off the vehicle. The switch from AC to HOT seems to get worse starting about @ 85 degrees and when it’s @ 100 degrees the AC stays on a very short while. When the AC is working, it is very cold. The vents facing the driver blow out hot air when the air conditioner is on.

How can I tell if my Chevy Silverado is overheating?

This suggests to me that the coolant is being boiled by ADDED heat, not just normal engine operation. You can test for a bad head gasket by using a coolant pressure pump.

Why is my Chevy Silverado heater not working?

One of the most common (and inconvenient) problems with the Chevy Silverado is when it has no heat coming from the heater. Not having a functioning heater makes driving much less comfortable, and can be a sign of certain issues. At the simplest level, there are two main reasons why the heater is not working.

Why does my AC keep blowing hot air?

Recently when running the AC, it will randomly begin blowing hot air instead of cold. No matter what I try, the only proven way to get cold air to blow again is to shut the engine off, wait around 5 seconds, then crank back up. After doing this everything seems to work fine for a week or so…then the AC starts blowing hot air again.

Why is my Silverado Sierra blowing cold air?

After fiddling with the controls a bit I gave up and rolled the windows down. About five minutes later it was eating at me so I switched the control from off to max and the fan kicked on like it was supposed to and was blowing cold air.

Why does my 2005 Tahoe blow hot air?

My 2005 Tahoe hava AC giving hot air problem. AC would suddenly blow hot air just on the driver’s side while the passenger side still blew cold. The only way to correct it was to turn the car off and back on and then it would immediately start blowing cold again. This happens intermitently.

Why did my Chevy Silverado blower plug burn up?

Most aftermarket companies, NAPA CARQUEST ADVANCE will have replacement plugs you can splice in for about half the price of a GM plug kit, and they burn up because GM cheaped out on the size of the terminals and they get hot, when they get hot they loose tension which causes them the get really hot and melt the plastic plug.

What’s the problem with my Chevy Silverado heater?

Fan is working, and some cool air seems to be sneaking thru, but it appears the vent actuators are not working. Have not been able to remedy the problem yet. I’ve changed the drivers side dual blend door actuator but the heat will intermittently blow hot to cold air. On the drivers side and the passenger side is completely fine.

What are the vents on a Chevy Silverado?

Modern trucks make use of blend doors, which are plastic flaps found inside of the vents that act as a gateway for hot or cold air to pass through. These doors are controlled by electrical actuators, which respond to the buttons pressed on the dashboard.

Why do my vents blow only hot or cold air?

Chevrolet Silverado 1999-2006: Why Do My Vents Blow Only Hot or Cold Air? The Chevy Silverado climate control system uses several different components that come together to either cool down or heat up the cabin. When one or more of these components fails, the heat or cold air capabilities go along with it.

Why is there no air coming out of the vents?

This should cause the control head to go through a sync mode with all the output devices (mode, recirc, etc.). It’s a long shot, but sometimes those control heads go out of sync for no obvious reason.

Where are the vents on my GMC Sierra?

No output on dash face vents or defrost vents but floor works ok. I have tried the pulling the fuses both under hood and left of dash but that did not fix my problem.

How to troubleshoot and repair vents low air flow?

Easy step by step guide one how to troubleshoot and repair vent low air flow, this article pertains to most vehicles. Step 1 – Most air control vents are equipped with a flow control door that is located at the vent outlet. This door is controlled by a thumb wheel that when activated will open and close the vent air flow door.

No output on dash face vents or defrost vents but floor works ok. I have tried the pulling the fuses both under hood and left of dash but that did not fix my problem.

How do I stop no air from dashboard vents?

This door is controlled by a thumb wheel that when activated will open and close the vent air flow door. Work the thumb wheel from one side to the other while checking the airflow. The flow should stop and start again, if the thumb wheel does not make a difference the problem is somewhere else.

What does it mean when AC blows hot air on one side?

AC Blows Hot or Cold Air on One Side with Clicking Sound. If you experience the symptom of the AC blowing hot or cold air on one side but not the other and it’s accompanied by a clicking or ticking sound, it probably means a gear in the temperature blend door actuator is faulty and the actuator needs to be replaced.

What causes hot air to blow out of driver side vents?

2004 silverado – hot air blows out of driver side vents, pass side stays cold. Restart the truck, it returns to normal. Click to expand… Give this a try before you starting taking the dash out and buying parts. Same thing has happened to me a few times in the past. Usually just the passengers side.

Where is the HVAC controller on a Chevy Silverado?

Remove the panel under the driver side’s dash board (For passenger actuator remove the panel under the glove box). The actuators are mounted near the HVAC controller. Pry off the electrical harness plugged into the actuator. Unscrew the mounting screws and remove the actuator. Install your new actuator and tighten it down with the mounting screws.

Why is the AC blowing hot air in my Silverado?

After starting the truck the AC works normally for awhile then the driver side starts blowing hot air. Sometimes it changes to hot in a few m … read more 04 chevy 2wd silverado 1500, yesterday the AC quit blowing cold air out the driver side vents but continued blowing cold out the passenger side vents.

Where is the AC on a 2004 Silverado?

2004 Silverado AC blows hot on passenger side and regular on driver side. I just changed the battery, started the truck 2004 Silverado AC blows hot on passenger side..driver side… The drivers side of the air blows hot and the passenger side cold when the ac is on.

What kind of AC does a Silverado 1500 have?

2004 Silverado 1500 crew cab with dual climate control. AC on max high, blows cold out of driver side, but only hot air on passenger side. Yesterday … read more Vocational, Technical or Tra… Hi, I had a dead battery on my Silverado 1500 LTZ today. After I charged the battery it started OK but now the AC is just blowing hot air.

Where does the hot air come from on a Silverado Sierra?

I really don’t care about having air I just don’t enjoy burning up so summer because I can’t stop the scorching hot air coming out into the drivers side while the passenger side gets full AC Passenger side under the hood is the 2 hoses running back to firewall.

Why are the vents not working on my Chevy Silverado?

Check the blend door actuator. If the blend doors aren’t the issue, proceed to Step 2. There may be no refrigerant in the system. When there is a lack of cold air coming from the vents, most will agree that there is a leak in the system.

The only thing that the air conditioning system has in common with the heater is that they both use the climate controls and the blower motor. It is entirely possible for your Silverado’s heater to work just fine even when the air conditioner is not blowing cold at all.

How much does a Chevy Silverado heater cost?

One or more heater & AC (HVAC) air delivery and/or temperature mode door actuator may fail. This can result in incorrect air delivery or temperature. If this occurs, fault code (s) stored in the HVAC control module should be available to assist with diagnoses. The average cost for a Chevrolet Silverado 1500 AC Diagnosis is between $53 -$67.

Why does my Chevy Silverado blow hot air on one side?