What kind of problems does a Duramax engine have?

The 5 Most Common LB7 Duramax Engine Problems 1 Fuel Injector Failure 2 Water Pump Failure 3 Fuel Filter Housing O-ring Leaks 4 Blown Head Gasket 5 Overheating (fan clutch problems, radiator gunk)

What happens when I put my Duramax in limp mode?

While in limp mode, the transmission will lock in 3rd gear, the torque converter will remain unlocked, and the transmission will not be able to operate in reverse. It’s great to have such a fail safe, but in many instances the limp mode is activated when it’s not entirely necessary.

Is there a problem with the glow plug on my Duramax?

Often, you can verify the problem by wiggling the wires around the injector. If the problem goes away (even momentarily), you’ve identified the affected zone. Glow plug failure was a concern on the 2006 model year LBZ and LLY Duramax models, but the problem should have been long corrected for owners of these years.

When did GMC Duramax lose power under load?

In 2012 there was a P1093 code and the dealer invoice states “…low rail pressure during enrichment. Command high fuel rail pressure, pressure drops. Follow diagnostic chart, test system pressure, relief valve failed” so they replaced the FPRV.

Why is my Duramax diesel engine not working?

The trucks computer keeps track of how much fuel needs to be added or subtracted from each individual cylinder to make the engine run smoothly, and this value is called the balance rate. If one cylinder is contributing too much or not as much as the rest, the cause is usually a bad injector and the cure is a replacement.

Are there any problems with the LLY Duramax?

In terms of LLY injector problems, GM had sorted out the internal failures with the 2004 ½ redesign, but the LLY Duramax would occasionally exhibit a trouble code for the injectors, but in most cases it turned out to be an issue with the injector harness rubbing through and causing a short or open in the wiring.

Are there any issues with the Duramax check engine lights?

Glow Plug System Issues – Nearly half of the check engine lights that come in for the Duramax pickups are for glow plugs. The glow plugs burn out over time and can be a real nuisance to remove from the aluminum heads sometimes.

When do I need to repair my 2003 Duramax?

For 2003 vehicles covered by Vehicle Service Contracts, all eligible claims with repair orders on or after October 10, 2006 are covered by this special policy and must be submitted using the labor operation codes provided with this bulletin. Claims with repair orders prior to October 10, 2006 must be submitted to the Service Contract provider.

What are the most common 6.6L LB7 Duramax problems?

What Are The Most Common 6.6L LB7 Duramax Problems? The LB7 Duramax engine made its debut on Chevrolet and GMC HD trucks in 2001. These diesel engines are where the Duramax started, and they have been so successful that the Duramax are still used in GM HD trucks today.

Are there any problems with the Duramax water pump?

This seems to be inherent of the factory water pump design. Overheating issues with the Duramax diesel seems to be a hit-or-miss problem; some owners experience it, while others never will. Regardless, it’s more common with the Duramax than other engines.

What are the common problems with 6.6L Duramax?

9 Common 6.6L LB7 Duramax Problems. 1 1. LB7 Duramax Injectors. The most notorious LB7 Duramax problem is their original injectors. Even GM acknowledged their problems when they corrected 2 2. Lack Of A Fuel Lift Pump. 3 3. Fuel Filter Housing O-Ring Leaks. 4 4. Water Pump Failures. 5 5. Overheating.

Are there any problems with the Duramax fuel pump?

It can also be relatively difficult to prime the fuel system once air has been introduced into the system, such as when the fuel filter is changed. The 2001 to 2004 LB7 fuel filter housings seem to be the most prone to problems. Water pump failures for Duramax engine are somewhat common.

What causes a fuel filter to leak on a Duramax?

Fuel Filter Housing Oring Leaks – The Duramax fuel system does not have any sort of low pressure fuel pump pushing fuel to the engine from the tank. The injection pump sucks all the fuel from the tank.

What kind of problems does a Duramax engine have?