Where is the thermostat located on a Dodge Ram?

On the Hemi, the thermostat is located on the engine at the upper radiator hose below the A/C compressor. The 4/7 and 3.7 engine’s thermostat is located on the lower radiator hose near the harmonic balancer.

How does a thermostat work on an engine?

An engine does not run optimally unless it is at a particular, regulated temperature. And a thermostat is a type of valve that is designed to open when the engine reaches a particular temperature. When that temperature is reached, the thermostat valve opens and the water circulates through the engine cooling it and regulating it.

How do you remove the radiator cap on a Dodge Ram?

Remove the radiator cap by pushing it down, and then twisting it counterclockwise. At the driver’s side bottom corner of the radiator is a drain blocked by a plug. Turn this plug counterclockwise with a 3/4″ wrench after you place a drain pan beneath it.

What kind of coolant do I need for my thermostat?

The red arrow points to the slot in the hose filler neck that fits to the thermostat O-ring. You will need about three gallons of 50/50 mixed coolant to fill the cooling system. For trucks using HOAT coolant, be sure to use the same type.

What is the repair manual for a Dodge Dakota?

Complete list of Dodge Dakota auto service repair manuals: DODGE SPRINTER / MERCEDES BENZ TRANSPORTER / FREIGHTLINER SPRINTER MODEL YEAR 1995 1996 1997 1998 1999 2000 2001 2002 2003 2004 2005 2006 SERVICE REPAIR WORKSHOP MANUAL (PDF) 1995 DODGE DAKOTA SERVICE REPAIR MANUAL DOWNLOAD!!!

Where can I buy a 2003 Dodge Dakota?

2003 Dakota listings within 50 miles of your ZIP code. Get answers to buy with confidence. Save when you purchase multiple reports. Select from one or more dropdowns below, to find the right car for you.

Where is the coolant sensor on a Dodge Ram?

The sensor (s) thread into the in intake manifold on either side of the thermostat housing, behind the alternator. You will need to remove the intake piping to find them. Unscrew the air cleaner cover bolt, and un-clip the airbox to set it aside.

What causes a Dodge Ram engine to overheat?

The thermostat blocks the coolant from flowing into the radiator as the engine is warming. A fault with the thermostat can cause reduced engine performance and overheating, typically seen on the instrument gauge panel. This article applies to the Dodge Ram 3rd Generation (2002-2008).

What happens when the thermostat on a truck goes bad?

Your truck’s thermostat regulates engine temperature. When it goes bad, coolant doesn’t properly circulate through your engine block. This leads to boiling and gurgling sounds, the engine running hot and, ultimately, the engine overheating.

What does the coolant temp sensor do on a Dodge Ram?

The coolant temp sensor (s) have a few jobs. They send a signal to the gauges so you can monitor engine temperature, they tell the radiator fans when to kick on or off, and they let the ECU know how warm the engine is so that it can fine-tune the fuel delivery to give you maximum performance as well as fuel efficiency.

What should the thermostat be on a Dodge Ram?

Changed thermostat back to factory 195F since some moron before me had a 180F piece in it.

Why do I need a higher thermostat for my Chrysler 318?

Once the thermostat opens it’s up to the rest of the cooling system to keep the coolant temperature under contol. Also, with a higher temp thermostat, the engine comes up to operating temperature faster. And that saves fuel. jesmed1 July 6, 2016, 2:35am #3 Thanks, Tester. You the best! mark9207 July 6, 2016, 2:35am #4

Where are the sensors on a Dodge Ram?

On trucks with two sensors, the one on the left of the thermostat housing is the sending unit for the gauge, and the one behind and to the right sends signal to the ECU. Depending on the problem you are having, you will likely just change one or the other. Figure 1.

How do you replace the thermostat on a Dodge Ram?

The thermostat housing needs to be cleaned up before you can reattach. Use a razor blade or a plastic putty knife and a rag to scrape off the old gasket and wipe it clean with a rag. Place a new gasket onto the housing. You may or may not wish to add some RTV sealant to the housing surface first; that is completely optional.

What does the thermostat on a car do?

A car thermostat regulates the flow of coolant through the engine and is an incredibly important player in the operation of your vehicle’s engine. You may hear the phrase “the thermostat was stuck open or closed.” When the engine has been sitting for a while and is not warm, the thermostat will be closed.

Why does my car thermostat keep leaking coolant?

Coolant Leaks Around Thermostat Housing or Under Vehicle A car thermostat regulates the flow of coolant through the engine and is an incredibly important player in the operation of your vehicle’s engine. You may hear the phrase “the thermostat was stuck open or closed.”

What happens to the thermostat when the engine is not running?

