Why does my Ford Expedition not have a front blower?

I bought a used 2017 expy from carmax and had no front blower. They sent it back to the dealer and I wanted to know exactly what was found. I was told the 40 amp fuse had a bad connection and was reset with dielectric grease, that was it, has worked fine since.

How does the blower work on a Ford F150?

In this video, we look at intermittent blower motor function on a Ford Expedition but will be the same for similar F150’s. This vehicle the blower motor would turn on and off intermittently in various conditions, but if the wire harness for the blower controller was wiggled it would come back to life.

Why is my front AC blower not working?

I’ve seen many posts from people whose front AC blower would stop occasionally. My wife would kick the wires under the glove compartment and it would start again. It finally failed altogether. Following the advice from other owners, I replaced the blower motor resistor. That didn’t help.

Why is my Ford Expedition air conditioner not blowing cold?

Conclusion: A/C Not Blowing Cold Ford Expedition Most of the time, when your Expedition ‘s air isn’t blowing cold enough, it is going to be a lack of refrigerant causing the problem. We recommend having a professional recharge your A/C if it does end up being a coolant issue.

Where is the fuse on the Ford Expedition blower?

I replaced a 40-amp fuse in the power distribution box under the hood and a 10-amp fuse in the panel under the glove compartment. I also replaced a blower motor relay in the power distribution box. I bought a new blower motor. I plugged in the wires, but I didn’t install it yet (It’s in a tough-to-reach spot).

How much does it cost to replace an air conditioner in a Ford Expedition?

When the $125.00 service was done the trusted mechanic said that my A/C compressor was week and needed to be replaced (after charge blowing coldish) So I purchased a complete kit (not from ford but a good kit anyways) and had it replaced (parts and labor $1200)

Why is my a / C not working in my Ford Expedition?

My A/C started to not be cold so I took it to a trusted mechanic who diagnosed my issue as needing a Freon charge.

How much does it cost to replace clutch fan in Ford Expedition?

Long story short replacing the $100 clutch fan solved my issue I ended up spending close to 2k for in parts, time, gas and agony when it was just the clutch fan. Hope this helps someone out there!! Cautionary tale of bad mechanics Ive never had this much trouble before.

What to do if your Ford Expedition heater stops working?

If the heater has stopped working in your Expedition , this process has failed in one way or another. A word of caution: If there is no coolant in your overflow, you can refill it by adding more to the overflow reservoir. There is almost never a situation where you would need to take the radiator cap off of the radiator to add coolant.

Why is my Ford Escape heater not working?

It does this by allowing water to enter the engine when it is getting hot, and by keeping coolant from entering while the vehicle warms up. Sometimes when a thermostat goes bad, it stays stuck open. This allows the coolant to continuously enter the engine.

When did the Ford Expedition air conditioner issue happen?

Discussion in ‘ 2nd Gen – 2003 – 2006 ‘ started by Jb14, Jun 19, 2013 . Hi Folks I am posting this in hopes that it can help you all not to have to go through what I had to for a year with and air conditioning issue with my 2005 Expedition.

Why is the air only blowing through the front vents?

The air only blows through the front defrost vents, the back air works fine. What could that be? have the same problem? Check for a vacuum leak see picture and look at the vacuum motors see if they are getting vacuum when put on defrost/floor etc..

When did my front AC blower stop working?

Discussion in ‘ 3rd Gen – 2007 – 2017 ‘ started by John Gouch, Jun 5, 2019 . I’ve seen many posts from people whose front AC blower would stop occasionally.

Why is my Ford Expedition not blowing cold?

Blend Door – The blend door controls how much air conditioned and heated air enters the cabin. If it gets jammed or locks up, your Expedition can’t respond to your temperature change request. These are a few of the most common issues that could cause your Expedition to not blow cold enough. There are other issues that can cause this as well.

Why is the rear air not blowing out?

Rear air works good no problem there. Could it be a fuse? no on the fuse,it works off vacume,check under hood driver side fender well for vac lines see if one has come unpluged or is soft,if so just replace the line,is rubber lines. 96 people found this helpful.

Why is no air coming out of front vents?

There is no air coming out of the front or defrost vents. The vents for the back seats work, but that’s it. I heard that this is actually the blower motor under the hood. This is like a $50 dollar fix if you order it online and watch the 1A auto video that demonstrates how to replace it! 11 people found this helpful.

Where are the vents on a Ford Explorer?

Open the glove box and push the side tabs in so it drops all the way down. Make sure you have a flashlight and shine it slightly upward towards the stereo. If you cannot see the metal actuator arm, turn on your truck and move through the vent settings until you do see it.

Where does the air come from in a Ford Explorer?

