What makes a Duramax not start all of a sudden?

6.6 duramax wont start all of a sudden. Turns over great new fuel filter. A shot of either fires up and runs and pulls Chevrolet: 6.6 duramax wont start all of a sudden .

Why does my car not start when I jump start it?

If it does, the battery is undercharged and you were just seeing a surface charge that can’t supply starter current at the proper voltage. If the battery reads low and you can jump start (or pop start the car with a standard transmission), the problem is with the battery or the charging system.

Why does my GM car say no start no crank?

How to diagnose a no start no click on GM vehicle. If you have a late model GM vehicle and turn the key only to hear nothing, you’ll most likely think you have a dead battery—and you may. But a no start, no crank, no click condition can be far more involved than that.

What should I do if my car wont start?

When the security light goes off, turn the ignition off, wait 20 seconds, and then start the engine. These are the most popular ways to solve the problem of anti theft system car wont start.

6.6 duramax wont start all of a sudden. Turns over great new fuel filter. A shot of either fires up and runs and pulls Chevrolet: 6.6 duramax wont start all of a sudden .

Why does my 6.6L crank no start?

Possible someone shimmed the valve and lost parts– COMMON. Pull the “U” hose from the fuel rail– plug the hose. Connect a hose to the nipple on the fuel rail. Crank the engine— any fuel coming out of the fuel rail nipple — the FPRV is leaking fuel– IT WILL NEVER START.

What kind of truck has a 6.6 Duramax?

I have a 2009 chevy 2500HD with the 6.6 Duramax. I started the truck with my remote while I was opening my shed it ran for a couple of seconds … read more 2017 Duramax will not idle and I kill it and restart it might run normal or I might have to keep killing and restarting till it runs. Once it starts running it … read more

What’s the fuel pressure on a GMC Duramax?

The actual fuel pressure today is 4.2 mpa while cranking. I just ordered a fuel supply diagnostic hose to make sure the volume is coming up from the tank and without sucking in air. Yeah thats about 610 psi and you need about 1400-1500psi to start easy..

Can a Silverado HD 6.6 turn over but no start?

Once it starts running it … read more ASE Certified Master Techn… Turn over but no start. 2007 silverado hd 6.6. Checked turn over but no start JA: Will the headlights turn on? Is the battery fully charged? Customer: yes JA: What is the model/year of your Chevy? … read more

What’s the number on the glow plug on Duramax?

The only code showing up is a number three glow plug, but that code has shown up on and off for a while, and shouldn’t make it impossible to start. Clicking this will make more experts see the question and we will remind you when it gets answered.

What kind of car won’t turn over?

2007 chevrolet: with the 6.6 duramax..turn over but just wont fire. I have a 2007 chevrolet with the 6.6 duramax. I went out to start it this morning and it stared and ran for about 20seconds then died and … read more

Why is the fuel pump on my Duramax not working?

Change the fuel filter often, the Duramax fuel system is fed by suction from the fuel tank and the slightest filter plugging will starve and overwork the fuel pump. The newer 17 models finally use a fuel boost pump to correct the starve issue. I know I’m a little answering this, but thanks to all for the advise.

What to do if your Duramax crank wont start?

Buy a new filter head– little over $100, and comes with a new filter and WIF sensor. i replaced the fuel hose to/from the filter head with clear line from the hardware store and then pressurized the fuel tank to 15 psi with a compressor and found the system full of air from a leaking quick connect fitting on the fuel line near the fuel tank.

Why does my Duramax engine not turn on?

After I replaced the filter head, it hasn’t done it since. You have a leak somewhere, Fuel is running back to the tank when it’s not running causing you to lose prime. Usually removing and resealing the fuel filter housing/water separator will cure this issue.

Can a Duramax 6.6 start without a fuel pump?

My son has a 2011 duramax 6.6 that will not start on fuel but will start with a shot of either and runs like a top. He has replaced the fuel pump, … read more Vocational, Technical or Tra… Vocational, Technical or Tra… Vocational, Technical or Tra… I was low on fuel and drove to station to get more but never ran out.

Why does my 2005 Chevy 2500 HD not start?