When the engine has been sitting for a while and is not warm, the thermostat will be closed. Once the engine is running and reaches a certain operating temperature, a sensor inside the thermostat will cause it to open, allowing coolant to flow to and from the radiator, decreasing the temperature so it can be…

What are the symptoms of a bad thermostat?

Here are the most common signs of a bad thermostat. The most common symptom of a bad thermostat is overheating. The thermostat doesn’t open up. This keeps the coolant from entering the engine. When this happens, the coolant in the radiator stays relatively cool, and the engine overheats fast.

What happens when the thermostat on a Dodge Ram goes bad?

This article applies to the Dodge Ram (1994-2001). When your thermostat starts going bad, you are putting your engine at risk. Your thermostat sends a lot of information to the computer which takes that information to make decisions affecting the fan, water pump, and fuel and air mix among other things.

Where does the thermostat housing meet the radiator?

The thermostat housing is right where the radiator hose meets the engine housing. It looks like half of a metal baseball. When the thermostat becomes stuck, it is reasonable to simply replace it. Also, when the thermostat housing is removed, the housing gasket should be replaced even if you’re just checking it.

What to do when your engine thermostat is stuck?

When an engine is cold, the thermostat should be closed, thus bypassing the radiator. Warm (not hot!) engine test: Open hood and remove radiator cap. Start engine. Observe coolant action. It should be swirling vigorously. When an engine is warm, the thermostat is in the open position.

Is the Dodge Ram 1500 running hot or overheating?

Everyone has a theory, and most of them are correct in some situations. That’s whey we get so many questions! This one came in from the owner of a Dodge Ram 1500 in North Carolina and typifies the running hot or overheating problem and how hard to mail down it can be.

What is the cooling system on a Dodge Ram?

This article applies to the Dodge Ram 2nd and 3rd Generation (1994-2008). Your vehicle’s cooling system comprises of various hoses, a belt, a thermostat, a pressurized radiator cap, among other components.

Can a thermostat be installed in the wrong direction?

Answer: A thermostat installed backward will cause the engine to overheat quickly, similar to a thermostat being “stuck closed.” Therefore, always double check that the thermostat is installed in the correct direction, and if equipped with a jiggle valve you install it according to the Factory Service Manual.

Where can I buy a 2001 Dodge Ram?

We have a huge selection of 2001 Dodge RAM Pickup PCMs. Visit fs1inc.com and order yours NOW!

Where is the coolant temp sensor located on the 5.7 Hemi?

Where is the coolant temp sensor located on the 5.7 hemi located in a2008 2500 ram Where is the coolant temp sensor located on the 5.7 hemi located in a2008 2500 ram – Answered by a verified Dodge Mechanic We use cookies to give you the best possible experience on our website.

What happens when you change the thermostat on a Dodge Hemi?

The thermostat in the “Hemi” regulates the engine temperature and opens to release coolant in to the engine. Once the engine cools down, the thermostat will close. A faulty thermostat will prevent the engine from receiving the coolant. This can cause the engine to overheat. Replacing the thermostat can be done in a matter of minutes.

Where is the coolant temp sensor located on a Dodge Ram 1500?

8,424 satisfied customers Where is the coolant temp sensor located on a 2004 ram 1500 Where is the coolant temp sensor located on a 2004 ram 1500 5.7 hemi … read more Mike V. technician Subaru and Nissan factory training. 32,825 satisfied customers My 2005 dodge ram 1500 wants to die while idling sometimes.

What should I replace my Dodge 5.7 Hemi thermostat with?

Please try again later. The 5.7 Hemi is one of the easiest thermostat replacements ever. 13mm socket and a flat head screw driver is all that is needed. Dont forget to subscribe to my channel I’m always adding more funny, spooky or How To videos. https://www.youtube.com/subscription_… https://www.instagram.com/cody_the_ca… Loading…

Where is the heater on a Dodge Ram 1500?

It’s very possible its actually the heating element under the passenger side dash. Look under the dash you will you will see a plug with the pigtail piece of the harness. Unplug the clip and remove the 2 screws and that will release the element . It looks like a pumice stone with the leads connected to it.

What are the problems with a 2002 Dodge Ram 1500?

Lighting issues are common in Dodge Ram trucks and are one of the most frequently-cited 2002 Dodge Ram 1500 electrical problems specifically. Owners find that their headlights, taillights or turn signals suddenly stop working, causing irritation at best and a safety hazard at worst.

Can a water pump on a Dodge Ram overheat?

If it seizes, your engine will overheat very rapidly. Also, seals inside of the pump can deteriorate and result in a loss of coolant. This article applies to the Dodge Ram 3rd Generation (2002-2008). The water pump is driven by the accessory belt on the Dodge Ram 5.7, 4.7, and 3.7 engines.

Where is the coolant tank on a Dodge Ram?