***AND AGAIN, TO THOSE WHO ARE SUGGESTING IT…THE AIR BLEND DOOR ACTUATOR HAS NOTHING TO DO WITH THE PLACE WHERE THE AIR COMES OUT! IT ONLY ADJUSTS THE TEMPERATURE ***

Why is my air conditioner not working in my Ford Expedition?

But my Fixed A/C stopped working again I took it to a new mechanic who after alot of trouble shooting found the problem. Which was again the Clutch Fan that was replace 10 days ago by the bad mechanic.

What kind of air flow does a Ford Explorer have?

Also if I have only the fan on (no air) the fan blows strong … read more 1993 Ford 150, 302 engine .. AC vent runing 60 degrees…84 degrees ambinent Flushed condenser/evaporator/lines twice…..changed the compressor/drierexp valve…pulled vacuum twice , two 45 minut … read more I own a 2005 Ford Explorer XLT and it has a V6 engine.

Why does my car have no air flow?

I am getting almost no air flow from the vents when on MAX AC. When in normal AC and the engine has a load, like going getting almost no air flow from the vents when on max AC…hill… I have a Ford F-150 1999. The AC works but it does not blow I have a Ford F-150 1999. The AC works but it does not blow well through the main vents.

How much does a 2010 Ford Expedition cost?

Monthly Estimate based on a 4.4% rate for 60 months, $10,900 vehicle price, $0 down payment, $0 trade-in, $0 sales tax. They sent an email right away about the truck and gave additional information that had been done to it since the listing.

Where was the Ford Expedition EL last serviced?

Mileage: 144,145 miles Body Type: SUV Color: White Engine: 6 Cyl 3.5 L No accident or damage reported to CARFAX. Purchased on 10/02/15 and owned in HI until 08/27/18. Driven an estimated 8,971 miles/year. Last serviced at 53,395 miles in Gainesville, FL on 06/04/21 • Vehicle serviced.

Discussion in ‘ 3rd Gen – 2007 – 2017 ‘ started by John Gouch, Jun 5, 2019 . I’ve seen many posts from people whose front AC blower would stop occasionally.

What are the problems with the Ford climate control?

Ford Motor Climate Control Problems 1 Air Condition. The Ford air condition system consists of the compressor, accumulator, evaporator, receiver/dryer and the lines. 2 Heating. The heater core and blower motor work in concert to send warm air into the Ford’s cabin. 3 Ventilation. 4 ETC. …

Why is my Ford air conditioner not working?

Problems with any of these three systems might prevent you from maintaining the cabin climate. The Ford air condition system consists of the compressor, accumulator, evaporator, receiver/dryer and the lines. The number one cause of AC system failure is a refrigerant leak.

Which is climate control system does your Expy have?

Unfortunately, even the manual heater on the XLT utilizes computer circuitry, which can always be suspect, but the “kick wires” clue tends to eliminate that nightmare. iimagine and Yupster Dog like this. Welcome to the site. Which climate control system does your Expy have?

Why does my a / C fan cycle on and off?

Before what the problem was, the a/c compressor was constantly cycling on/off and the air was just slightly cold. The only time the compressor stayed on before was if I left the fan on full speed, and even then it would cycle when driving on the highway, and I’d get periods of warm air that smelled like a warm refrigerator.

Why does my air conditioner blow cold air?

The air conditioner blows cold air but switches from front vent 2 floor 2 defrost vent simultaneously. None stay on very long they just keep switching back and forth. Do I need to get AC checked or what?

Are there any problems with the Ford Expedition?

While the latest generation resolved most Ford Expedition engine problems, some drivers have complained about faulty throttle bodies in the 2017 Expedition and the 2016 model year’s engine dying or surging while driving. Among these issues, faulty Ford Expedition fuel injectors are considered the worst.

How can I get my Ford Expedition back on the road?

Everything is on hand and ready to ship, so you can get your Ford Expedition back on the road in just a few days. Ordering Ford Expedition spark plugs, fuel injectors, and other parts and accessories only take a few clicks. Just enter your vehicle’s model year into our website’s vehicle selector to limit the results to compatible products.

How to order Ford Expedition parts and accessories?

Ordering Ford Expedition spark plugs, fuel injectors, and other parts and accessories only take a few clicks. Just enter your vehicle’s model year into our website’s vehicle selector to limit the results to compatible products. If you have a preferred brand or price range, tweak our search filters to find what you need faster.

What to do if your AC compressor is not engaging?

If the clutch is engaging, then it’s time to check the system pressure. You can use the gages that come attached to your refill bottle purchased at WalMart of and auto parts store. Find the low pressure service port which is against the firewall, passenger side, connected to the AC dryer/accumulator can.

