What should the transmission temp be in a Duramax?

If you own a 2001-2004.5 LB7 Duramax your normal operating temperatures will run around 160-180 degrees. These transmissions will warm up when towing or driving in the summer months. 200-225 is very common when the ambient air temp is 80-100 degrees and your transmission is under an increased load.

Which is the best Duramax 6.6L turbo diesel?

Perhaps the shortest lived of the 6.6’s, the LBZ Duramax is one of the most desirable amongst diesel enthusiasts today. The LBZ has the best performance and horsepower potential with bolt-on mods and was paired with a stronger Allison transmission than found in the LLY Duramax.

What kind of transmission does a Duramax diesel use?

It was the first to come bolted to the six-speed Allison transmission which provides a lower cruising RPM and greater fuel efficiency when compared to the five-speed on the LB7 and LLY.

What should the temperature be in a Duramax LB7?

If you own a 2001-2004 LB7: Duramax your normal operating temperatures will run around 160-180 degrees. These transmissions will warm up when towing or driving in the summer months.

What should the temperature be on a Duramax LB7?

I’ve got a new to me LB7 and I think that the temperature is a little low. On all of my other vehicles (mostly GM), operating temp is 210, however I cant get the Duramax above 170 (according to the gauge it is 180). I took the reading via my OBDII reader, it is 170-172F.

What kind of transmission does the Duramax LB7 have?

The LB7 was available mated to the Allison 1000 five speed automatic transmission or the ZF 6 speed manual transmission, with the automatic being a much more common choice. The LB7 was produced through the 2004 model year, when the LLY was introduced in its place.

What should the transmission temp be in the summer?

These transmissions will run from 200-230 in the summer months when towing in hilly areas. These temps are normal and will not hurt the transmission. If you are seeing temps above 235 degrees on a regular basis you should check your fluid level.

What to do if your Duramax transmission stops working?

If playback doesn’t begin shortly, try restarting your device. Videos you watch may be added to the TV’s watch history and influence TV recommendations. To avoid this, cancel and sign in to YouTube on your computer. I am Corey, I film car videos and content for YouTube.

What kind of transmission does a Duramax pickup have?

Nearly all Duramax powered pickup trucks were equipped with the Allison 1000 automatic transmission, with the five-speed version running from 2001 to 2005, and the six-speed starting in 2006 and running until 2019.

Are there any problems with the Duramax diesel engine?

Overheating issues with the Duramax diesel seems to be a hit-or-miss problem; some owners experience it, while others never will. Regardless, it’s more common with the Duramax than other engines.

What happens when a Duramax engine goes down?

Not only does this mean game-over for the engine, but it results in a truck that’s down for weeks (if not months) and a huge chunk of change missing from your wallet. The failure is most common in higher horsepower engines, but can still occur in moderately modified and even stock power plants.

Why is my Chevy Silverado having transmission problems?

When a torque converters wears, its vanes start to bend, which means that it cannot accurately control the movement of fluid inside the bell housing, causing erratic performance.

When was the Duramax LBZ engine phased out?

When you couple the performance potential with the reliability, and lack of emissions regulating systems, it’s no wonder the LBZ is still the fan favorite over 13 years since its discontinuation. The engine was phased out in 2007 solely for the purpose of emissions regulations.

What should the temp of an Allison Transmission be?

How hot should your Allison transmission run? If you own a 2001-2004.5 LB7 Duramax your normal operating temperatures will run around 160-180 degrees. These transmissions will warm up when towing or driving in the summer months. 200-225 is very common when the ambient air temp is 80-100 degrees and your transmission is under an increased load.

It was the first to come bolted to the six-speed Allison transmission which provides a lower cruising RPM and greater fuel efficiency when compared to the five-speed on the LB7 and LLY.

What causes a Duramax diesel engine to heat up?

When the engine is working hard, the turbocharger is drawing in a ton of air, and the restrictive stock turbo inlet tube can effectively choke the VGT turbocharger causing the compressor outlet temperature to skyrocket, heating up the intercooler, and ultimately raising the temperature of combustion and the coolant temp.

Why is the odometer on my GM Truck not working?

A common fault on ’99 – ’02 GM trucks was the permanent or intermittent failing of the odometer/gear select LCD. This meant that you were unable to see what gear you were currently in, unable to determine the mileage of the vehicle, and unable to use the trip computer.

