How do you remove the fuel tank from a Ford Expedition?

Remove the fuel tank from the vehicle. 1. Install the vent hose to the fuel tank vent spout. 2. CAUTION: Do not support the fuel tank directly beneath the fuel pump mounting area. Damage to the fuel pump assembly can occur. CAUTION: Correct routing of the fuel vent hose and fuel tank pressure sensor is critical to fuel system operation.

How does the fuel pump work in a Ford Expedition?

The fuel pump in a Ford Expedition moves the gasoline from the tank, up through the fuel lines, through the fuel filter and on to the fuel rail where it reaches the fuel injectors. Without the pump, which is the heart of the fuel system, everything else in the system cannot function.

How do you remove a drop tank fuel pump?

1. Remove the fuel pump module. See above^^ 2. Remove the shrink wrap and disconnect the electrical connector. 3. Remove the fastener and lift the fuel level sensor from the fuel pump module. 4. To install, reverse the removal procedure.

Where is the fuel vent hose on a Ford Expedition?

Make sure that the fuel vent hose and fuel tank pressure sensor are routed above the crossmember and brake cables. NOTE: If a new fuel tank is being installed, transfer the fuel vent hose and fuel tank pressure sensor to the new tank. Position the fuel tank in the vehicle.

How to update your Ford navigation system map?

Get the latest Ford navigation system map update for the most current data, including new roads, businesses, addresses and much more. Updating your Navigation System Map | SYNC | Official Ford Owner Site

How do you change the stereo in a Ford Expedition?

Pry open the screw cover on the rear edge of the door panel and remove one Phillips screw, then remove two 7mm screws from the bottom edge of the door panel. Moving back up the door, pry out the sail panel.

How do you remove a door panel on a Ford Expedition?

The door panel removal process begins with prying off the screw cover behind the door release and removing one 7mm screw. Pry off the door release trim to release the retaining clips and remove the trim, then pry open the screw cover inside the door pull cup and remove two exposed 7mm screws.

How to eject a CD in a Ford Expedition when stuck?

Insert the tip of a blank disc into the player and attempt to lodge it into the player underneath the stuck disc. Try to push the stuck CD up into the ejecting track to remove it from the player.

What happens when a fuel pump relay goes bad?

If the fuel pump relay has an issue while the vehicle is operating it will cut off power to the fuel pump, which will cause the engine to stall. A faulty relay may allow the vehicle to be restarted a short while later, while a completely failed relay will not.

Why is my Ford Expedition engine cutting off while driving?

Shortly after the engine would stutter and sometimes stall and would restart. Took back to our guy and we were having a devil of time repeating the experience. Eventually he finds a lose ignition wire and believes that was the fix.

What to do if your Ford Expedition is stalling?

Before troubleshooting any automotive issue, including stalling issues with the Expedition , make sure that you check the vehicles trouble codes with an OBD2 scanner. Trouble codes are always a great place to start diagnosing problems on today’s modern computer controlled vehicles. Without them, you are in the dark.

When did the Ford Expedition air conditioner issue happen?

Discussion in ‘ 2nd Gen – 2003 – 2006 ‘ started by Jb14, Jun 19, 2013 . Hi Folks I am posting this in hopes that it can help you all not to have to go through what I had to for a year with and air conditioning issue with my 2005 Expedition.

How much does it cost to replace clutch fan in Ford Expedition?

Long story short replacing the $100 clutch fan solved my issue I ended up spending close to 2k for in parts, time, gas and agony when it was just the clutch fan. Hope this helps someone out there!! Cautionary tale of bad mechanics Ive never had this much trouble before.

What to do if your car shuts off when stepping on the gas pedal?

In most late model cars, this problem will usually trigger the Check Engine light. A top-rated mobile mechanic will come to your home or office to determine the source and cause of the stalling condition, and will then provide a detailed inspection report that includes the scope and cost of the necessary repairs.

Why is my Ford Expedition in no run condition?

This 2003 Ford Expedition came in with a no run condition. A quick check found no fuel pressure and a code P0231 (low voltage on fuel pump monitor circuit). I decided to go to the interior fuse box, where my wiring diagrams, stated the fuel pump relay and fuse are located. There are a couple of covers that have to be removed.

What kind of fuel filter does Ford Expedition have?

The 1997-2006 Ford Expedition models come equipped with a quick-connect fuel filter. The main responsibility of the fuel filter is to keep any type of fuel impurities from entering into the fuel injectors so only clean fuel makes it to the injectors and the engine.

Where is the fuel pump on a car?

Then there’s the labor. On some cars (particularly domestics) the fuel tank must be dropped to access the pump, making the job especially time-consuming. Other vehicles (typically imports) have an access cover below the rear seat that makes the job much easier.

What should I do if my fuel pump does not work?

After mechanic replaced… After mechanic replaced fuel pump gas gauge does not work. Took my truck to mechanic for routine maintenance and he replaced the fuel pump. After I got the truck back and filled the gas tank I noticed the fuel gauge wasn’t reading correctly.

How do you remove the fuel tank from a Ford Expedition?