What’s the low side psi of an AC compressor?

Low side PSI at say 75 degrees would be around 35 PSI. Believe your switch has failed. It unscrews and another screws in, a shrader valve stops loss of refrig coolant. Wear protective PPE ‘anyway for your eyes. High side PSI of around 180 PSI. Some running down the highway might read 220 PSI.

Why are the cooling fans not working on my car?

1. Engine running hot 2. Cooling fans do not function 3. Cooling fans stay on at all times Average rating from 129,472 customers who received a Vehicle Engine Cooling Inspection. Most modern vehicles use electric cooling fans to help pull air through the radiator so that it can keep the engine cool.

What happens when a cooling fan relay fails?

If the relay fails, it will be unable to supply power to the fans, and as a result they will not operate. This can lead to overheating, especially when the vehicle is at a stop, where there is no forward motion by the vehicle to pass air over the radiator. 3. Cooling fans stay on at all times

What is the problem with my Ford Expedition?

The fan the controls the A/C and heat does not work. The temperature is controllable, but that’s it. I don’t see any burnt fuses. At one time, I was trying to swap a turn signal relay and the fan conrol stopped working. The dealer says the problem is the dashboard climate contol unit.

Is the back of the Ford Expedition heated?

I have recently purchased a used 2008 Ford Expdition Eddie Bauer from a dealer with 12K on it. My problem is that the heated seat work OK, but do not get as warm as my old 2001 Chevy Tahoe seats. It seems that the back of the seat is warmer than the base of the seat.

What causes a vacuum leak in a Ford Expedition?

There are a number of areas that you need to check for vacuum leaks. From the head unit (the controls) to the canister in the engine compartment. It could even be a small evap leak elsewhere that is keeping the system from maintaining enough vacuum under high load conditions.

What causes a bad or failing blower motor relay?

Blown fuses. One of the first symptoms of a bad or failing AC blower motor relay is a blown AC blower motor relay circuit fuse. If the blower motor relay develops any sort of problem that hinders its ability to properly limit and distribute power, it may cause the blower motor fuse to blow. Any sort of electrical spikes or excessive current…

What causes a fuse to blow on a blower motor?

If the blower motor relay develops any sort of problem that hinders its ability to properly limit and distribute power, it may cause the blower motor fuse to blow. Any sort of electrical spikes or excessive current from a bad relay will blow the fuse and cut power in order to protect the system.

Why is the blower motor on my Ford Explorer not working?

If your 4.0L Ford Explorer (Aerostar, Ranger, B4000, Mountaineer, Mountaineer) is currently experiencing a ‘no blower’ problem, then there’s a good chance that the blower motor has fried and needs to be replaced. In this tutorial I’ll show you how to test it and find out for sure.

Why does my interior climate control fan stop working?

Recently my interior climate control fan stopped working. Turn the switch, nothing happens, on any speed. OK.. I went through and replaced all the major culprits.. a new blower motor, new blower resistor & harness, and new blower relay.

Why does the blower motor slow down when accelerating?

However, if the vacuum motor develops a small leak, or there is a leak in the vacuum hose or the dashboard switch, the drop in vacuum may be too much to overcome. That’s when you get a change in airflow. When the door doesn’t operate properly, it may sound like a Blower motor slows down when accelerating

What happens if you lose the blower motor relay?

The blower motor is the component responsible for pushing air through the vents of your vehicle’s heating and air conditioning systems. Without it, the AC system will not be able to circulate any heated or cooled air. The blower motor relay controls the current used to power the blower motor,…

What happens if you have a bad blower motor?

What causes a blower motor to not work?

If the blower motor resistors’ internal components fail it may cause the blower motor to malfunction, or not function at all on one or more of the settings. This can also be caused by a blower motor switch, so a proper diagnosis is highly recommended if you are uncertain of what the issue may be.

Why is my Ford truck heater blowing cold air?

The issues you describe is a common fault with older ford trucks. It is most commonly caused by faulty bearings inside of the steering wheel column. To inspect the bearings, a technician will need to remove the steering wheel.

What happens when a blower motor relay wears out?

Without it, the AC system will not be able to circulate any heated or cooled air. The blower motor relay controls the current used to power the blower motor, and is subject to the constant on and off switching. Over time, it can eventually wear out.

Why does the a / C blower slow down when the RPMs go up?

Why does the a/c blower slower down when the rpms go up c… When the truck sits and idles the blower works fine but when your driving and start to pull a hill the blower slows down when the truck is at about 3000 rpms nothing really is coming out of the vents as soon as you let off the accelerator it picks back up to normal

Why does my Ford Expedition not have a front blower?