What causes a bad gas gauge on a Chevy truck?

A poor ground or loose connection to a gas gauge is just as likely to cause problems as loose or dirty battery cables assuredly will with your starting system.

Can a child sit in the back of a GMC Canyon?

Child safety restraints and car seats don’t always fit properly in the back seats of small extended-cab pickups, but a clever design engineered for the GMC Canyon may give families some newfound flexibility. Without a strong, durable pickup bed, a pickup truck is essentially nothing.

Why is the temperature gauge on my Chevy truck not working?

All I have the same issue, I own a 1996 chevy pickup c1500, before I replaced the temperature gauge sensor, the gage read two lines below 210, after I replace the temp gradually climbs but the engine not as hot as where the gage reads, need advice stephan is on point for the diagnostic procedure. First.it’s not a thermostat issue.

Where is the temp sensor on a GM Truck?

Replace the “temp switch”. It’s on the right side of the block, in between the exhaust headers, it’ll have a single green wire going to it from past the alternator. They cost like $20, and it’s an easy replacement. Be sure to get the “temp SWITCH” and NOT the “temp SENSOR”.

Is there a temp sensor for the gauge?

There are two different temp sensors for your vehicle. One for the computer and one for the gauge. If you unplug the one for the computer, the computer may think the engine is cold. and the RPM’s will increase. I think you need to find the coolant temp sensor for the gauge.

What was the code name for the Duramax in 2011?

In an effort to keep up with the ever-tightening emission regulations, GM redesigned its Duramax for the 2011 model year, and this time the code name was LML.

What causes an engine to surge at idle?

A surge is usually caused by a fuel system management or drivetrain operation failure. When an engine’s computer can “hunt” or “surge” at cruising or idle speeds it is searching for program compliance, there is a problem elsewhere in the system. SPONSORED LINKS. Article published 2017-01-26.

What causes the injector on a Duramax to fail?

The two primary failure points of the factory injectors are internal cracking of the injector body itself and corrosion-induced failure of the internal ball seat. The solenoid style Bosch units found in the LB7 employed a non-hardened internal ball seat to seal the injector.

What should the operating temp be on a Duramax?

On all of my other vehicles (mostly GM), operating temp is 210, however I cant get the Duramax above 170 (according to the gauge it is 180). I took the reading via my OBDII reader, it is 170-172F.

How often does fuel pressure surge at idle?

Watching the fuel pressure at idle stays around 5200psi and when it surges up goes to around 9000psi. It’s up and down about every 15 seconds. And you can also feel it at a slow speed. Could someone lead the right direction, I do automechanic by trade I just don’t do a lot of diesel work.

How long does it take for a Chevy Duramax to warm up?

Mine now takes about 5 miles at highway speeds to come up to full temp. It still won’t warm up a whole lot just idling, but it is much better with the new thermostats and will now put out heat. I got my thermostats at the local parts store in a kit that had both thermostats and the rubber gaskets. Merchant also has them.

What should the running temp of a service truck be?

I have a 2003 2500HD Service truck on a 3500 chassis. 7800 lbs with tools. and it always read lower than 190 or under. New radiator, water pump and it reads 210 consistent running temp now. Something about it having a leak or pressure loss that causes it to read lower than it is?

What kind of transmission does a Chevy Silverado have?

Figure 1. GM’s 4L60-E automatic transmission, late model. Over the years, this transmission has seen numerous revisions, changes, and additions to internal components—such as valve bodies, solenoids, pump, and torque converter. In 1997, the “late” model of this transmission that included a removable bell housing was widely introduced.

When a torque converters wears, its vanes start to bend, which means that it cannot accurately control the movement of fluid inside the bell housing, causing erratic performance.

What kind of engine does a Chevy Silverado have?

All models are available in two- or four-wheel-drive. A 6.0-liter V-8 gas engine is standard on all models. The popular 6.6-liter Duramax diesel and six-speed Allison transmission are optional. GM says the 2500HD and 3500HD can tow up to 13,000 pounds with the diesel engine and a conventional hitch.

What kind of car is a 2009 Chevy Silverado?

Description: Used 2009 Chevrolet Silverado 2500HD LTZ with AWD/4WD, Tire Pressure Warning, Audio and cruise controls on steering wheel, Remote Start, Stability Control. This 2009 Chevrolet Silverado 2500HD is in great mechanical and physical condition.

What should the transmission temp be in a Duramax?