Is there a problem with the GM blower motor?

If you have a General Motors car or truck from 2002 through 2008 you’ll probably have a blower motor issue at some point. In many cases it’s a problem with the GM blower motor module. The most common complaint when this part fails is the motor will not turn on at all.

Why does my rear AC blower keep spinning?

But #36 looks like it would stop it only if the HVAC CM-Aux was the fault. If you pull #36 and it keeps spinning then it is the BMCP-Aux. The blower motor control processor controls the speed of the blower motor by increasing or decreasing the voltage drop on the ground side of the blower motor.

What does Black Wire mean on GM blower?

The black wire should indicate a strong ground. If you have a good ground and verified power into the module, yet have no electricity flowing to the fan you probably have a bad module.In many cases when I find the problem with the GM blower control module I also find signs of moisture in the heater case that contains the motor and module.

How do you reset a blower motor on a GM Truck?

However, you can reset the system by pulling the yellow 60 AMP VSES/ECAS fuse located in the under hood convenience center. After you remove the fuse you then start the truck and let it run for two minutes. Next shut it off and replace the fuse.

When does the rear AC blower turn on?

Three years ago I replaced the rear blower motor control module, which caused the rear AC to start working again. That was no fun with such a tight space to try to loosen and tighten nuts in! Since then there has always been, however, an approximate three minute delay for the rear AC blower to turn on.

What to do if your rear blower stops working?

Chevy tahoe suburban rear blower stops working. How to fix. – YouTube Chevy tahoe suburban rear blower stops working. How to fix.

Why is my blower motor not coming on?

With the back wire hooked up I ran a jumper directly to the battery pos and attached it the purple wire terminal on the motor. The motor did not come on. So either my motor is dead shorted or something has gummed up the brushes or they are worn out.

How to test the blower motor resistor ( GMC )?

Thankfully, testing the blower motor resistor is not that hard and in this tutorial I’ll show you 4 different tests that will help you troubleshoot it and find out if it’s bad (or not). This tutorial applies to several Chevrolet, GMC and Oldsmobile pickups and SUVs.

Why is the blower motor running at a low speed?

Be careful, on some vehicles when the engine is running the interior fan is in constant operation at a low speed. GM called this astro ventilation. This is to provide an ample supply of fresh air in the interior compartment even when no climate control mode is selected.

What does blower surge mean on a Mopar engine?

Blower surge by definition. On a mechanically injected engine, which is the fuel delivery on the Mopar engine in the above video, when the engine richens up, the idle drops. As the idle speed goes down, the fuel pump, which is driven by the engine, doesn’t send as much fuel to the engine. That means the motor leans out slightly, increasing the RPM.

Why does the blower motor slow down when accelerating?

However, if the vacuum motor develops a small leak, or there is a leak in the vacuum hose or the dashboard switch, the drop in vacuum may be too much to overcome. That’s when you get a change in airflow. When the door doesn’t operate properly, it may sound like a Blower motor slows down when accelerating

What are the symptoms of a bad blower motor resistor?

Another common symptom of a faulty blower motor resistor is a a blower motor that does not function on certain settings. If the blower motor resistors’ internal components fail it may cause the blower motor to malfunction, or not function at all on one or more of the settings.

What kind of motor does a variable speed blower use?

Variable speed blower motors don’t use a blower motor resistor. Instead they use a blower motor speed control or a power transistor. Variable speed motors are most often used in vehicles with automatic climate control.

What happens if your truck heater is not working?

Because the heater in your truck isn’t working! That means you have to drive 45 minutes, or an entire trip, in a freezing cabin. The first step to fixing your heating system is finding out what’s wrong with it.

What to do if your air conditioner blower motor is not working?

Other options include removing the air conditioner blower motor from the AC unit and checking the label on the actual blower motor. Write this part number down for easy reference. Having the exact part number can save you both time and money, especially if you intend to get a professional installer to replace the blower motor for you.

Why is the heater in my car blowing out cold air and not?

The problem with the heater on the Vauxhall Corsa (as well as the Renault Clio) is often that there is no power from the heaters at all. This issue has nothing to do with cold air coming out instead of heat. This loss of power is also a common issue on the Renault Clio.

What should I do if my blower motor is not working?

If it’s good, refer to a wiring diagram for your vehicle and conduct these tests: Disconnect the electrical connector at the blower motor and jumper power and ground to the motor, bypassing all the speeds controls.

What happens if a heater blower has no power?

A blower motor without power will not be able to produce any air pressure, and as a result the heating and air conditioning system will be left with no air coming from the vents.

What causes a blower motor to overheat?

Decreased airflow causes the blower motor resistor to overheat and fail. Reduced airflow also causes the blower motor to work harder, draw more current and that can cause repeat blower motor resistor failures. Blower motor is drawing too much power. Check the cabin air filter for clogging.

Why does my car blower motor not shut off?

If you have a vehicle with climate control system and a variable speed blower motor and the blower motor won’t shut off and stays on HIGH with the car turned off and the key out, chances are the blower motor motor control processor is toast or the HVAC control module is damaged.

How do I replace the blower motor on my envoy?

Reinstall the new blower motor into the housing. Tighten the blower motor screws and reattach the air outlet duct. Reconnect the electrical connector and replace the HVAC module. Recharge the air conditioning system and refill the radiator with coolant.

Why does my blower motor stop when the car is turned off?

