Are there any problems with Ford Transit injectors?

The engines are also fitted in various Ford cars (Focus, Mondeo, S-Max, Galaxy and Edge), but far less prolifically. Across Europe a total of around 90,000 vehicles are involved. The faulty batch of injectors was installed between 25 February 2019 and 13 September 2019.

What happens if the fuel injector is not working?

Fuel injectors are a vital part of a complex fuel management system. Furthermore, New technology has made fuel injectors more precise than ever in dispensing fuel. If the fuel injectors are not operating properly, then other parts of the engine will be affected as well.

What’s the issue with the Ford EcoBlue injector?

What’s causing the Ford EcoBlue injector issue? Ford says the issue has been caused by quality problems with a third party supplier, which provides the injectors fitted in the Transit, Transit Custom and Ranger EcoBlue models.

What is the problem with Mondeo 2 LTR TDCi injector?

The problem is in the diesel pump which has a manufacturing defect. the cams and rollers are case hardened but a number of pumps have a problem whereby the case hardening fractures and contaminates the whole fuel system with small chards of hardened steel. Total replacement of fuel system and flushing of tank is the only cure.

What should I do if my Ford fuel injector fails?

Fuel Injector Inspection – You can take the injectors out of your Ford and inspect them for damage, dirt or rust. You can start by removing the fuel rails and detaching each injector from the rail. When you remove the injector, there will be fuel that spills out of the rail, so make sure you do not get it on you or the ground.

Can a Ford 6.0L diesel injector be replaced?

For extreme cases like this and cases when your Ford van or truck has high mileage or sees heavy use, we recommend purchasing a complete set of rebuilt replacement 6.0L Powerstroke diesel injectors or upgrade to our high-quality Bosch remanufactured replacement Powerstoke injectors.

What causes a fuel injector to leak over the engine?

So, the most common cause of leaky injectors is; the failure of the O-ring, where the injector meets the fuel rail. The O-ring can become, hard and brittle, from the heat of the engine. If it breaks, then fuel can leak out, over the engine. The other way an injector will leak is if, the injector body or nozzle cracks.

How to remove fuel pump from Ford Transit?

11 You should now be able to put a second timing pin into the fuel pump timing locating hole. 12 Remove the 3 Torx screws holding the diesel pump to the engine (T45) Timing kit part

What kind of camshaft does Ford Transit 2.0 have?

The Ford EcoBlue 2.0 TDCi engine as fitted in the Ford Transit/Ford Transit Custom has a belt driven, double overhead camshaft design. The valves are operated via rocker arms from the camshaft, with hydraulic lash adjusters.

Why are Ford Transit EcoBlue injectors self learning?

The Ford Transit EcoBlue injector calibration is self learning, but resetting the saved values will enable the ECU to adapt to the current injectors and any changes in the fuel system much more quickly, helping prolong the life of the engine and preventing any possible associated damage which may cause a problem which would require repair again.

Is the injection pump on a Ford Transit aspirated?

I’ve been roped into a job tomorrow to time up a V Reg 2.5 Ford transit engine (normally aspirated), basically the owner had to change the injection pump, lost all the timing and now I have to pick up the pieces. I’m fairly genn’d up but need to clarify a few points… 1.

What’s the problem with the Ford Transit engine?

Solution: The Transit with the 2.0 and 2.4 DuroTorq Di diesel engines suffer from a failing Bosch injection pump. The cam plate fails in the Bosch VP30 fuel injection pump. The solution is to fit a revised and modified injection pump. The fuel system should be thoroughly cleaned and checked for any metal particles in the fuel system.

Where is the fuel pump on a transit van?

With the ignition turned on pin 7 of the fuel pump connector should be a 12 volt feed try to check this with the wiring connected as if the pump is disconnected the engine management cuts the power to it after a short time.

Is there a warranty on Ford Transit injectors?

Ford plans to replace the faulty injectors with injectors of the correct quality. This will be done under warranty with no charge to customers.

What does p0235 mean on Ford Transit TDCi?

After my ECU update and the newer software detecting a fault, the van then moaned about P0235 – “turbocharger boost sensor A malfunction”. What this really means is “the data I am getting from the

What kind of diesel engine does Ford Transit have?

A continuous update on technology and improved economy has helped to maintain the ranges position at the top of the class. Every Transit range that has been manufactured comes with a strong 2.0 litre EcoBlue diesel engine that is highly efficient and very economical.

What kind of fuel pump does Ford Transit use?

Started last week after a three week lay-up. Instant start as always, pulled forward ten feet and the engine cut-out. Would not start at all, turned OK but acted like it was out of diesel. Checked all the usual checks, even got the local garage out with the diagnostic stuff.

Can a Ford Transit run out of diesel?

Instant start as always, pulled forward ten feet and the engine cut-out. Would not start at all, turned OK but acted like it was out of diesel. Checked all the usual checks, even got the local garage out with the diagnostic stuff. No luck.

Are there any problems with Ford Transit injectors?