When did my Dodge Sprinter lose its power?

Now I left for vacation June 29, 2008 and have a loss of power again, can’t go over 55mph, which is good for saving diesal fuel but not for wanting to get to my vacation place. This sprinter has only 17,000 miles on it. Up date on my van, after sitting for appox. two days, started up and ran fine.

Where can I get a Dodge Sprinter with no boost?

Update: Had a 2nd event of sudden loss of power / no boost on the I20 just west of Atlanta on a weekend trip with my Sprinter 3500 (2006) Winnebago View (2007). Aborted trip and limped back on my own power to dealer in Canton, GA that has Service Department working on Saturdays.

What is the Turbo resonator on a Dodge Sprinter?

Turbo Resonator is the black plastic box on the front of the turbo into which the boosted air goes prior to going into the intercooler input hose. recommended to replace with the part from Riordan = no more failure (aluminum part)… I have a Winnebago View built on the Sprinter Chassis. I had the same problem.

What kind of car is the Dodge Sprinter?

My unit is a 2006 Navion with a 2005 Sprinter chassis and we are on the fourth resonator. Our first was done 6 weeks after purchase, the second one was 10 months later, the third one was 11 months later and the fourth one was this week (April 2009).

What causes a sprinter to go into limp home mode?

This is common condition with a few common causes. If you have an Sprinter with the 4-cylinder engine (OM651) see this article about a common issue on this engine that causes Limp Home Mode. Low power – enough power to get to 50 mph in some cases, but not to keep that speed up a hill.

What causes boost to fail on Sprinter van?

Turbocharger Actuator On the modern diesel engine used in the Sprinter van, boost pressure is controller using a vane-system. The control valve for the vane system is electronically controlled and can fail. The turbocharger is still healthy, only the control valve has failed.

Is there a warranty on a Dodge Sprinter?

The aluminum turbo resonator eliminator is not only approved for installation, it is being recommended by Dodge Sprinter service reps all across the Country. Further, the Magnuson warranty act would specifically MAKE them honor your warranty, since this part does not change the operation, or function of any system on the vehicle.

What should I do about my pre 2007 sprinter?

Pre 2007 turbochargers can have their actuators adjusted. Turbo Resonator: Common failure part on these vehicles. Can replace with a durable aluminum unit to fix the faulty factory part.

What does it mean when a Dodge Sprinter won’t start?

The first and most common is when it won’t turn over. This just means that the engine doesn’t move when you turn the key. The second way that your Sprinter won’t start is when the engine turns when you engage the starter, but it won’t fire and run on its own.

Pre 2007 turbochargers can have their actuators adjusted. Turbo Resonator: Common failure part on these vehicles. Can replace with a durable aluminum unit to fix the faulty factory part.

What to do if your sprinter loses power?

Some of the Sprinter owners have complained about problems like: Sudden loss of power on the move and the van going into the limp home mode If you feel that your Sprinter van is experiencing any of the above issues, you need to contact the best auto repair in your area and get your van inspected and maintained.

Are there any negatives to a Sprinter van?

For instance, improved lifespan and good torque characteristics via a broad range of RPM in Sprinter vans offer great driving comfort. The negative side, however, is that these engines have a sooty exhaust that needs to be controlled regularly so that the van does not cause much pollution.

What causes intermittent power in a Mercedes Sprinter?

You may find that some of the fuse carriers have also corroded on the visible side of the board, the unit can be further dismantled to reveal the internal components of the holders that can be cleaned in the same way as the rear connectors. However the most common cause of problems will be in the multi-way connectors on the rear of the unit.

What to do if your Mercedes Sprinter loses power?

Once the fixings are removed and the large wire is protected pull out the top of the board directly from the two connectors beneath the steering wheel. Once this is out the board will pull down to allow you to remove the connectors behind. Once all these are removed the unit can be lifted away from the column and inspected.

Why do I have intermittent power in my sprinter?

Sometimes due to a weak moulding, the threaded insert in the column plastic fails, preventing the secure fastening of the fuse board at its top edge. The best cure for this is to remove the insert with careful use of a screwdriver and prize it out, then using a strong tie-wrap as pictured to secure the whole assembly.

Is it safe to drive a Dodge Sprinter?

I bought a 2008 sprinter 2500 3 week ago. It just ran 700 miles now. But I was stoped by a police on highway because the huge white with light blue smoke came out of this van and said it’s unsafe to drive this van. I start to notice: it’s realy big smoke from exhaust pipe with no much smell.

