How do you remove an AC evaporator from a Dodge Ram?
How do you remove an AC evaporator from a Dodge Ram?
Then use the 8mm socket and ratchet to remove the top bolts located near the windshield, and lastly, use the 13mm socket to release the passenger compartment dash. Then you may wiggle it out and remove the dash as a whole. Figure 2. Remove dash panel under steering column. Figure 3. The bolts are located to the right and left of the center vent.
How does an AC evaporator work in a car?
The A/C system is complex in the way that its made up of multiple parts and components, and lots of physics and complicated terms are involved. That being said, the evaporator plays the biggest role of drawing in the heat and humidity out of the cabin and replacing it with cold air.
How does the a / C system work on a Dodge Ram?
You turn your A/C on, crank it to the coldest temperature setting and expect cold air to come out through the vents, but instead, the system lets you down and blows warm air. The A/C system is complex in the way that its made up of multiple parts and components, and lots of physics and complicated terms are involved.
Then use the 8mm socket and ratchet to remove the top bolts located near the windshield, and lastly, use the 13mm socket to release the passenger compartment dash. Then you may wiggle it out and remove the dash as a whole. Figure 2. Remove dash panel under steering column. Figure 3. The bolts are located to the right and left of the center vent.
How do you change the battery in a Dodge Ram?
Figure 1. Disconnect the battery. Start by accessing the driver’s side footwell and use the Phillips screwdriver to undo the three screws that hold the lower dash panel underneath the steering column together, then repeat this step on the passenger side.
Why is my Dodge Ram 1500 AC not working?
Pretty common is that the climate door above the blower has broke and fallen blocking air flow. Also after time the Evaporator gets clogged and also blocks the flow through the cooling fins of the Evaporator .
You turn your A/C on, crank it to the coldest temperature setting and expect cold air to come out through the vents, but instead, the system lets you down and blows warm air. The A/C system is complex in the way that its made up of multiple parts and components, and lots of physics and complicated terms are involved.
When to replace the dash top on a Dodge Ram 1500?
Get our aftermarket full replacement dash top for your 2nd Gen ’98-’02 Dodge Ram 2500/3500 or ’98-’01 Dodge Ram 1500 trucks and help make the interior of your truck look new again. This is a full replacement dash top and not a cover.
Can you remove the HVAC system from a Dodge Ram?
Ok Folks here is a lengthy DIY for the removal of the HVAC system in a 2nd Gen Ram. Now this was done on a 1998 Ram 1500 Quad Cab. Some areas may vary and the number of bolts may change.
What kind of dash board does Dodge Ram have?
The 1998 -2001 Dodge Ram pickups have the biggest problem for cracked dash boards. Whether you have a Dodge 1500, 2500, or 3500 series we have the best solution to make your dash board look like new again. With all the complaints for Dodge dash boards in the Dodge Forums you will see you are not alone in this problem.
Can a replacement dash top be left unpainted?
Left unpainted, the replacement dash is quite reflective and will typically cause a glare on the inside of the windshield on a sunny day. We will also include a copy of issue 82 of the TDR with an article on replacing the dash in a ’98-’02 Dodge Ram 2500/3500.
When does the a / C Drain in a Dodge Ram?
This article applies to the 2nd generation Dodge Ram (1994-2001). When the A/C in your Dodge Ram operates, water is produced and is supposed to drain out of the cooling system and truck cabin via the drain hose.
Where does the water come from in a Dodge Ram?
When the A/C in your Dodge Ram operates, water is produced and is supposed to drain out of the cooling system and truck cabin via the drain hose. If you notice a water leak puddling up the passenger’s side foot well, there are two minor issues at fault.
Why does my a / C Leak in my Dodge Ram?
Because the hose faces downward, the air passing the open end of the hose creates negative pressure that draws the water out of the system. Now, when the A/C is on blast, air pressure is reversed and water should leak out of the drain hose away from the truck’s interior.
When to replace the evaporator core in a Dodge Ram?
To replace the heater core and the Evaporator core, the entire Dashboard has to be moved away from the wall of the truck. Most 4th Gen trucks from 2010-2018, 1500,2500,3500,4500 all use the same type of dashboard configuration.