My 2005 Chevy 2500 HD won’t start. Engine won’t turn over with key at all. Batteries are hot. You can take a power probe and shoot 12v to starter solenoid wire and it will crank and run fine. I traced that wire back to the fuse panel under the hood on the driver’s side. There is a CRANK fuse as well as a starter relay in that panel.

Why is the tow / haul button not working on my Duramax?

When you turn the key to start, the fuse gets 12v but the starter relay is not getting voltage to the solenoid wire. Also noticed that the tow/haul button isn’t working and it was before the issue. Any suggestions? swap the relay with another in the box and see if the relay is the problem. 5 people found this helpful.

What happens if the crankshaft on a Duramax goes bad?

Perhaps the most devastating of all Duramax failures is a broken factory crankshaft. Not only does this mean game-over for the engine, but it results in a truck that’s down for weeks (if not months) and a huge chunk of change missing from your wallet.

Are there any problems with the GM Duramax?

In stock form and even when substantially modified, GM’s legendary V8 diesel can provide hundreds of thousands of miles of trouble-free use. Still, and just as we exposed the shortcomings of the almighty Cummins, the Duramax isn’t without its flaws—some of them catastrophic.

How many versions of the Duramax diesel engine are there?

All told, there are six different iterations of the Duramax diesel engine: LB7, LLY, LBZ, LMM, LML, and L5P spanning from 2001 to the present day. Each version of the engine has its own issues and quirks, and some are less problematic than others.

What kind of maintenance does a Duramax do?

Heavy duty trucks, especially turbo-diesels, are costly to maintain. Yes, you can do most of the maintenance yourself: oil changes, fuel filter changes, air filter, tire rotations, etc. The Duramax V8 holds 10 quarts of oil. The extra oil and the fuel filter add cost to the equation.

What kind of engine does a GM Duramax have?

It’s been said before, but that doesn’t make it any less true: The 6.6L Duramax is one heck of an engine. In stock form and even when substantially modified, GM’s legendary V8 diesel can provide hundreds of thousands of miles of trouble-free use.

Why does my 2003 Chevy Silverado not start?

My 2003 Silverado has issues starting sometimes. If I hit the steering column it will sometimes start. My silverado has left me stranded numerous times with this intermittent starting bullsh!t. The truck starts majority of the time however sometimes I go to start the engine and nothing!!

Are there any issues with the Duramax fuel pump?

The new injectors available from us and others are updated and do not have the cracking issue. Fuel Filter Housing Oring Leaks – The Duramax fuel system does not have any sort of low pressure fuel pump pushing fuel to the engine from the tank. The injection pump sucks all the fuel from the tank.

What causes a fuel filter to leak on a Duramax?

Fuel Filter Housing Oring Leaks – The Duramax fuel system does not have any sort of low pressure fuel pump pushing fuel to the engine from the tank. The injection pump sucks all the fuel from the tank.

Why did my 2004 Duramax engine not start?

My 2004 Duramax started and then died like it was out of fuel. Now it won’t start. I have about 1/4 tank of fuel, tried priming it until the batteries died.

How to fix 2003 Duramax Diesel loosing Prime?

2003 Duramax Diesel loosing prime and will not start until I lift the hood and pump the prime plunger on the fuel filter housing. Clicking this will make more experts see the question and we will remind you when it gets answered. You can’t post conmments that contain an email address.

What kind of Chevy truck won’t start?

In this video we encounter a condition where a 2002 Chevy Silverado ( Similar to GMC Sierra ) pickup has a symptom of the engine cranks over but won’t start…. In this video we encounter a condition where a 2002 Chevy Silverado ( Similar to GMC Sierra ) pickup has a symptom of the engine cranks over but won’t start….

What kind of pump does a 2003 Duramax use?

You can’t post conmments that contain an email address. 2003 duramax, when clod it will start drive for 30min to hour and shut it off will not start untill it cooled off for about 2-3 hours at the shop they replaced the fule pump with 2006 modle for $150,the pump for the 2003 was $650 is this right,is this the same pump??

Why does my 2015 Duramax high country not start?

I have a 2015 2500 High Country with 45k Miles. I was in line at a drive through and the lady asked me to turn off my engine cause she couldn’t understand my order. I did and when i tried to start it back just turns over but wont start. Pushed it to a parking place and notice diesel coming from the fuel filter where the water seperator screws in.

