What causes a Duramax Diesel to lose power?

Vocational, Technical or Tra… Duramax Chev. P.U. (2003) loses fuel prime and motor stops running at low RPM or at an idle. No visible leak around filter area. Fuel pressure … read more Vocational, Technical or Tra… Hi, I just purchased a 2004 Kodiak C4500 crewcab with the Duramax diesel engine mated to an Allison with 4:44 gear ratio.

Are there any problems with the Duramax LMM?

One problem can rear its head when you are pushing the power of the LMM to a level GM never imagined, and that’s with the pistons. Simply put, they can crack under pressure. There are a lot of factors which dictate the power level where a piston bites the dust, but it’s usually north of 600 horsepower.

What makes a Duramax LB7 diesel so special?

The introduction of common rail injection powered by the Bosch CP3 injection pump made the LB7 Duramax stand apart from other diesels of the day with excellent power and efficiency.

Where is the CP3 injection pump in a Duramax?

The CP3 injection pump sits in the valley of the engine between the cylinder heads and is driven by the camshaft gear, and it has two main jobs: get fuel from the tank up to the engine, and pressurize the fuel to 26,000psi and ultimately inject it into the engine.

Why does my Duramax say reduced engine power?

If you’ve got a Duramax diesel, the Reduced Engine Power warning could Illuminate for a variety of reasons. There are many different technical service bulletins (TSBs) for Duramax-powered vehicles that mention Engine Reduced Power mode.

Why does my GM car have a reduced engine power warning?

Some GM vehicles will enter Reduced Engine Power Mode when the engine begins to overheat due to cooling system issues. The PCM triggers the mode to protect the engine from further damage. In some instances, the Reduced Engine Power warning may illuminate to inform the driver that the vehicle lacks power due to an underlying condition.

What causes a Chevy 2500HD to lose power under load?

Probably P0087. Check the fuel hoses at the side of the trans– they can get kinked, weak and collapse. I’ve just experienced a very similar situation with my 2005 2500HD. After driving about 2 hours, over varying terrain, I had to stop at a light (not the first on the trip).

What happens when I put my car in reduced power?

GM’s Reduced Power Mode can inhibit your vehicle’s ability to accelerate. Even if power isn’t reduced immediately, performance may be limited the next time you go to drive the car. In some instances, the PCM may actually cut off fuel delivery to the engine, rendering the vehicle undrivable.

What causes a Duramax injection pump to fail?

As a result (allegedly), the lack of lubrication in the fuel can cause a premature failure of the injection pump, to a point where it won’t allow the LML Duramax to run. You can be driving down the road and everything seems normal, and when the pump fails, the truck just shuts off.

Why is the fuel pump and relay not working?

The ignition circuit, which includes the ignition switch, controls power to many components, including the fuel pump and relay. If there is an issue with the switch or the circuit, perhaps a wiring problem, then power to the fuel system may be cut off.

Where is the fuel pump on a Duramax Diesel?

The pump is located in the engine valley (between the heads, at the front). Don’t worry about it or mess with it, just yet.

Is my fuel pump failing?

If you’re driving at freeway speeds and notice your engine sputter or jerk, you may have a failing fuel pump . This problem is caused when the fuel pump can’t deliver a smooth flow of fuel to the engine; periodically, your engine receives only air when it was expecting to receive fuel.

What is a Duramax lift pump?

Whether you own a Power Stroke, Cummins , or Duramax-powered rig (or something else altogether), a lift pump can simply be defined as a low-pressure supply pump that is used to transmit fuel to a high-pressure pump. In the case of most mechanical engines, fuel pressure is fed to an injection pump,…

What’s the RPM on a 2005 GMC Duramax?

Check out the thread “2005 6.6 max rpm 2000”, there are some suggestions there. Also search for the “ice pick trick” as it is one of the suggestions that often comes up for this problem.

What kind of engine does a Duramax diesal have?

I have a 2002 Chevrolet Duramax diesal that has started to shift wildly. Sometimes it reves up to 3.5 K rpm before shifting and sometimes it doesn’t … read more Automotive Repair/Damage… I am looking for a 4 wheels on the ground car to tow behind my motorhome I understand the chev cobalt and chev malibu have this capability. I … read more

Check out the thread “2005 6.6 max rpm 2000”, there are some suggestions there. Also search for the “ice pick trick” as it is one of the suggestions that often comes up for this problem.