Because the hose faces downward, the air passing the open end of the hose creates negative pressure that draws the water out of the system. Now, when the A/C is on blast, air pressure is reversed and water should leak out of the drain hose away from the truck’s interior.
When to replace heater core and evaporator core?
If you have to replace either the heater core or the evaporator core, you might as well replace both of these parts since they sit side by side of each other. That is the best solution u can do because if you only do one of them, chances are u might have to replace the other one later.
This article applies to the 2nd generation Dodge Ram (1994-2001). When the A/C in your Dodge Ram operates, water is produced and is supposed to drain out of the cooling system and truck cabin via the drain hose.
Can a bad expansion valve cause an AC system to overheat?
Too much refrigerant flow and the evaporator core will freeze over; too little and the evaporator core will overheat and compromise the efficiency of the AC system. The expansion valve meters refrigerant flow according to evaporator temperature and the load and cooling demand of the AC system.
The A/C system is complex in the way that its made up of multiple parts and components, and lots of physics and complicated terms are involved. That being said, the evaporator plays the biggest role of drawing in the heat and humidity out of the cabin and replacing it with cold air.
What happens to the evaporator in a Dodge Ram?
That being said, the evaporator plays the biggest role of drawing in the heat and humidity out of the cabin and replacing it with cold air. So if the evaporator were to fail, it wouldn’t be able to turn that warm air into cold. Below is a step-by-step guide on how to replace the evaporator in your truck.
How to remove the dash from a Dakota?
The snaps may come off and stay in dash, use needle nose pliers to remove them and re-secure then to the panel. -Remove lower dash panel from under column, Three Torx head screws. The P Brake release rod will be attached tot he handle, there is a keeper that rotates down and the rod slides out the side of the handle.
Do you need to take dash out for heater core replacement?
If you are going in because of the heater core do yourself a favor and plan to replace the Core and Evaporator, no reason to do this more than needed. I also did the Blower motor and resistor on recommendation, but both of those units (at least in the ’01) are accessible without taking the dash out.
What causes a water leak in a Dodge Ram?
If you notice a water leak puddling up the passenger’s side foot well, there are two minor issues at fault. First of all, the drain hose is parallel to the ground. Secondly, when driving on the freeway or highway, plenty of air pressure is produced inside of the engine compartment, which affects the cooling system’s hoses.
Why is the carpet wet in my Dodge Ram?
Why is the carpet wet in the passenger’s side floorboard of your Dodge Ram? This water leak problem has something to do with your truck’s A/C system, which occurs more often when it rains and when it’s damp outside. By Richard Bowen – July 21, 2015 This article applies to the 2nd generation Dodge Ram (1994-2001).
If you notice a water leak puddling up the passenger’s side foot well, there are two minor issues at fault. First of all, the drain hose is parallel to the ground. Secondly, when driving on the freeway or highway, plenty of air pressure is produced inside of the engine compartment, which affects the cooling system’s hoses.
Where is the dye leak on a Dodge Ram?
On the low side of the A/C system, the dye would have worked well, but on the high side, it escaped too “fast” from the leak area to leave the residue. The compressor has a handful of seals, including one under the output shaft (under the a/c coil pulley), and if leaking, could be difficult / impossible to see. One last thing to try.
Why is the carpet wet in the passenger’s side floorboard of your Dodge Ram? This water leak problem has something to do with your truck’s A/C system, which occurs more often when it rains and when it’s damp outside. By Richard Bowen – July 21, 2015 This article applies to the 2nd generation Dodge Ram (1994-2001).
If you are going in because of the heater core do yourself a favor and plan to replace the Core and Evaporator, no reason to do this more than needed. I also did the Blower motor and resistor on recommendation, but both of those units (at least in the ’01) are accessible without taking the dash out.
The snaps may come off and stay in dash, use needle nose pliers to remove them and re-secure then to the panel. -Remove lower dash panel from under column, Three Torx head screws. The P Brake release rod will be attached tot he handle, there is a keeper that rotates down and the rod slides out the side of the handle.