What kind of engine cranks but won’t start?

Filled tank today, was 3/4 full. Drove home 5 miles. came out several hours later, engine cranks normally but won’t fire. Held throttle down and it started. Had slight surging. Very slight.

What causes a Duramax injection pump to fail?

As a result (allegedly), the lack of lubrication in the fuel can cause a premature failure of the injection pump, to a point where it won’t allow the LML Duramax to run. You can be driving down the road and everything seems normal, and when the pump fails, the truck just shuts off.

What causes a Duramax diesel engine to heat up?

When the engine is working hard, the turbocharger is drawing in a ton of air, and the restrictive stock turbo inlet tube can effectively choke the VGT turbocharger causing the compressor outlet temperature to skyrocket, heating up the intercooler, and ultimately raising the temperature of combustion and the coolant temp.

What kind of engine does a GMC Duramax have?

I have a 2021 GMC Sierra 1500 AT4 with the 3.0 Duramax that is 4 weeks old with 2500 miles. The following has happened three times. I press the brake, press the start button, the engine turns over for approximately 10 seconds without starting. Each of the three times it has started on the next attempt.

Why does my 04 LB7 engine not start?

Now engine wont start anymore. Went to start my 04 LB7 this morning to let it warm up before going to work. As I shut the door and walk away, the engine died. I tried to fire it back up but it just spins over and doesnt start. The truck has 144k, has about 3.5k on new injectors installed by dealer, fuel filter was replaced around the same time.

Why is my Duramax diesel engine not starting?

Fairly common issue when you overtighten the sensor while doing a filter change. The fuel leak you saw also allows it to suck air into the system, causing a loss of prime. It’s easier for the engine to suck air through the leak than to suck fuel from the tank. Make sure your fuel/air leak is fixed.

Why is my Chevy Silverado 2500 not starting?

While there are a variety of reasons your Chevrolet Silverado 2500 HD won’t start, the most common 3 are a dead battery, an alternator problem, or failed starter.

What to do if your 6.5 diesel won’t start?

To read more about 6.5 PMD failure and the recommended cure, our FSD heat sync kit, follow the links below: For those with more in-depth issues, proceed to follow through the no-start guide one step at a time.

Why does my car not start when I try to start it?

But if the battery doesn’t have enough juice to start the engine or repeatedly needs a jump start, the problem may originate elsewhere, and jumper cables or even a new battery won’t solve the problem. Here are eight possible reasons your car won’t start.

What does it mean when your RV won’t start?

The RV won’t start. There are none of the typical dead battery behaviors – no clicking, no lights flickering, nothing. All of my normal dash lights do not come on when I turn the key. Even the radio light is out. When I flip the chassis battery disconnect switch it springs back into the ON position and won’t stay off.

What should I do if my Mercedes Benz won’t start?

Start the car and you should be able to get around 60 psi. When the engine is running and when you turn off the engine the pressure should stay steady. Always perform this test on a cold engine. Next, make sure that the fuel injector connections are secure and not loose. Check the fuel pump and the fuel pump relay.

What to do if your fuel pump won’t start?

Use a circuit tester to check all the electrical connections to the fuel pump. Turn the key to ON. If you see a current, then it is not the pump. If there is no current, check the fuse.

What to do if your Toyota won’t start?

Battery – If the connections on your battery become corroded, there is no longer a connection to the rest of the car. This can keep you from starting. Clean the posts and try to start the car. Additionally, the battery may be dead. Take a battery tester and test the cranking amps to see if they are weak.

What causes a Harley Davidson not to start?

Some other ideas: 1 Problem with security module or key FOB 2 Problem with clutch safety switch, or its wiring (if bike has it) 3 Bad relay (like you said)

Are there any issues with the Duramax pickup?

This can produce long cranks and hard starts. Glow Plug System Issues – Nearly half of the check engine lights that come in for the Duramax pickups are for glow plugs. The glow plugs burn out over time and can be a real nuisance to remove from the aluminum heads sometimes.

Is the water pump on the LB7 Duramax leaking?

