Where is the fuel pump on a Sprinter?

Where is the fuel pump on a Sprinter?

Fuel Pump Mercedes-Benz SPRINTER The fuel or feed pump is intended to supply the carburettor in your Mercedes-Benz SPRINTER with petrol. The fuel pump is situated in the fuel tank.

Why are my cranks on my sprinter not working?

Checked clear lines and NO air bubbles or foam. Got van to start after several extended cranks but died as soon as accelerator peddle pressed. Van towed back to dealership and I asked what my feed pressure and rail pressure readings are and was informed they never tested or checked as the only code is no communication with MAF sensor.

What happens when you unplug fuel pressure sensor in sprinter?

If I unplug the fuel pressure sensor and crank for about 20-30 seconds I can get it to hit on what sounds like one cylinder and make a little bit of fumes. The actual pressure matches the desired after 10-15 seconds of cranking. The actual pressure gradually builds and when you quit cranking it gradually drops.

What is part number for sprinter fuel regulator?

Dont let your dealer try to sell you the whole regulator for $300 the o-ring only kit is part number is 05175439AA. 4. If this is not the problem you may have too much fuel bypassing inside worn injectors. You need to run a fuel quantity test.

What causes boost to fail on Sprinter van?

Turbocharger Actuator On the modern diesel engine used in the Sprinter van, boost pressure is controller using a vane-system. The control valve for the vane system is electronically controlled and can fail. The turbocharger is still healthy, only the control valve has failed.

Why does my Dodge Sprinter engine not start?

There are a lot of issues that can cause your Sprinter to crank, but not start. The engine needs air, fuel, and a spark in order to run. It is highly likely that if the engine is cranking, but not starting that it has thrown an OBDII code.

Is it safe to drive a Dodge Sprinter?

I bought a 2008 sprinter 2500 3 week ago. It just ran 700 miles now. But I was stoped by a police on highway because the huge white with light blue smoke came out of this van and said it’s unsafe to drive this van. I start to notice: it’s realy big smoke from exhaust pipe with no much smell.

What should fuel pressure be to start sprinter?

You must have at least 2500 PSI to start. 3. If no or low fuel pressure the nasty little culpret may be a 25 cent o-ring. The fuel pressure regulator is located at the rear of the fuel rail on 2002 to 2004 trucks. Its held in with two little torx head screws and can be a mother to get out. It’s not terrible you just have to work by feel mostly.

Can a Dodge Sprinter start in cold weather?

My Dodge Sprinter 2007 will not start in extreme cold weather (-30F). (14400km) Took it to the dealer they installed a circulation heater in the heater hose (1000W). Again the Sprinter would not start in minus 30F weather after the heater was installed.