How long does it take to repair a compass on a Ford Explorer?

The process of disassembling the display, cleaning and re-soldering the board, and reassembling the display required about 30 minutes of work; work that I expanded to 3 hours including research, battling the connector plugs with clumsy fingers, and extra trips from house to truck for forgotten tools.

What kind of compass does Ford Explorer sportrac have?

2001 Ford Explorer Sportrac at Corolla, NC. Described by Car & Driver as the Swiss army knife of SUVs. Yet, age and heat degrade electric components needing repair. For several months, the digital compass and temperature display gradually faded.

What kind of display is on Ford Explorer?

LCD Vacuum Fluorescent display manufactured in Mexico for the 2001 Ford Explorer Sportrac. Displays compass and external temperature. Soldering flux and quality fine silver-bearing solder are critical to a solid joint. Cold-soldered resistors whose solder points fail due to age, heat, pollution and vibration.

How do you repair a compass and temperature display?

Slide your fingers into the gap until you are 3/4 of the way toward the front. Next, pull the console firmly to release the two tabs that secure it to the ceiling. At this point, the console will be dangling by the main electrical harness and the sun-roof motor plug.

What kind of display does a Ford Explorer have?

This is a repair service for the overhead compass / temperature display on many 1998-2005 Ford models, including: Explorer, Explorer Sport Trac, Expedition, Excursion, or F150, F250, F350, F450, and F550 Super Duty trucks. If your Ford overhead display containing the compass and temperature information is flickering or has gone out, we can help!

How to calibrate the compass on a Ford Escape?

1. Start the vehicle. 2. To calibrate, press and hold the RESET control for approximately ten seconds until CAL appears. Release the control. 3. Slowly drive the vehicle in a circle (less than 3 mph [5 km/h]) until the CAL display changes to the direction value. It may take up to five circles to complete calibration. 4.

What’s the problem with my compass and temperature display?

Several online forums I searched pin-pointed two resistors labeled “510” as the most likely cold-solder culprits. These resistors are designed to step down the voltage required by the display and do so by dissipating energy as heat.

Where is the electronic compass on a Ford F-150?

Ford F-150 trucks made after 2000 have an electronic compass that is located in a console above the rear view mirror, attached to the ceiling of the cabin. The compass has an LED display that is controlled by resistors on a circuit board. The resistors are soldered to the circuit board, but can become loose with time. …

What was the problem with my digital compass?

For several months, the digital compass and temperature display gradually faded. Pressing the display buttons and tapping the screen temporarily revived the device, but eventually, the fade was permanent. Research and the experience of others suggested the root of the problem was a faulty cold-solder connection.

What was the problem with my overhead compass?

Pressing the display buttons and tapping the screen temporarily revived the device, but eventually, the fade was permanent. Research and the experience of others suggested the root of the problem was a faulty cold-solder connection.

Where is the fuse for the ECU located?

Locate the fuse for the ECU using the fuse diagram on the underside of the fuse panel cover. Pull the fuse for the ECU using the fuse pullers in the fuse panel. Turn the ignition to the “On” position but don’t crank the engine (it won’t start anyway).

Can a Ford Excursion fuse box be repaired?

This Ford Fuse Box repair service is for a failing or faulty fuse box on a 2000 through 2005 Ford Excursion. This failure commonly appears as a fuel pump or horn related issue.

Where are the fuses located on a Ford Explorer?

The fuse panel is located on the left hand side of the instrument panel facing the driver’s side door. Pull the panel cover outward to access the fuses. The power distribution box is located in the engine compartment near the battery. Power mirror. Power antenna Air bag system.

How many amps does a Ford Explorer have?

Passenger compartment № Amp Rating Description 1 7.5 Amp Power mirror. Power antenna 2 7.5 Amp High-mount stoplamp 3 15 Amp Parking lamps 4 10 Amp Left headlamp

Why is my digital compass screen going blank?