My blower motor keeps running after car is turned off. It stops only if I remove the fuse. How can I fix this? GM repair problems? Ask a GM repair expert now. By continuing to use this site you consent to the use of cookies on your device as described in our cookie policy unless you have disabled them.

When to replace the blower motor control module?

Replace the blower motor control module if the vehicle experienced a blower motor control module failure in extremely cold ambient temperature conditions. Technicians are to replace the blower motor control module also called the Linear Power Module (LPM) with the P/N listed below.

Where can I get a new blower motor?

Its kinda a dealer item but call pep boy’s or auto or major parts store to make sure you cant special order it. here is a pdf of replacement and testing and location as promised. Was this answer helpful?

How does an air conditioner blower motor work?

As explained in the HVAC Blower Motor Guide, an air conditioner blower motor and assembly is basically the fan inside the air conditioning system that forces the cooled air, via the AC cooling coil, through the vents and into the room space that is being conditioned.

Where does the air come from in a GM blower?

As an example, if you select defrost, the mode door points all the air at the windshield. If you select heat, then the air will be directed at the floorboards. In the AC mode all of the air should come out of the air conditioning vents. If you select blend, then you’ll get air coming out of all of the positions.

When did the Chevy Impala get a blower motor?

If you have a Buick Rainier, Chevrolet Impala, GMC or Chevrolet Silverado pickup that falls between model years of 2002 through 2008 it probably has the same set up. Oh and don’t forget the Envoy and Trailblazer.

Why does my Chevy Silverado blower keep running?

Also, if you smell burning plastic or smoke begins to enter the cabin when the blower is going, that is also a sign you have a faulty blower motor. Finally, if you hear that the blower motor is still running even when the Silverado ignition is in the “off” position, chances are, your blower motor needs replacing. Figure 1. Test your HVAC controls.

What to do if your Chevy Tahoe blower stops working?

Chevy tahoe suburban rear blower stops working. How to fix. If playback doesn’t begin shortly, try restarting your device. Videos you watch may be added to the TV’s watch history and influence TV recommendations. To avoid this, cancel and sign in to YouTube on your computer. An error occurred while retrieving sharing information.

Why is there no ground on my blower motor?

It seems, too, that the black ground wire on the blower motor (accessible from just below the dash) has NO ground potential. I ghetto jumpered a 16 gauge wire from the back of the metal clip on the ground wire to the dashboard impact bar/brace and the fan turns at variable speeds with the knob!

Where is the blower motor on a GMC c1500?

This 1992 GMC C1500 pickup came in with the complaint that the blower motor was squeaking and the noise was getting worse. The blower motor is located under the passenger side of the dash and has this rubber and foam sound deadening cover over it.

When do you need to replace the blower motor relay?

If the blower motor does not function, car fuses are blown, or relays are melting, you may have to replace the car blower motor relay. 1. Blower motor does not function 2. Blown fuses 3. Melted relay The blower motor relay is the electrical switch that is used to supply the power for the vehicle’s blower motor.

How much does it cost to change a blower motor?

In this case, the blower motor in my 2008 GMC Sierra Z71 4×4 (5.3L) stopped working completely. The price of a new blower motor at O’Reilly Auto parts was about $98.00. Installation was very simple. The cheapest local mechanic wanted almost $300 to do the same job. DO IT yourself….Hope this helps someone. Loading…

What happens if you have a bad blower motor?

The blower motor is the component responsible for pushing air through the vents of your vehicle’s heating and air conditioning systems. Without it, the AC system will not be able to circulate any heated or cooled air.

Where is the blower control switch on the dashboard?

The blower control switch on the dashboard controls the circuit flow of the blower motor to adjust the voltage from low, to medium, to medium-high, to high. When on high, the circuit bypasses the blower resistor.

Why is my blower not working on my Chevy Silverado?

It could be faulty. Whether you have a physical fan speed switch or the dual climate feature in your Silverado, there is a button or switch that is dedicated to start or speed change of the blower for the AC or heater. Sometimes this switch can fail, and leave you with no way to turn on or operate the blower speed.

Why are the cooling fans not working on my Silverado Sierra?

I had the AC on in the truck today and noticed the air would get warm at idle. The AC was nice and cold if I was driving. I assumed a blend door was bad, but noticed the electric cooling fans were not coming on.

What to do if your Silverado blower won’t work?

Head under the hood and check the blower motor wiring to make sure it is getting power to it. If it is, then your only option is to remove the blower motor and have it tested or replaced. You can do so yourself if you have the equipment, or have it done at the dealership or parts store. Figure 3. Silverado blower motor and fan assembly.

What should I do if my blower motor stops?

Replace blower motor. If you have a variable speed blower motor, replace the blower motor speed control module. If you have a three or four speed blower motor, remove the blower motor relay. If the motor stops, replace the relay. Alldatadiy.com and Eautorepair.net are professional-grade shop manuals—period.

Why does my GMC k1500 blower not work?

Here is a possible solution for your 1995 GMC K1500 blower that wont work on high. First remove the glove box and set it aside. Now look into the area that the glove box resided. You will see a wire harness covered in factory foam and next to this on the right you will see a flat silver box that is your ECM.

Why does my GMC heater not work on high?

1997 GMC C1500 Heater/AC blower will not work on HIGH. I have replaced the black BOSCH relay behind the glovebox, the blower RESISTOR and the blower MOTOR and still cannot get the blower to work on HIGH. I remember in older model years of GMC’s and Chevys that their was a high speed blower relay that caused this issue.

Is there a problem with the GM blower motor?