Why did Cat stop making the Turbo Cat 3208?
Why did Cat stop making the Turbo Cat 3208?
Cat quit making the 3208 because it was too “dirty” in the emissions department, not because it wasn’t a good engine for them. Now, to answer the question about how much power you can get out of one, Cat has pulled 435 HP out of that engine easily.
How much power does a Cat 3208 have?
Cat quit making the 3208 because it was too “dirty” in the emissions department, not because it wasn’t a good engine for them. Now, to answer the question about how much power you can get out of one, Cat has pulled 435 HP out of that engine easily. You can make this at 2800 rpm without too much trouble.
Which is better a Turbo Cat 3208 or a DT466?
The DT466 is a great engine. They have a gigantic lower end in them. But the 3208 is a great engine as well. I think that a 3208 would fit better in a F350 than a DT466 would. It’s a shorter engine. Have you ever seen a DT466 stuffed into a pickup? I haven’t. I did see a 8.3 liter Cummins in a 1987 F350.
Is the oil return line on my Turbo bad?
You may have a turbine wheel very undersized for the larger compressor wheel. As to the oil return line, That won’t blow the turbo. It can make it smoke. But, if you fix it the turbo should be fine. I have a International 175 track loader.
How much does a Cat 3208 engine weigh?
Different variations of the engine weigh between 722 and 899 kilograms. The engine displaces 10.4 liters. It has a cooling system capacity of between 47.3 and 56 liters and a lube oil system capacity of between 12 and 15 liters. Three versions of the 3208 engine have varying power ratings.
Where does the oil go in a turbocharged engine?
If your engine is turbocharged, the turbo itself becomes the heart of the engine. All of the engine’s intake air enters through the compressor, while the turbine end sees all of the exhaust, and the engine’s lubricating oil runs through the bearing system.
What happens when a turbocharger goes wrong in a car?
You can copy and paste this link to share: https://musclecardiy.com/performance/turbocharger-failure-analysis-went-wrong-fix/ If your engine is turbocharged, the turbo itself becomes the heart of the engine.
Where is the foreign object in a turbocharger?
(Courtesy Honeywell Turbo Technologies) If the compressor wheel inducer shows damage, the object may or may not be found in the intake system. If the engine is equipped with a charge-air aftercooler, the foreign object, or parts of it, will most likely be located in the cooler.
How much does a Caterpillar 3208 diesel engine cost?
Select a country to view available states. CAT 3208T Diesel Engine, 215HP, All Complete & Run Tested. $6,995.00 with Exchange For Information on this or any other engines. Please Call Cat 3208N Non-Turbo – Complete.
How big is the Cat 3208 diesel engine?
520 cid Hemi ProCharged Pro Mod Engine Stage 2 6.7L Twin Turbo Cummins Engine Diesel of the Week August 2020 Recap Features Rebuilding the CAT 3208 Diesel Advertisement
How much does it cost to rebuild a Cat 3208?
The $13,000.00 is for a Jasper new/rebuilt engine with the new pistons plus the labor to install it from someone who has a pit and is capable of lifting the chassis and dropping the engine out the bottom and then re-installing. CAT wanted $15,000.00 to install a new/rebuilt 3208. Talk about RIP OFF!!! /ubbthreads/images/graemlins/eek.gif
How do you start an OT-Cat 3208 diesel?
You will notice there is a little round knob on it that you can unscrew until you can pull the knob up about 1 1/2 inches or so. That is a priming pump. Next time you go to start it, pump the thing up till you are sure you have fuel pressure to the injector pump and then give it a try at starting.
How big is the fuel line nut on a Cat 3208?
fuel line nut as shown. When this injector is used in the lower horsepower naturally aspirated 3208 engine it will have an injector tip orifice diameter of .290 mm and when used in the higher horsepower turbo engine the injector tip orifice has a diameter of .315 mm.
Can a 1985 3208 cat loose fuel pressure?
3208 cat no start. I had the injector pump rebuilt, loosened 3208 cat no start. I had the injector pump rebuilt, loosened the injector lines and used the hand pump to prime. Fuel comes out a few of the … read more
Why does my Blue Bird 3208 cat not start?
3208 cat no start. I had the injector pump rebuilt, loosened the injector lines and used the hand pump to prime. Fuel comes out a few of the … read more I have a 3208 in a blue bird and it wont crank unless I bleed one of the injectors. It has an electric fuel pump near the tank and if I disconnect the fuel … read more
Cat quit making the 3208 because it was too “dirty” in the emissions department, not because it wasn’t a good engine for them. Now, to answer the question about how much power you can get out of one, Cat has pulled 435 HP out of that engine easily.
3208 cat no start. I had the injector pump rebuilt, loosened 3208 cat no start. I had the injector pump rebuilt, loosened the injector lines and used the hand pump to prime. Fuel comes out a few of the … read more
Cat quit making the 3208 because it was too “dirty” in the emissions department, not because it wasn’t a good engine for them. Now, to answer the question about how much power you can get out of one, Cat has pulled 435 HP out of that engine easily. You can make this at 2800 rpm without too much trouble.
3208 cat no start. I had the injector pump rebuilt, loosened the injector lines and used the hand pump to prime. Fuel comes out a few of the … read more I have a 3208 in a blue bird and it wont crank unless I bleed one of the injectors. It has an electric fuel pump near the tank and if I disconnect the fuel … read more
Different variations of the engine weigh between 722 and 899 kilograms. The engine displaces 10.4 liters. It has a cooling system capacity of between 47.3 and 56 liters and a lube oil system capacity of between 12 and 15 liters. Three versions of the 3208 engine have varying power ratings.
Where does the Caterpillar 3208 diesel engine come from?
An RNLI Lifeboat near Drogheda in Ireland is powered by twin 3208 turbo-charged diesels – such is their reliability. This is an article on diesel engines and in particular the Caterpillar 3208 diesel engine and its application in modern times. We begin with a short history of the Caterpillar Company and move on to its assets.
How many horsepower does A 3208 cat engine have?
The CAT people told him that the 3208 engine was a “engineering nightmare” for Caterpillar and that engine was never intended to do or to be installed in applications they were installed in AND it was never intended to have a turbo installed to put out 250 HP much less have a turbo and aftercooler installed and put out 300 HP.
The DT466 is a great engine. They have a gigantic lower end in them. But the 3208 is a great engine as well. I think that a 3208 would fit better in a F350 than a DT466 would. It’s a shorter engine. Have you ever seen a DT466 stuffed into a pickup? I haven’t. I did see a 8.3 liter Cummins in a 1987 F350.
