Why does my 2001 Astro van not start?

by Lee Sallings. The three most common causes of a no-start condition in your 2001 Chevy Astro van are starting/charging system failure, ignition system failure and fuel system failure.

Where is the fuel pump on a Astro van?

If it is good, check for power at the fuel pump electrical connector located near the rear of the fuel tank on the driver’s side of the van. In the Chevy Astro van, power is supplied to the fuel pump by the the gray wire on the electrical connector when the engine is being cranked.

What should battery voltage be in Astro van?

A measurement of 12.5 volts is considered discharged, and the battery should be charged before any further testing. Any measurement below 11 volts indicates a severely discharged battery–the battery is most likely damaged and should be replaced. If the battery measures above 12.7 volts, proceed to the next step.

What to do if your starter doesn’t turn?

If battery voltage is present at the purple wire, and the starter doesn’t turn, replace the starter. If the voltage measurements at the starter are correct, and the starter cranks the engine over when the key is turned to the start position, proceed to the next step.

What causes a Chevy Astro van to not start?

In the Chevy Astro van, power is supplied to the fuel pump by the the gray wire on the electrical connector when the engine is being cranked. If power is supplied, hitting the fuel tank with the flat side of a hammer while someone else is turning the ignition key to start will sometimes bump the fuel pump enough to allow it to start.

When did the Chevy Astro rear wheel drive come out?

Made to compete with the Toyota Van, Dodge Caravan and Plymouth Voyager, Chevrolet released the rear-wheel drive Astro in 1985. The Chevrolet Astro and GMC Safari, which shared the same platform, were used as passenger vehicles, converters, and cargo vans.

What was the purpose of the Chevy Astro?

Dependable, tough and long-lasting, the Chevrolet Astro was Chevrolet’s answer to the growing need for a versatile mid-sized van. This van was used for both personal and commercial purposes, thanks to its superb towing and passenger-carrying capacity.

Can a Chevy Astro be replaced with aftermarket parts?

If you are not satisfied with how your Chevrolet Astro parts do their load of the performance, you can always replace them with aftermarket and custom Chevrolet Astro auto parts and have them gentler and more minivan-like in terms of the ride and drive factors.

https://www.youtube.com/watch?v=JHh5idP8QP8

How to replace a fuel pump in an Astro van?

Astro Van Fuel Pump Replacement – 1996-2005 (GMC Safari) – 4 MINUTE DIY VIDEO – YouTube NOTE: For some reason some models have an additional cover over the gas tank.

How to diagnose no start no fuel?

This case study will help you diagnose a No Start No Fuel Condition with the ‘Spider’ injector. ‘Spider’ Fuel Injector Misfire and Hydrolock (Troubleshooting Case Study) . This case study will help you diagnose a fuel injector (within the ‘Spider’) that’s stuck open and causing a Hydrolock condition.

by Lee Sallings. The three most common causes of a no-start condition in your 2001 Chevy Astro van are starting/charging system failure, ignition system failure and fuel system failure.

Why does my GM car say no start no crank?

How to diagnose a no start no click on GM vehicle. If you have a late model GM vehicle and turn the key only to hear nothing, you’ll most likely think you have a dead battery—and you may. But a no start, no crank, no click condition can be far more involved than that.

How to troubleshoot a no start GM 4.3L pick up?

Testing a Cranks but Does Not Start condition on your GM 4.3L, 5.0L, 5.7L pick up, van or SUV is not that hard to do, if you have a solid diagnostic strategy. In this article I’ll show you the basics of testing such a problem.

What’s the difference between no start and no crank?

It’s important to know that a no crank and a no start condition are not the same thing since this article only concentrates on testing a no start condition. In layman’s terms, a No Start Condition means that your vehicle’s starter motor is cranking the engine but the engine is not starting.

Why does my car engine not want to start?

If the engine still doesn’t seem like it wants to start, probably fuel is getting into the cylinders and your problems lies somewhere else. However, if the engine runs momentarily and dies, then the problem is that fuel is not getting to the cylinders. Check for a clogged fuel filter, or a bad fuel pressure regulator.

What does no start no crank no click mean?

If you have a late model GM vehicle and turn the key only to hear nothing, you’ll most likely think you have a dead battery—and you may. But a no start, no crank, no click condition can be far more involved than that. In the old days, power flowed through the ignition switch and down to the starter solenoid. Not anymore.

What to do if your car won’t start?

Diagnosing a no-start condition uses a process of eliminating the possible culprits to pinpoint the cause. Use a series of simple tests to diagnose these problems quickly and accurately.

What are common reasons my Chevrolet Astro won’t start?

