Why did I have to replace the turbo on my 2005 PT Cruiser?

Our 2005 PT Cruiser has a 2.4 liter turbo. We had to replace the turbo at 78K miles due to “carbon buildup and clogged” so said the dealer. I can not get any local mechanic to tell me why this happened or if it is normal.

Where does burnt oil go in a turbo?

Over time layers of burnt oil will accumulate on the inside walls of your feed line slowly restricting flow. Shards of the burnt oil can also break free and travel down towards the bearing passageways blocking the flow of oil to important areas of the turbo.

Why do I get buidup in my Turbo?

If you do a lot of in-town driving and short trips I think it has the possibility of creating carbon buildup because the turbo is driven by the exhaust. I don’t believe that oil will necessarily cause the buidup. This is not an octane problem and the octane of the fuel has no effect on the turbo itself.

How does the PCM know when to cut back on fuel?

To check on how well it did calculating the air/fuel mixture, it checks the readings from upstream oxygen sensors (O2). If the readings shows the exhaust is rich, the PCM will cut back on fuel. If the reading is too lean, it’ll add fuel.

Why does my Chrysler PT Cruiser not start?

If your battery no longer has enough charge to turn the starter, your PT Cruiser will not start. As a battery ages, it’s “cranking amps” decrease, leaving it with a diminished capacity for starting the vehicle. When this happens, you’ll often hear the vehicle crank slowly, but not start.

What causes an oil leak on a PT Cruiser?

This problem is pretty common on PT Cruisers that have a small oil leak. It is commonly misdiagnosed as an oil pressure switch which is a common issue on these cars as well. It is easily corrected with a couple of inexpensive parts. The PCV valve starts to get plugged up and doesn’t seal tight.

Why do you not use synthetic oil in turbochargers?

DO NOT use Synthetic blends because they will not resist the heat exposure as Full Synthetic oil will. As seen in the attached photographs coking can occur due to poor oil quality, extending oil changes and “Hot Shutdowns”. The needle sized bearing oil passageways can easily be blocked with the coking leading to imminent TurboCharger failure.

Are there any recalls on the Chrysler PT Cruiser?

A recall was done on the dashboard and replacement is covered under it. The other solution is to live with the cracks. If they don’t bother you, they don’t cause the car to malfunction, so you can continue to drive the car with them. The car this issue conflicts is the 2007 Chrysler PT Cruiser.

How much does it cost to fix a PT Cruiser engine stall?

The car this issue conflicts is the 2006 Chrysler PT Cruiser. Typical repair cost for an engine that stalls and shuts off while driving is $700. This is the most dangerous of the PT Cruiser problems. It involves the engine to completely stall out while driving.

What’s the best way to fix a PT Cruiser?

The best solution is to have a professional car mechanic well versed in PT Cruiser problems. A tempory solution was to turn the car off and back on. But this only stopped the problem temporarily and quite often the problem would arise again upon the next time the owner drove the car.

What was the problem with my PT Cruiser GT?

MY 2007 PT non-turbo did the same thing at about 18K miles. It was the camshaft positioning sensor. It is a $65 part. I had it replaced under warranty. Knowing what it looks like and how easy it is to replace, I will replace it myself next time. It involved removing two screws and an electrical lead- no biggie.

When did the Chrysler PT Cruiser come out?

The compact PT Cruiser is a retro-style wagon or convertible produced by American automaker Chrysler. The PT Cruiser debuted in 2000, with the convertible version arriving in 2005.

How do you get a computer code on a PT Cruiser?

In addition, as with all vehicles sold in the United States, the system is OBDC3 compatible, so that a standard diagnostic device can be plugged into a standard jack to get computer codes. When some problems are found, the computer lights up the “engine light;” others are ignored until a mechanic asks for them.

What’s the name of the 2003 Chrysler PT Turbo?

Now DaimlerChrysler just needs to figure out what it plans to call the car. The invitation to the unveiling called it the 2003 PT Cruiser GT, and sure enough, there were little GT badges on the first-level prototypes we drove. But company spokespersons now say the car should be called the PT Turbo.

What’s the name of the 2003 Chrysler Cruiser GT?

The invitation to the unveiling called it the 2003 PT Cruiser GT, and sure enough, there were little GT badges on the first-level prototypes we drove. But company spokespersons now say the car should be called the PT Turbo. All right, whatever. Just let us know when you’ve made up your minds, okay?

How much horsepower does a Chrysler PT Cruiser have?

This vehicle, the PT turbo, transfuses the PT Cruiser with more power. Using a Mitsubishi turbocharger to blow 14 pounds of boost down the 2.4-liter four-cylinder engine’s throat, the bruiser Cruiser makes 205 horsepower at 5200 rpm.

Why does my 2004 PT Cruiser keep stalling?

My Wifes 2004 pt cruiser began bucking and stalling, I took it to the shop ,they plug it into their computer and tell me the AC cooling fan itself was burned out causing the car to overheat and stall. So we replaced it and the car still does the same thing.

Why does my 2006 PT Cruiser overheat?

2006 pt cruiser 2.4 turbo ho put on fail proof thermostat a month or two . Don’t not overheat on 20 mile drive but does on a longer trip. Radiator is full just notice coolant tank may be leaking could that be the only problem or something else? Cooling fan is working also. Is this a good question?

When did the Chrysler PT Cruiser convertible come out?

2005 Chrysler PT Cruiser Convertible FCA Chrysler kept PT interest up by introducing a convertible in 2004 as an ’05 model. The following year, the whole PT line received a mild facelift, dialing back the retro vibe with a deep front apron, shorter grille, and scalloped headlights.

What kind of horsepower does a PT Cruiser have?

For 2003, the turbocharged GT model with 215 horsepower and 245 lb-ft of torque gave the PT Cruiser the guts to back up its hot rod looks. Much of the customizing defied the PT’s low-priced nature.

Find the most common driver-reported problems that are to blame when a Chrysler PT Cruiser won’t start. If the engine does not crank (or cranks but won’t start), the wireless control module (wcm) may have locked up. this… The battery is considered dead when there isn’t enough charge to start the engine or run electrical components.

Why did I have to replace the turbo on my 2005 PT Cruiser?