Why does my Dodge Sprinter run so hot?

My sprinter also runs a bit hotter above 80 outside with A/C running, especially climbing hills (even gentle ones) as the turbo is running due to fuel useage to keep up speed.

Why are my cranks on my sprinter not working?

Checked clear lines and NO air bubbles or foam. Got van to start after several extended cranks but died as soon as accelerator peddle pressed. Van towed back to dealership and I asked what my feed pressure and rail pressure readings are and was informed they never tested or checked as the only code is no communication with MAF sensor.

What should fuel pressure be on Sprinter diesel?

When checking the fuel pressure solenoid there should be no fuel coming out the return during cranking, and it should hold 870-1450 psi when unplugged during cranking. If it doesn’t, and the injectors are OK, then the fuel pressure solenoid is bad.

How does the high pressure pump in a sprinter work?

The high pressure pump builds the high pressure and delivers it to the fuel rail manifold, which buffers out pressure fluctuations and distributes fuel to the individual injectors. The fuel quantity valve (fuel control actuator, M-Prop) in the high pressure pump controls pressure output from the pump.

When to replace fuel pressure solenoid on sprinter?

If it is and there is leakage, replace the fuel pressure solenoid. The high pressure pump is driven by the camshaft, and requires no timing. Fuel that enters the high pressure pump is pressurized between 200-1600 bar (2,900 – 23,205 psi). The pressurized fuel is then supplied to the fuel rail.

Is there a speed governor on a pro sleeper?

My friend just bought a 98, 9900 International Pro Sleeper truck and he says he can only go 66mph. He says there is a speed governor on it and he doesn’t know how to disable it. I’m sure you may need more info on this but I’m not very familiar with the ‘big’ diesels so just let me know.

Is there a way to disable speed governor?

Fired for sure if they get caught. Get into an accident, and better do the stretching thing so they don’t pull a muscle when kissing their own butt good bye. Otherwise it would be cheaper just to have the speed limits set by the dealer. Less then an hour to do, may have a one hour min charge. Dealer don’t care what the speed limit is set to.

What causes a Dodge Sprinter to loose power?

I have a 2002 Dodge Sprinter that seems to loose power after it has been driven a few hours, and then it must sit for 10 to 30 minutes before it will start again. It acts like there is either no fuel or the airflow is restricted.

What causes check engine light on sprinter 3500?

The Sprinter should have codes on just about every sensor and very few things can be wrong without a code of some kind… Any ideas on what could be causing the frequent appearance of Check Engine light on my 2006 Sprinter 3500 powered by 5 cyl Mercedes? I’ve put 7,500 miles on the chassis which carries an Itasca Navion Class C motorhome.

Why does my 2002 sprinter not start after second start?

After the second start error, it takes about 4 hours for my 2002 Sprinter to reset itself before I can even try again to start it. I thought maybe the anti-theft system wasn’t reading the chip in the ignition key because its battery was low, but a Sprinter tech told me there is no battery in the key.

When did the second generation Sprinter come out?

The second generation Sprinter was introduced in Europe in 2006. It was voted Van of the Year 2007 and again in 2008 by Professional Van and Light Truck Magazine. 2012 Information and Fuel Consumption Figures.

Are there any problems with my Mercedes Sprinter?

As long as you stay on top of regular maintenance, the longevity of a Mercedes Sprinter will serve you well. But these vans are not devoid of some major common issues, and these problems are expensive to repair. Sourcing Mercedes parts is a potentially difficult task. And buying parts gets expensive.

Who is the manufacturer of the Mercedes Sprinter?

Jump to navigation Jump to search. Light commercial vehicle (van) built by Daimler AG. The Mercedes-Benz Sprinter is a light commercial vehicle (van) built by Daimler AG of Stuttgart, Germany as a van, chassis cab, minibus, and pickup truck.

Why did my Mercedes Sprinter Countdown go to 0?

My Mercedes sprinterdef countdown went to 0 even after I filled it. Is there a way to reset the code to get it running Mechanic’s Assistant:Tell me a bit more about what’s going on so he can help you best. The van won’t start since the def countdown went to 0.

How many starts does a 2013 sprinter have?