What are common reasons my Chevrolet Astro won’t start? While there are a variety of reasons your Chevrolet Astro won’t start, the most common 3 are a dead battery, an alternator problem, or failed starter.

Can a car start with no crank or no starter?

Yes, especially if there is a bad connection to the starter, or from the battery. Doesn’t take much juice to click the solenoid, but it takes a lot of juice to turn the starter and turn over the engine.

Why does my car starter not turn on?

Doesn’t take much juice to click the solenoid, but it takes a lot of juice to turn the starter and turn over the engine. The other thing is it is an intermittent problem on the vehicle, so if the starter was intermittently acting up when installed, it could also be intermittently acting up when tested at the auto parts store.

What does it mean when your truck won’t start?

Hate to say it but if the solenoid clicks and it don’t start, it’s either a bad battery, bad starter or bad battery cables. A bad starter will do it almost every time, a bad cable can be intermittant but gets worse quickly. My bet is the battery has a bad internal buss contact plate.

How big is a 2001 Chevy Astro minivan?

This minivan used to fit between the top-selling Dodge Caravan and Grand Caravan in size, but things have changed since the 2001 redesigns from Dodge were made. Todays regular-length Caravan is nearly as long as the Astro, while the Grand Caravan measures 11 inches longer.

What is the length of a Chevy Astro?

The Astro comes in LS and LT trim levels, either for passenger use or as a two-seat Cargo Van for commercial use. Exterior. Marketed in one body length, Astros ride a 111.2-inch wheelbase and measure 189.8 inches long overall.

When did the Chevy Astro minivan come out?

Following Chryslers 1984 debut of its front-drive minivans, Chevrolet introduced its truck-based midsize van a year later. Slotted between the Venture minivan and the full-size Express van/wagon, the Astro comes with either rear-drive or all-wheel drive.

Where did the 2001 Chevy Astro come from?

1st owner purchased on 12/12/01 and owned in WA until 12/18/15 • 2nd owner purchased on 12/18/15 and owned in UT until 05/24/21. 1st owner drove an estimated 12,748 miles/year • 2nd owner drove an estimated 0 miles/year.

How many miles does a Chevy Astro have?

Mileage: 114,432 miles Body Type: Van Color: White Engine: 6 Cyl 4.3 L No accident or damage reported to CARFAX. 1st owner purchased on 11/30/99 and owned in OH until 03/10/09 • 2nd owner purchased on 03/10/09 and owned in OH until 07/06/09 • 3rd owner purchased on 07/06/09 and owned in OH until .

What kind of engine does a Chevy Astro have?

A 190-horsepower, 4.3-liter Vortec V-6 engine is the sole powertrain and is driven by a four-speed-automatic transmission that incorporates a Tow/Haul mode for transporting heavy loads. Chevrolet claims its the biggest V-6 in its class.

When did GM stop making the Chevrolet Astro?

In 2003, GM upgraded the chassis of both the Astro and Safari with certain suspension components, larger brakes, and six-lug, 16 inch wheels from the full-size Chevrolet and GMC half-ton pickup trucks. The Chevrolet Astro and GMC Safari twins were originally scheduled to be discontinued after 2002,…

When did the Chevrolet Astro minivan come out?

The Astro and Safari were introduced for 1985 as the first minivan from General Motors. While marketed as a response to the first-generation Chrysler minivans, GM adapted a rear-wheel drive layout, sizing the Astro and Safari closely to the short-wheelbase Chevrolet G10 van.

What’s the towing capacity of a Chevy Astro?

The Astro was marketed as a minivan, though sized between the Chevrolet Venture/Lumina APV unibody minivan and the full-size Chevy Van/Express. Similar to the Ford Aerostar, it had powertrain components in common with GM’s other light trucks and up to a 5,500 lb (2,500 kg) towing capacity.

When did the Astro Air Conditioner come out?

For the 1994 model year, GM started manufacturing most of their vehicles, including the Astro and Safari, with CFC-free air-conditioning systems, which used R134a refrigerant instead of R-12 refrigerant.

What to do if your car won’t start at PassLock?

A red (or yellow) “security” warning light will stay illuminated and the engine will either a) never start or b) start for a moment and then shut down. A temporary fix is to leave your key in the ignition, at the “auxiliary” position for about 10-15 minutes until the security light shuts off.

Diagnosing a no-start condition uses a process of eliminating the possible culprits to pinpoint the cause. Use a series of simple tests to diagnose these problems quickly and accurately.

What are the symptoms of a failing Vortec distributor?

Symptoms of Failing Vortec Distributor 1 Engine misfires 2 P0300 to P0306 engine codes (for misfire) 3 Engine is slow to start, or not starting 4 Poor idling, acceleration, etc. (usually caused by misfires)

What to do if your Chevy Silverado won’t start?