Water Pumps – Another issue with the LB7 Duramax is the water pump leaking. This one is fairly common and unfortunately a huge pain in the butt to change. Water will seep from the underside of the pump. Be prepared though because you will have to remove the dampner pulley to get the pump off.

Are there any problems with the LLY Duramax?

In terms of LLY injector problems, GM had sorted out the internal failures with the 2004 ½ redesign, but the LLY Duramax would occasionally exhibit a trouble code for the injectors, but in most cases it turned out to be an issue with the injector harness rubbing through and causing a short or open in the wiring.

Why does my 2004 Duramax truck not start?

CLICK HERE TO RESET YOUR PASSWORD! 2004 Duramax WONT START! I have a 2004 duramax that i reciently changed the fuel line that goes from my fuel sending unit to my steel feed line.. I also replaced my fuel filter housing because the truck was loosing prime..

What are the old codes for Duramax truck stop?

I cleared the codes… when i tired to rescan for new codes none showed up so im not sure if the old codes were an indication or not…

What are the codes for my Duramax injection pump?

It actually is throwing a few codes now I’m not sure if some are old and unrelated but here are the codes: P0089 P0101 P0621 P0700 P1093 U1800 U2104 U2106 U2105. It seems potentially to be my injection pump. What do you guys figure? Click to expand… I would clear all the codes first. This way you can focus on what is newly set.

What causes a riding lawn mower to not start?

7 Simple Reasons Your Mower Won’t Start 1) Out of Gas 2) Stale Gas Leads to Clogged Carburetor 3) Clogged Fuel Filter 4) Dead battery 5) Bad Starter Solenoid 6) Disconnected or Dirty Spark Plug 7) Dirty Air Filter

What happens to the head gasket on a Duramax?

Head Gaskets – As these truck reach the 100,000-150,000 miles we are seeing more and more head gasket issues. The Duramax has a multi-layer steel head gasket. When they have issues, they do not typically smoke out the exhaust or get coolant into the cylinders. What happens is the head lifts a little during the compression stroke.

What to do when your GMC Truck won’t start?

Try turning your key to the run position a few times (with out starting). Then try to start it. If it starts, sounds like what mine did. I replaced the fuel pump assembly and that fixed the problems. Very common problem.

Are there any problems with the Duramax diesel engine?

Overheating issues with the Duramax diesel seems to be a hit-or-miss problem; some owners experience it, while others never will. Regardless, it’s more common with the Duramax than other engines.

Why does my GMC Sierra stall at 30 mph?

Never threw a service engine light or a code and would readily re start. 2 weeks ago it quit at 30 mph, wouldn’t restart and SES lit up. Code indicated crank positioning sensor. Had it replaced and so far so good. If yours behaves as mine did it could be a while before you get a traceable code. I own a 1998 GM Sierra 5.7L 2wd automatic.

Where is the crank fuse on a 2005 Chevy Duramax?

I traced that wire back to the fuse panel under the hood on the driver’s side. There is a CRANK fuse as well as a starter relay in that panel. When you turn the key to start, the fuse gets 12v but the starter relay is not getting voltage to the solenoid wire. Also noticed that the tow/haul button isn’t working and it was before the issue.

Is there a 6.6 Duramax that wont start?

Chevrolet: 6.6 duramax wont start all of a sudden . Turns… I have a 2009 chevy 2500HD with the 6.6 Duramax. I started I have a 2009 chevy 2500HD with the 6.6 Duramax. I started the truck with my remote while I was opening my shed it ran for a couple of seconds … read more

Why does my Chevy Duramax not crank up?

So after trouble shooting the ignition by sending power (12v) through the crank fuse and turning the key, found that all wiring is good. Would have to be one of the ignition fuses. Checked all fuses with test light and found 40amp ignition fuse to be bad. Replaced and attempted to start. All working as it should at this time.

Why does my Silverado 2500HD no start no crank?

If it helps, usually when this happens, the first time you try to start it, it will start for like a split second and stall out. From there on it just makes a soft clicking at the relays and won’t crank. I usually do not do a lot of repairs to my truck myself.

Can a Duramax diesel engine be kept warm?

Huge no-no for modern diesel engines as your grid heater in the intake and glowplugs stay on until the truck is “warm”. Also sometimes rebuilding the filter head isn’t enough, you have to replace it. Click to expand… Yeah I wasn’t to fond of spraying it.

