Easy tips

How does the transfer case work on a Chevy Silverado?

How does the transfer case work on a Chevy Silverado?

By turning it to “4-Hi” (at less than 70 mph only) with the front axle actuator already engaged from the previous position (“Auto”), the transfer case is shifted by the transfer case shift motor from 2WD, past Neutral (as noted previously the transfer case has its own Neutral mode) to “4-Hi.”

Why does my Chevy Silverado have a 4WD warning light?

Lights up when you start your vehicle but then goes off by itself, then your Transfer Case Control Module (TCCM) is the suspect (a “Service 4WD” dashboard warning light may also come on). Switches into 4WD just fine but your vehicle isn’t actually sending power to the front wheels, then your front axle actuator is the suspect.

Where are the ground wires on a Chevy Silverado?

These ground wires are attached to the frame under the front of the driver’s door. Unbolt these wires, clean their contact area to bare metal as well as the bolt threads, and reattach the wires to the frame (a 5-minute job). Figure 2. Transfer case selector switch replacement. If the ground wires are okay, replace the transfer case selector switch.

What causes a 4WD transfer case to fail?

A failing 4wd transfer case position sensor selector switch is one of the most common reasons behind transfer case failure in four-wheel drives. A mechanic can diagnose the issue in several ways. One of the first things your mechanic will check is the switch’s voltage input and output.

Can a Silverado Sierra be put in neutral?

On my way to work this morning, however, the red neutral light came on and I couldn’t get it into any other setting, even after stopping/putting the truck in neutral/reverse/drive. I’ll see what happens this afternoon on my way home.

What to do about a bad transfer case on a Silverado 1500?

Selector switch in a Silverado 1500. A bad transfer case motor will often throw a code on your dash, but can also be diagnosed if you fail to hear the motor spinning once the 4WD gear is engaged. A new transfer case motor will cost you around $200.

How can I switch my truck from neutral to 4WD?

The one on the dash. try taking the tranfer case motor out cleaning the plugs and putting it back in also! Ok is it hard to take the transfer case motor out? When your truck does that, can you switch it out of neutral and/or auto?

How do you put a GM transfer case in neutral?

SOME KNOBS MAY LOOK DIFFERENT (TRAILBLAZER, ENVOY, etc..) BUT THE PROCEDURE IS THE SAME. First, make sure you are in 2 wheel drive position on the transfer case. Next, put your foot on the brake pedal and shift your transmission in Neutral. Rotate the dial all the way clockwise, PAST the 4LO position and HOLD IT THERE for approx. 10 seconds.

This article applies to the 4WD Chevrolet Silverado GMT800 (1999-2006). The transfer case in your Silverado defines its four-wheel-drive (4WD) system. To transfer power from the transmission to all four wheels, the chain-driven transfer case must rotate the propeller shafts that are connected to the front and rear axles.

What kind of transmission fluid does a GMC transfer case use?

The manual specifies GM Goodwrench Synthetic Manual Transmission Fluid, with a GM part number, for the manual transmission, but allows for 75W-90 GL-4 gear oil as an equivalent. So, I would not use it in a modern transfer case, more like the old cast iron ones.

What kind of transfer case do I need for my 1996 k1500?

From buying research to owner support, join 1.5 MILLION GM Truck Enthusiasts every month who use GM-Trucks.com as a daily part of their ownership experience. I’m pretty sure that I have the NP241 transfer case in my 1996 k1500 with the 4l60e and 350 vortec.

How does a chain drive transfer case work?

To transfer power from the transmission to all four wheels, the chain-driven transfer case must rotate the propeller shafts that are connected to the front and rear axles. In addition to driving the two axles separately, the transfer case allows the vehicle to lock the front and rear differentials.

What kind of transfer case do I need for a Tahoe?

(Electric Shift) Transfer Case will fit a Silverado Tahoe Sierra Yukon 1500 from 2003 2004 2005 2006 with a 4L60E or 4L65E transmission.Call with your VIN # or Model # (located on rear case half of transfer case) to insure we ship you the right transfer case for your vehicle. 27 spline Input Gear. (Electric Shift)

Which is GMC Yukon has a transfer case?

All Wheel Drive (AWD) transfer case for GMC Yukon, Denali, Sierra 2001-2005. Cadillac Escalade Ext. Esv. 2000-2002. Call with your VIN # or Model # (located on rear case half of transfer case) to insure we ship you the right transfer case for you vehicle. 27 spline Input Gear.

What kind of transfer case does a Chevy Silverado have?

Chevrolet Silverado- GMC Sierra 2500HD/3500HD with 6.6L duramax diesel with allison transmission. Also available are the 6.0L gasoline engine transfer cases with 6L90 transmission.

(Electric Shift) Transfer Case will fit a Silverado Tahoe Sierra Yukon 1500 from 2003 2004 2005 2006 with a 4L60E or 4L65E transmission.Call with your VIN # or Model # (located on rear case half of transfer case) to insure we ship you the right transfer case for your vehicle. 27 spline Input Gear. (Electric Shift)

All Wheel Drive (AWD) transfer case for GMC Yukon, Denali, Sierra 2001-2005. Cadillac Escalade Ext. Esv. 2000-2002. Call with your VIN # or Model # (located on rear case half of transfer case) to insure we ship you the right transfer case for you vehicle. 27 spline Input Gear.

Where to buy Chevy np246 transfer case rebuild kit?

Choose items to buy together. Only 20 left in stock – order soon. Ships from and sold by AutoMaxx. Only 18 left in stock – order soon. In Stock. FREE Shipping on orders over $25.00. . .

This article applies to the Chevrolet Silverado 1500 (2007-2013). The transfer case controls whether you are in four-wheel drive or in two-wheel drive, so it’s important to make sure it’s maintained properly. The transfer case functions by taking the output from the transmission and splitting that power into two driveshafts.

Are there any GMC trucks with a transfer case?

GEO Sidekick and tracker, plus General Motors GMC divisions Envoy, Jimmy S15, Sierra K series 1500, 2500, 3500, Safari, Savana, Sonoma, Syclone, Typhoon V Series, Yukon and Denali. Removing and replacing a transfer case with our remanufactured unit is much easier then overhauling the transfer case.

Where can I buy a 2004 Chevy Silverado case?

Buy 2004 Chevrolet Silverado 1500 Transfer Case from AutoZone. 10% OFF $75. Use Code: DIYSAVE10 Online Ship-to-Home Orders Only

How to replace the 4WD tranfer on a Chevy Silverado?

Pull tab of the connector to release it. Figure 5. Separated routing clip of the second wire harness (red arrow). Remove three 15mm bolts from the shift motor, and pull it off of the transfer case. Save the gasket between the shift motor and transfer case as it will be reused. Take care not to damage it.

Is there a warranty on a GMC transfer case?

Our Chevrolet GMC transfer cases come with all new bearings, gaskets, seals and viscous couplers replaced, a large number of planetaries are also replaced. Detailed inspection procedures and each unit is factory pressure tested and comes with a no hassle warranty.

Author Image
Ruth Doyle