The washer fluid reservoir sensor connectors and hose on the 3.7 and 4.7 engines. The 5.7 engine coolant recovery tank is located above the radiator. There are two bolts at each side of the tank. Slide any hoses connected to the tank off and be careful as you lift the tank out of the engine bay, or coolant may spill.

Can a Dodge Ram run cooler in the winter?

First off the engine does run cooler….also no problems with heat in winter either… cooling running engine is also better…all newer cars try to meet govt mandates…as most didn’t buy these trucks for the mpgs….also many including myself rip off the clutch fans and install the v6 electric fans…

What kind of temp does Dodge Ram run at?

Dead stock with 110,000 miles (have owned 1-year/25,000 miles) and a muffler MORE restrictive than stock. 87-octane, meets EPA mpg figures. Never pings, loaded or empty, highway or city . . . and no death flash.

How to replace the thermostat on a Dodge Caravan?

(Playback ID: nKWYh85YUg-PlTLt) An error occurred while retrieving sharing information. Please try again later.

What’s the rating of a 2004 Dodge Ram?

2004 Dodge Ram 1500 Review. Dodge’s Ram is available in 1500, 2500 and 3500 versions, which translates to half-ton, three-quarter-ton and one-ton ratings, respectively. While the 2500 and 3500 models are designed for serious work, an offshoot of the 1500 — the high-performance Ram SRT-10 — is designed for serious play.

Can a faulty thermostat cause a Dodge Ram to over heat?

A fault with the thermostat can cause reduced engine performance and overheating, typically seen on the instrument gauge panel. This article applies to the Dodge Ram 3rd Generation (2002-2008).

What happens when you Jiggle the thermostat on a Toyota?

The jiggle valve positioning can also affect the entire cooling system on some cars and cause as much as an 8-10 degree Celsius change in the temperature. That may not sound like a lot, but on a hot engine that is a big difference. Toyota 3.4l FSM specifications. Thermostat jiggle valve down!

What happens if the thermostat is installed backwards?

Where is the oil pan located on a Dodge 1500?

I have unbolted the oil pan on my 2002 dodge ram 1500 4.7 engine but the oil pan still will not drop are there bolts holding the tube and screen on the outside and where are they located…

Where is the thermostat located on a radiator?

Ok. The Thermostat is located inside the Thermostat Housing. If you follow the Radiator Hose up to the side of the Engine, it connects to the side of the Housing. You have to drain the Coolant, remove the Drive Belts, then remove the Hoses from the side of the Housing to get the Thermostat out.

How can I get the thermostat out of my car?

The thick black hose runs from the side of your radiator and attaches to the top or side of your engine block with a tube clamp. Use a screwdriver to loosen the nut on the tube clamp and then pull the hose off of the engine. Set the end of the hose aside for now so you can access the thermostat housing on your engine.

What happens if your car thermostat is stuck closed?

Learn more… Your vehicle’s thermostat opens to allow coolant to flow through the radiator and cool the engine down. However, if the thermostat gets stuck in the closed position, the coolant can’t flow through the radiator and can make your engine overheat.

Why do I need to change coolant in my Dodge Ram?

Changing the coolant in your Dodge Ram is an easy maintenance task that can keep your engine in top operating condition. Coolant, also known as antifreeze, is designed to keep the water in your radiator from freezing during cold weather and boiling during hot weather.

What should the temp be on a Dodge Ram?

The truck used to average 13l/100 and for the past year it seems to be around 15l/100. I doubt this new thermostat issue will fix it but any possibilities I can cross off the list. Wild one likes this. The actual opening temp of the thermostat could vary 3-5 degrees from the actual listed temp.

Why is the coolant leaking on my Dodge Ram 1500?

Coolant Leaks Multiple coolant leaks are one of the more common 2015 RAM 1500 problems, as well as affecting model years 2009-2014. Many owners report that the leaking is strange because it’s difficult to locate even with a pressure test and that the leak only occurs when the engine is cold.

What causes a 2004 Dodge Ram 1500 to stall?

Some 2004 Dodge Ram 1500s stall when braking and at idle, as well. The most common report is that on a cold start, the truck won’t move when put in gear. The transmission may also slip or refuse to shift at all, which is one of the main 2006 Dodge Ram 1500 transmission shifting problems.

How to replace Dodge Caravan 3.3L V6 thermostat?

If playback doesn’t begin shortly, try restarting your device. Videos you watch may be added to the TV’s watch history and influence TV recommendations. To avoid this, cancel and sign in to YouTube on your computer. An error occurred. Please try again later. (Playback ID: nKWYh85YUg-PlTLt) An error occurred while retrieving sharing information.

Where can I get a new thermostat for my Dodge Ram?

Use Code: DIYSAVE10 Online Ship-to-Home Orders Only Strong yet refined, your Ram stands tall among full-size pick-ups. Don’t let a busted thermostat take your truck out of the game. If your vehicle’s engine is overheating, consider heading over to AutoZone to pick up a thermostat replacement for your Dodge Ram.

