How much does it cost to replace an AC compressor clutch?

The AC compressor clutch replacement cost will be between $700 and $1000. Labor costs tend to be about $150 to $250, with the new compressor costing $450 to $850.

Why does my AC compressor clutch not engage?

Why AC clutch won’t engage If the clutch doesn’t engage, the problem could be a blown fuse, an open in the wire to the clutch coil, a bad clutch coil, a poor ground, or a low pressure lockout. AC compressor clutches receive power in a number of ways.

How is the compressor clutch relay turned on and off?

In some vehicles the compressor clutch relay is turned on and off by the low pressure switch and the evaporator temperature sensor. In a computer controlled system, the compressor clutch relay is grounded by the computer. If the fuse is good, disconnect the electrical connector from the compressor clutch coil.

When to recharge car AC after compressor replacement?

If your car is not cooling down properly then maybe the compressor requires replacement. And then, you must recharge the ac after changing the compressor to start blowing the cold air again. People usually hire a mechanic for this procedure.

The AC compressor clutch replacement cost will be between $700 and $1000. Labor costs tend to be about $150 to $250, with the new compressor costing $450 to $850.

Look into This! Engaging the AC compressor clutch at home is not rocket science. There are a couple of ways you can fix the problem to bring back the air conditioning system in order. What is the most common reason for an air conditioning compressor not to engage?

Why does the clutch not engage in a low pressure car?

If the PCM (powertrain control module) senses low pressure in the low pressure fluid line, it will stop the compressor clutch from engaging to prevent any damage. This is because low pressure = low fluid, and r 134a is also oil/lubricant for the compressor and if you don’t have fluid then you will damage the compressor.

What happens if you have a bad air conditioner clutch?

If the compressor clutch gets damaged, it will keep the air conditioning system permanently on or off. A faulty compressor clutch can be replaced but it is generally recommended to replace the whole compressor to save time and additional cost. How to Diagnose if the Car AC Compressor Has Failed?

What should I do if my air conditioner clutch is spinning?

The clutch allows the compressor pulley to engage or disengage from the motor, ensuring it is only running when it should. If the clutch seizes, normal action cannot continue. Look at the front of the compressor while the air conditioning is running to see if the clutch is spinning.

What happens when the clutch on an AC compressor breaks?

When the compressor clutch breaks, the bearing inside the compressor can become damaged as well. While it’s not common to see fluid leaking through the front seal because of a failed AC compressor clutch, it’s not unheard of. Look at the compressor to see if there are any signs liquid is leaking out through the front seal.

Can you replace only the clutch on a Dodge Ram?

By replacing only the clutch, you are saving on labor, compressor and parts like filter drier and expansion valve. Pages with related products. See and discover other items: a/c compressor clutch, compressor clutch, ac compressor clutch, dodge clutch, 2002 dodge 1500 items, jeep air compressor

What kind of clutch does a Dodge 1500 have?

AC Compressor Clutch. Fits; 2004-2007 Dodge Ram 1500 3.7 & 4.7 liter Gas Engine. For OEM compressor only. Made in the USA by Maxsam Clutches.

Can you replace just the clutch on your AC compressor?

AC Compressor Clutch replacement?? Discussion in ‘ Engine & Performance ‘ started by cheapbeater, Oct 13, 2010 . Can I replace JUST the clutch on my AC compressor?

Is there an AC compressor for a Dodge Ram?

Junkyard that has a heart will sell ya one on the cheap. 5.7?? Check out myosinner on dt. He has a rolled over o6 night runner may still have the compressor. He has half the truck in hi livng room now lol. pm him. Or go to a pick and pull. Or bite that bullet. myy 2 cts cousin.

What should I do if my AC compressor clutch is not working?

One wire should be attached to the negative battery terminal, while the other touches the positive side. If your electromagnet is good, the compressor clutch will kick on. Remove the positive wire to release the clutch. You can repeat this process several times to ensure the clutch is working as it should.

What are the symptoms of a bad air conditioner clutch?

One of the most obvious symptoms you notice is that the car’s air conditioning system stops blowing cold air. This is because the damaged compressor fails to distribute the refrigerant effectively, resulting in the air condition to blow hot air.

If your car needs a new AC compressor clutch put into it, it’s not going to be particularly cheap to do it. The AC compressor clutch is a small part of your AC system, but it can cost a lot of money to replace it. On average, you’re going to have to pay somewhere between $600 and $670 to replace your AC compressor clutch.

How to replace AC compressor clutch in Jeep Cherokee?

(Playback ID: 0OkUpd-zhFEJiqN3) An error occurred while retrieving sharing information. Please try again later.

Can a compressor be replaced in an air conditioner?

It’s not normally recommended to replace the compressor clutch, but rather, install a whole new compressor. Because the compressor is one of the main parts of the air conditioning system, it is an expensive part, probably the most costly of the entire system. However, it isn’t difficult to replace.

How do you remove AC compressor clutch?

Insert the male threaded end of the compressor clutch removal tool into the female threaded end of the clutch. Thread the removal tool into the compressor clutch until it becomes too difficult to turn by hand. Tighten it with a standard open-end wrench until it is completely seated.

Can the AC clutch be replaced?

Yes you can just replace the clutch pulley on the a/c compressor. The issue that you may have is the pulley bearing seized up and may have spun on the front of the compressor nose cone and will damage it. You may not be able to get the old pulley off and if you do the new one will not seat and hold on…

Why does my AC clutch not engage?

Why AC clutch won’t engage. If the clutch doesn’t engage, the problem could be a blown fuse, an open in the wire to the clutch coil, a bad clutch coil, a poor ground, or a low pressure lockout. AC compressor clutches receive power in a number of ways.

Can you run car without a compressor clutch?

if the clutch and/or pulley on your compressor are okay, yes, you can continue to operate your vehicle without any issues…without a compressor you will need a bypass pulley and special length of belt.

How much does it cost to replace an AC compressor clutch?