Why does my 1996 Express van not start?

Hoping it is not the fuel filter, car seems to run OK once it has started. took the 1996 express van back to the mechanic and we put the computer that reads codes on it. It only said egr as a code. This van starts when cold but not on the first crank, maybe the second or third and only if the engine is cold.

When does a van start in the Cold?

This van starts when cold but not on the first crank, maybe the second or third and only if the engine is cold. When driven it runs great no problems at all ….goes down the road very good even . But if I stop to shop and come back out it will not start till its cold again , then it will start everytime (cold).

What is the diagnostic code for engine stall?

Diagnostic trouble codes P0120, P0121, P0122, P0123, and P0124 are what will commonly appear. The engine can stall for no reason and without any warning. This happens when the TPS gives incorrect information to the ECM. The engine can stall at high speed, at low speed, or even at idle.

What to do if your Chevy Express won’t start?

It sounds like it’s trying to start but won’t. The key only comes out in vans that are equipped with the V.A.S.T system. Weirdly banging on the dash sometimes works too. If it does not try to start for a second and then die, replace the cap and rotor. This video is about an issue involving the disabling of the fuel pump for security. Loading…

How to reset PassLock reset system on Chevy?

1. Turn the key to ON and attempt to start the engine and release the key to the ON position. 2. The SECURITY light will illuminate. Wait 10 minutes until it turns off. 3. Turn the key to OFF for 10 seconds. 4. Turn the key to ON and attempt to start the engine.

What was the ignition module for a 1996 GMC k1500?

1996 GMC K1500, K2500, K3500 Pick Up. All of the information you need to diagnose a misfire or a no-start problem (caused by the ignition coil, the ignition module, or the crankshaft position sensor). Wiring diagrams.

What kind of battery is in Chevy Express?

Before and after insulating the back of our Chevy Express cargo van. Our electrical system consists of 200 amp-hours of lithium ion batteries from Renogy, 300 watts of solar, a 1000 W inverter, and a Renogy DC/DC charger so we can charge from the alternator.

Why is the Chevy Express a camper van?

That YouTube channel captured our imagination because, being from Michigan, the thought of traveling via sailboat to exotic tropical lands seemed a whole lot cooler than battling rush hour traffic in the horrible suburban winters of Detroit. It also inspired us because of their ability to fund their adventures through YouTube and Patreon revenue.

What are the most common GMC truck problems?

One of the most common 2007-2013 GMC and Chevy truck problems owners experience is excessive oil consumption. This problem led vehicle buyers to launch a class-action lawsuit against GM, which alleged 2010-2013 vehicles with Generation IV 5.3 Liter V8 Vortec 5300 engines were defective.

What kind of Van is 99 Savana vortex?

I am new but have also suffered with a “different running” 99 Savana 5.7L Vortex conversion Van. It was purchased as a project van because it would run sometimes and sometimes not. It turned out to be the fuel pump, or so I thought. It has 180K on it and the pump was replaced once in that time.

Why is my Chevy Silverado not 4 wheel drive?

Over time, dirt, moisture and corrosion can affect the contacts on the bolts used to attach the wires to the frame. If you have a 2008 Chevy Silverado with 4-wheel drive problems, or a similar GMC or Chevy truck from another model year, replacing the switch will solve the issue.

What kind of problem does a 1997 GMC pick up have?

1997 GMC K1500, K2500, K3500 Pick Up. All of the information you need to diagnose a misfire or a no-start problem (caused by the ignition coil, the ignition module, or the crankshaft position sensor). Wiring diagrams.

What causes a no start on a GMC Savana?

1996-1999 GMC Savana Van. All of the information you need to diagnose a misfire or a no-start problem (caused by the ignition coil, the ignition module, or the crankshaft position sensor). Wiring diagrams.

Is there an issue with the Chevy Express?

Chevy Express Van- Ac/Heat Fan Blower issue Fixed! – Resistor Replacement, Wire Harness Repair – YouTube Chevy Express Van- Ac/Heat Fan Blower issue Fixed! – Resistor Replacement, Wire Harness Repair

Where can I buy a 1997 Chevy Express?

For Sale 11 Chevrolet Express 1500 Passenger vehicles nationwide. Used 1998 Chevrolet Express 1500 $N/A Kendall at the Idaho Center Automall Used 1997 Chevrolet Express 1500 New Listing $N/A CHELSEA MOTORS LLC Used 1997 Chevrolet Express 1500 New Listing $N/A Village Motors, Inc Used 1997 Chevrolet Express 1500 $5,500 Private Seller Used 1997

Is there a warranty on a Chevy Express van?

GM is not responsible for the safety or quality of independent supplier alterations. Chevrolet Accessories are dealer-installed and covered by the GM 3-year/36,000-mile (whichever comes first) New Vehicle Limited Warranty when ordered with your new Express Van. See your dealer for details.

How much horsepower does a Chevy Express van have?

4.3L V6 1 Standard on Express 2500 and Express 3500 Cargo and Passenger Vans and Cutaway Van with 139” wheelbase 2 276 horsepower and 298 lb.-ft. of torque 3 Maximum towing capability of 7,400 lbs.† (10) 4 Direct Injection and Variable Valve Timing

What are safety features on Chevy Express vans?

Your safety is our business. Express vans offer advanced active safety features to help your passengers stay safe while you’re on the go. Safety or driver assistance features are no substitute for the driver’s responsibility to operate the vehicle in a safe manner.

Why does my Chevy 5.7L hard start?

Lol, its the only problem a 11 year old truck has. We can turn the key and wait for it to energize before cold starts. It sounds like the fuel pressure regulator to me. If it has to crank when cold but not when it’s warm, it sounds like it is bleeding off fuel pressure while it sits for a while. How many miles on the truck?.