Where is the thermostat housing on a Dodge Hemi?

Locate the thermostat housing at the end of the top radiator hose. Use a socket wrench to loosen the two bolts at the thermostat housing. Place a sealable bag under the bottom of the housing to collect the coolant as it pours out of the opening.

Do you need to change the thermostat on a Dodge Durango?

If your Dodge Durango has an overheating problem, you may need to replace the thermostat. For Durango owners, this process is a bit involved, but once you remove all you need to remove to get to the thermostat, you’ll need to decide if you want to stick with the factory-set 192-degree thermostat or install a lower-temperature one.

Where is the radiator hose on a Dodge Durango?

Leave all wiring attached except for 4-wheel drive indicator lamp wiring at the rear of the generator. Follow the top radiator hose to the intake manifold if the engine of your Dodge Durango is 5.7 or 5.9 liter, and the bottom hose if the engine is 3.7 or 4.7 liter.

Why is my Dodge Ram 3500 engine not working?

Often, the cause is ventilation issues in the PCV or crankcase. Bear in mind that regardless of the weight of your oil, this issue can present itself. To replace ball joints of dodge ram 2500 & 3500 check out the list of top-rated products. 02. Engine Failure

What are common reasons my Dodge Dakota overheats?

What are common reasons my Dodge Dakota overheats? While there are a variety of reasons your Dodge Dakota is overheating, the most common 3 are a coolant leak (water pump, radiator, hose etc.), the radiator fan, or a failed thermostat. See what others are asking about their Dodge Dakota.

Can a bad thermostat cause an engine to run?

The bad thermostat can cause two different sets of problems, depending on whether it’s stuck open or stuck closed. A thermostat that is stuck open can cause the engine to run c… Read More The two most common signs of a bad pump are leaks and noises.

What should the thermostat be on a Dodge Dakota?

The thermostat has been replaced 3 times and is 195 degrees. I have tested these in boiling water with 2 thermometers in the pot and they open at around 205 which is okay. Why in the world it will not open while in my truck while driving on the interstate is beyond me.

Why is the radiator on my Dodge Dakota overheating?

The overflow was still at capacity. It appeared that the anti-freeze was going out the overflow tube and maybe splashing onto the engine. What would cause it to heat up like this. Could it be a bad radiator cap or what. My 4.7 liter Dakota 4×4 just started overheating yesterday. I replaced the thermostat and that seemed to cure the problem.

Is there a problem with my Dodge Dakota?

I have a 2004 Dodge Dakota Pickup and the temp gauge is running high but not overheating. My electrical cooling fan is not coming on – relay is okay, fuse is okay, and the fan is okay. The thermostat seems ok too. Any ideas what may be wrong? Is there another thermostat I should be looking at?

Why does my Dakota 4×4 heat up so fast?

It appeared that the anti-freeze was going out the overflow tube and maybe splashing onto the engine. What would cause it to heat up like this. Could it be a bad radiator cap or what. My 4.7 liter Dakota 4×4 just started overheating yesterday. I replaced the thermostat and that seemed to cure the problem.

What should the thermostat be on a Chevy Silverado?

Figure 1. Chevy Silverado thermostat and housing. Thermostats have a rated temperature listed on them. Most commonly, thermostats are rated at 180, 190, and 200 degrees Fahrenheit, which fully open about 20 degrees after its temperature rating. Common problems associated with thermostats is engine overheating or an engine that runs too cold.

What should the temperature be on my thermostat?

Thermostats have a rated temperature listed on them. Most commonly, thermostats are rated at 180, 190, and 200 degrees Fahrenheit, which fully open about 20 degrees after its temperature rating. Common problems associated with thermostats is engine overheating or an engine that runs too cold.

Can a stuck thermostat cause an engine to overheat?

Common problems associated with thermostats is engine overheating or an engine that runs too cold. A stuck thermostat that remains open will continuously circulate coolant and not allow the engine to heat to optimal running temperatures.

Where is the generator located in a Dodge Durango?

Take out mounting bolts for generator. Leave all wiring attached except for 4-wheel drive indicator lamp wiring at the rear of the generator. Follow the top radiator hose to the intake manifold if the engine of your Dodge Durango is 5.7 or 5.9 liter, and the bottom hose if the engine is 3.7 or 4.7 liter.

Is the thermostat on a 6.7 Cummins truck the same?

While other models may be slightly different the thermostat location should be the same on all Cummins 6.7 engines. If your truck is not warming up or sometimes even having overheating issues, you might want to check the themostat. I cannot say if this is the factory approved procedure as I just figured it out as I went along.

Where is the thermostat located on a Dodge Ram?