Simple fix by checking the ground in the harness right behind the passenger side cylinder head. Trace the break and wire it to a new location for a ground such as the front of the cylinder head as I did. Loading…

Why does my 2001 Chevy Silverado not start?

My 2001 Chevy will not start. I replaced the fuel filter and I can hear the fuel pump running. Could it still be the fuel pump? What model Chevrolet is this? Any warning lights on the dash? Sorry, it’s a Silverado. No lights, and the diagnostic tool shows nothing. OK. Most likely not the fuel pump. If a new one made no change, then highly unlikely.

How to troubleshoot the electrical system in a Chevy?

When interior lights start flickering or just don’t want to work at all, your first step is to check fuses and relays. If that checks out, look for a loose wire connector. Don’t forget to check the ignition switch too. Examine the ground cable from the engine to the firewall, particularly if you’re experiencing more than one electrical problem.

What to do if your Chevy Express won’t start?

It sounds like it’s trying to start but won’t. The key only comes out in vans that are equipped with the V.A.S.T system. Weirdly banging on the dash sometimes works too. If it does not try to start for a second and then die, replace the cap and rotor. This video is about an issue involving the disabling of the fuel pump for security. Loading…

Why is my car starter not working properly?

” When you face car starter problems, remember that lack of proper battery maintenance, faulty electrical connections and components will prevent your starting system from working properly. Whatever the source of the problem, these troubleshooting tips will help you when your car won’t start.

What should I do if I have a problem with my starter system?

Inspecting Cables and Wires. Corrosion around battery terminals prevents electrical flow. This is a common problem on a battery or starter system that hasn’t received much attention. If you notice a layer of corrosion around one or both battery terminals, clean them with a solution of baking soda and warm water.

What should I do when I remove the starter motor?

If you removed the starter motor for inspection, this is a good chance to check the flywheel as well. The flywheel is the large, heavy wheel between the engine and transmission. This is the wheel that the starter pinion gear engages to crank the engine. Once you’ve removed the starter motor, set your transmission to Neutral.

Why does my car starter keep acting up?

The other thing is it is an intermittent problem on the vehicle, so if the starter was intermittently acting up when installed, it could also be intermittently acting up when tested at the auto parts store. Ok thanks. next thing i will do is check wiring harness and grounds. thanks again guys

How to troubleshoot a Chevy 4.3 engine?

1 Common Problems. A common complaint with the Chevy 4.3 engine is that it doesn’t idle well, it’s loud and makes awkward noises. 2 Idle Air Control Valve and Throttle Conrtol Switch. Open up the hood and look at all the wires, spark plugs, tubes, vacuum lines and valves. 3 Check Your Oil. 4 Vehicle Fuilds. …

How long does a Chevy 4.3L Vortec engine last?

3 vortec is a very strong and reliable motor, proven by it being the longest lasting production vortec engine. Generally, these engines are extremely capable of lasting up to 300,000 miles.

Why is the Check Engine light not coming on?

Even if the check engine light hasn’t come on, you may find a pending code that can guide you in your diagnosis. False input or lack of input from sensors like the crankshaft position sensor (CKP) or camshaft position sensor (CPS) can prevent the engine from starting.

Do you need trouble code to replace sensor?

Remember that most trouble codes refer to a specific circuit and replacing the sensor without confirming it is bad, may not solve the problem. Disclaimer:We cannot guarantee the accuracy of all trouble codes .

Can you do a diagnostic without a trouble code?

Throughout the years, more emission related systems and components have been incorporated to the list of computer monitored systems. Still, some performance and driveability problems can appear without the computer setting any DTC. So you need a different strategy to do a diagnostic without the help of a trouble code.

What should temp be for Astro van to start?

Seems that van runs perfectly if temp is below 32 degrees or when no humidity when warmer. It has been raining about once a week and problem is back. Van is in garage and will start after a few days. I decided to put a ceramic heater near the front under carriage and the van started after a day.

Why does my car not start after I replace the battery?

Evaluating Your Car’s Key Systems for Possible Failure. There are many other possible problems that could lead to the fact that, after you’ve replaced the battery, the car won’t start. One or more of several key systems might not run properly, or there could be a serious malfunction with the electrical system.

Why did my Astro van have no start?

How to Troubleshoot No Start in a 2001 Chevy Astro Van. The three most common causes of a no-start condition in your 2001 Chevy Astro van are starting/charging system failure, ignition system failure and fuel system failure.

What’s the length of a 2001 Chevy Astro?