How to stop a Duramax truck from losing Prime?

Tried running fuel line from injection pump to tank of diesel.. No go Pressurized the fuel tank primed it and tried starting.. Nothing Pressurized fuel tank sprayed soap water on lines.. No leaks found Tried having someone prime while I cranked. Truck will run off starting fluid through airbox but dies when you stop spraying.

Why is my Duramax not starting after fuel filter change?

Changed the fuel filter today, and cannot for the life of me get the system primed back up. I loosened the bleeder screw, and have been pumping for so long that there’s a blister on my hand.

What to do if your Duramax won’t start?

Re: Duramax won’t start! I had the same problem. The LLY is famous for developing a small crack in the fuel/water filter housing. Try priming the filter (loosen small nut, push down on primer until fuel seeps out of nut, retighten nut).

Why is the priming pump on my Duramax not working?

Priming Pump/Filter Housing. Truck won’t start: Chevy Duramax | Performance Boats Forum Priming Pump/Filter Housing. Truck won’t start: Chevy Duramax Did a search and still was not comfortable with the results if found. I was ready to leave for a trip a couple of days ago.

What should I do if my Duramax engine wont start?

With the engine OFF, loosen fuel filter assembly plastic bleed screw a turn or so, and depress the round priming pump on top of FF assembly until fuel squires out of vent. CAREFULLY close plastic vent nut with fingers or nutdriver. Depress pump until firm. Barely finger tight with nutdriver is all you need.

How can I Keep my Duramax Diesel pump healthy?

However, there are measures you can take to keep the pump happy and healthy, the first being to always buy your diesel from a high-traffic, reputable filling station that’s known to dispense good, clean fuel. Second, always change the fuel filter at or before the recommended service interval.

Are there any flaws in the Cummins Duramax?

Still, and just as we exposed the shortcomings of the almighty Cummins, the Duramax isn’t without its flaws—some of them catastrophic. For example, did you know the injection pump on the LML version is prone to coming apart and wrecking the entire high-pressure fuel system when it does?

Why does my GMC Duramax not start up?

Sat in drive way moved it around a couple of times and parked it in the garage to do tcase. Almost two months later I finally finished it and now it won’t start. Acts like it will, fires up then dies right aways like the fuel shut off.

Can a 6.6L Duramax crank no start?

Hi I could really use a tip if you could help. I am working on a 2006 6.6 duramax and can’t get it to run. Drove ina couple months ago but ran very poor like a missfire. then stopped running completly. Will start on starting fluid but then stalls when runs out of starting fluid.

Is there a crank fuse on a Duramax?

Batteries are hot. You can take a power probe and shoot 12v to starter solenoid wire and it will crank and run fine. I traced that wire back to the fuse panel under the hood on the driver’s side. There is a CRANK fuse as well as a starter relay in that panel.

Are there any problems with the Duramax water pump?

This seems to be inherent of the factory water pump design. Overheating issues with the Duramax diesel seems to be a hit-or-miss problem; some owners experience it, while others never will. Regardless, it’s more common with the Duramax than other engines.

Are there any problems with the Duramax fuel pump?

It can also be relatively difficult to prime the fuel system once air has been introduced into the system, such as when the fuel filter is changed. The 2001 to 2004 LB7 fuel filter housings seem to be the most prone to problems. Water pump failures for Duramax engine are somewhat common.

What causes fuel starvation in a Duramax Diesel?

Fuel Starvation and/or Air in the Fuel Lines. The Duramax diesel is susceptible to fuel starvation and getting air in the fuel lines. This can be contributed to the fuel filter housing design and the fact that the Duramax does not use a lift pump. Rather, the high pressure fuel pump (injection pump) is responsible for vacuuming fuel from the tank.

Why does my Chevy Duramax not turn over?

Engine won’t turn over with key at all. Batteries are hot. You can take a power probe and shoot 12v to starter solenoid wire and it will crank and run fine. I traced that wire back to the fuse panel under the hood on the driver’s side. There is a CRANK fuse as well as a starter relay in that panel.

What makes a Duramax not start all of a sudden?