Several online forums confirmed my suspicion about what was causing the digital display screen to fade to blank. When the fade can be temporarily repaired by pressing or tapping on the unit or the display, a loose connection is the culprit. Eventually, the connection degrades and a permanent fix is necessary.

How do you repair an overhead compass in a Ford Explorer?

Pulling down on the tab will begin to release the console from the ceiling. Slide your fingers into the gap until you are 3/4 of the way toward the front. Next, pull the console firmly to release the two tabs that secure it to the ceiling. 2001 Ford Explorer Sportrac Overhead Console.

What are the signs of a Ford Explorer transmission failure?

Check out the list below for some of the most commonly-reported signs of Ford Explorer transmission failure: 1 Unable to switch gears 2 Burning smell 3 Leaking fluid 4 Grinding or shaking 5 Check engine light comes on 6 Slipping transmission

Where can I buy a 1997 Ford Explorer?

If you are in the market for a BARGAIN PRICED SUV you need to consider this 1997 Ford Explorer Eddie Bauer. This 4WD unit is PRICED LOW TO SELL FAST so stop in today and take it for a test drive at S & H by Simonton Lake!!!*, 4WD, Alloy wheels, Leather Sport Bucket Seats.

How to repair the overhead compass and temperature display?

Unplug the display harness from the white housing and split open the housing by carefully prying the 4 tabs on the outer edge. At this point, the housing, the main harness, and the overhead light harness can be set aside as one unit, with the green circuit board remaining in front of you.

What should I do if my Ford Explorer is stuck in 4WD?

OFTEN IF IT IS STUCK MECANICALLY IN LOW OR 4WD YOU CAN PLACE THE SELECTOR IN 2WD OR AUTO AND GO IN REVERSE FOR A FEW YARDS AND SEE IF IT DISENGAGES. SOMETIMES U HAVE TO DO THIS A COUPLE TIMES. iT HAS WORKED W/ ME ON DIFFERENT EXPLORERS IN THE PAST

What is the Ford Explorer sportrac overhead console?

2001 Ford Explorer Sportrac Overhead Console. At this point, the console will be dangling by the main electrical harness and the sun-roof motor plug. Disconnecting these plugs is simple, but not necessarily easy depending on your patience, dexterity and tools available.

Where can I buy a new Ford Explorer?

Call us toll free at 1-800-541-9352 to order The Ford Explorer has been a staple for the company and for people who drive SUVs for a long time. Ford makes both a smaller and a larger SUV that look basically the same, but the Explorer has a great following because of its mid-sized appeal.

When do I need to do work on my Ford Explorer?

When you need to do some work on your Ford Explorer, though, make sure you take the time to find the right mechanic, the right body shop, and the right maintenance company. They should all use high-quality parts and be proud of their service. If they don’t and they aren’t, it’s time to go elsewhere.

When did the Ford Explorer get an engine upgrade?

The V-8 engine was upgraded to a much more powerful output of 292 horses, which came with a 6-speed automatic transmission. Side curtain airbags were added in 2008, and Ford upgraded the satellite-operated navigation system with voice-activated controls.

Can a digital compass and temperature display be repaired?

Yet, age and heat degrade electric components needing repair. For several months, the digital compass and temperature display gradually faded. Pressing the display buttons and tapping the screen temporarily revived the device, but eventually, the fade was permanent.

Why is the fade on my compass not working?

When the fade can be temporarily repaired by pressing or tapping on the unit or the display, a loose connection is the culprit. Eventually, the connection degrades and a permanent fix is necessary. I am not a proficient handyman. The idea of taking things apart that I might not put back together again generally intimidates me.

When was last serviced Ford Explorer Eddie Bauer?

No accident or damage reported to CARFAX… 1st owner purchased on 12/08/03 and owne… Last serviced at 130,097 miles in Sweetw… 1st owner drove an estimated 7,705 miles… No accident or damage reported to CARFAX…

How long does it take to repair a compass on a Ford Explorer?