Marketed in one body length, Astros ride a 111.2-inch wheelbase and measure 189.8 inches long overall. This minivan used to fit between the top-selling Dodge Caravan and Grand Caravan in size, but things have changed since the 2001 redesigns from Dodge were made.

What kind of engine does a Chevrolet Astro have?

Chevrolet Astro. Along with its rebadged variant, the GMC Safari, the Astro was marketed in passenger as well as cargo and livery configurations—featuring a V6 engine, unibody construction with a separate front engine/suspension sub-frame, leaf-spring rear suspension, rear bi-parting doors, and a seating capacity of up to eight passengers.

When did the Chevrolet Astro and Safari come out?

Background. The Astro and Safari were introduced for 1985 as the first minivan from General Motors. While marketed as a response to the first-generation Chrysler minivans, GM adapted a rear-wheel drive layout, sizing the Astro and Safari closely to the short-wheelbase Chevrolet G10 van. Similar to the Ford Aerostar, to reduce production costs,…

Why does my Toyota Tacoma engine not start?

When the computer senses the engine is out of time, it will turn on the check engine light, and the engine may start and stall, or fail to start at all. If the engine runs, it w…

What to do when your car won’t start?

Correcting most no-start problems usually involves replacing the alternator, starter or battery, cleaning connections, ignition system repairs, or fuel system repairs. But because there are so many potential causes, the diagnosis is key to understanding how expensive the repair will be. When a vehicle doesn’t start it can be for many reasons.

Is the astrostart remote start system for free?

WINTER IS HERE. IS YOUR CAR READY? Free Smartphone Car Control! With AstroStart’s new DS4 technology, smartphone vehicle control capability is built right into your AstroStart remote start system.

Do you need a phone to use astrostart?

Free Smartphone Car Control! With AstroStart’s new DS4 technology, smartphone vehicle control capability is built right into your AstroStart remote start system. AstroStart® products offer cutting edge technology and are designed and engineered for safe and easy use for years of convenience, comfort and reliable trouble-free service.

Why does my truck not start after sitting for a long time?

This can happen when the check valve in the fuel pump assembly leaks pressure back into the fuel tank. The longer the truck sits the harder it is to start. Try this, turn the key on for 2 seconds then off, do this two more times then try and start it.

When did my car lose power then died?

While driving car lost power then died and now won’t star… I was driving and all of a sudden when I hit the gas there was nothing there I got it where I was going and then it died while I was still driving we have not been able to get it to start since it does crank but does not start. My car has 185000 miles.

What causes a car to not start with no gas?

Problem may be at wiring connector on top of fuel tank (hard to reach!). No gas in fuel tank (Check the fuel gauge, and keep in mind the gauge may not be reading accurately). Bad gas (Contaminated with water or too much alcohol or diesel fuel). If you just filled up with gas and now your car won’t start, suspect bad gas.

What should fuel pressure be when no Buzz?

Fuel pressure is typically in the 35 to 45 psi range. If your Anti-Theft light is flashing; the anti-theft system is disabling the fuel pump to prevent the engine from starting. Bad fuel pump (Pump should run for a few seconds when ignition key is turned to start, no buzz means no fuel delivery to the engine).

When did the second generation Chevy Astro come out?

In this article, we consider the second-generation Chevrolet Astro, produced from 1995 to 2005.

When was the last time I owned a Chevy Astro?

1st owner drove an estimated 11,462 miles/year • 2nd owner drove an estimated 5,102 miles/year. Last serviced at 122,500 miles in Chula Vista, CA on 12/07/20 • Vehicle serviced • Maintenance inspection completed. Accident reported. Purchased on 11/18/02 and owned in CA until 05/01/21. Driven an estimated 7,668 miles/year.

How many miles does a Chevy Astro drive?

1st owner purchased on 02/10/04 and owned in CA until 04/03/04 • 2nd owner purchased on 05/11/04 and owned in CA until 10/16/20. 1st owner drove an estimated 0 miles/year • 2nd owner drove an estimated 8,198 miles/year.

Who was the original owner of the Astro?

No accident or damage reported to CARFAX. 1st owner purchased on 04/06/01 and owned in CA until 01/07/05 • 2nd owner purchased on 05/29/05 and owned in CA until 02/16/21. 1st owner drove an estimated 11,462 miles/year • 2nd owner drove an estimated 5,102 miles/year.

When was the last time I serviced my Astro?

1st owner drove an estimated 0 miles/year • 2nd owner drove an estimated 0 miles/year • 3rd owner drove an estimated 0 miles/year • 4th owner drove an estimated 0 miles/year. Last serviced at 213,699 miles in Loris, SC on 04/02/21 • Vehicle serviced • Brakes serviced • Serpentine belt replaced • Brakes checked.

Why does my 2001 Astro van not start?