2013 ML350, got the 10 starts remaining signal, replaced DEF, but now it’s down to 5 starts and has not reset. I am 5 hours from a Mercedes dealer. … read more I have a 2013 Mercedes Sprinter 2500. The Check DEF lamp I have a 2013 Mercedes Sprinter 2500. The Check DEF lamp came on while I was driving home from a short trip.

What’s the Def light on a 2013 sprinter?

2013 MB Sprinter 2500 with 41k miles, just got the 10 starts left light. DEF tank full. I was told to take it for a long drive and get it warm, because I … read more associates in automotive te… It will or start. The display reads Starts RE 0. 2012 It will or start. The display reads Starts RE 0. JA: Will the headlights turn on?

Why do I need a 2004 Dodge Sprinter?

JUST GETTING ON THE FREEWAY ONE DAY CHANGED MY LIFE. YOU SEE, I DEPEND ON MY 2004 DODGE SPRINTER FOR WORK /INSTALL DRAPERIES AND BLINDS. WITHOUT MY TRUCK IN THIS ECONOMY ,WELL, THATS MY MAIN TOOL TO WORK.

How to increase horsepower in a Sprinter van?

Please select your vehicle from the drop-down menu. Increase your Sprinter’s Horsepower and Torque with this Dual Channel Power Module. Please note that this product will not allow you to overcome your speed governor. Satisfaction Guarantee: Tuning modules have a 30-day satisfaction guarantee. That is 30 days from the assumed delivery date.

What happens when you unplug fuel pressure sensor in sprinter?

If I unplug the fuel pressure sensor and crank for about 20-30 seconds I can get it to hit on what sounds like one cylinder and make a little bit of fumes. The actual pressure matches the desired after 10-15 seconds of cranking. The actual pressure gradually builds and when you quit cranking it gradually drops.

Why is the Turbo not working on my sprinter?

Turbo Actuator: We don’t offer this item separately, but often times the turbo isn’t working correctly because the electronic actuator is broken. Pre 2007 turbochargers can have their actuators adjusted. Turbo Resonator: Common failure part on these vehicles. Can replace with a durable aluminum unit to fix the faulty factory part.

What is the fuse box diagram for a Dodge Sprinter?

Dodge Sprinter (2005 – 2006) – fuse box diagram Posted on 22 November 201710 July 2019by admin Dodge Sprinter (2005 – 2006) – fuse box diagram Year of production: 2005, 2006 Fuse Assignment, Standard Equipment Dodge Sprinter – fuse box – fuse assignment (standard equipment) Number Ampere rating [A] Circuits 1 10 Parking lamp right, taillamp right

What should I do if my Mercedes Sprinter loses pressure?

Always on: The Mercedes Sprinter yellow tire/ tyre pressure monitoring system (TPMS) has detected a rapid loss of pressure in at least one tire. Avoid making any sudden steering or braking manoeuvres and stop the van being sure to pay attention to traffic conditions.

Is it worth it to buy a Sprinter van?

As a business owner, you know buying quality for the long haul is always worth it for your bottom line. And Sprinter vans save through efficiency, retained value, and more. Boost your efficiency with the van that needs fewer service visits. Keep your business rolling right along for up to 20,000 miles with this category-leading service interval.

How to get the most mileage out of a Sprinter van?

The best way to get the most mileage out of a Sprinter van is to keep a book of records. Follow the manufacturer’s maintenance schedule, and you shouldn’t have anything too serious for several years. If you choose to ignore the schedule to cut costs, you could end up paying much more later on.

What to do if you lose your Dodge Sprinter key?

First, call an automotive locksmith that offers a mobile service for Dodge Sprinter cars. We can help you with that. Second, tow the car to the dealer. Third, order a key online and have the dealer or locksmith cut and program (if necessary) it for you.

Where is the fuse box on a Dodge Sprinter?

Dodge Sprinter (2008 – 2009) – fuse box diagram Posted on 26 November 201710 July 2019by admin Dodge Sprinter (2008 – 2009) – fuse box diagram Year of production: 2008, 2009 Main fuses box The fuses box is in the footwell on the lefthand side of the vehicle. Dodge Sprinter – fuse box – main fuse box Number Consumer Amp. 1 Horn 15 2

When did the Dodge Sprinter get a transponder?

How to program & more. Dodge Sprinter was introduced in 2002. This model has two types of keys. Transponder Chip Key: 2007 to 2013. Non-Transponder Key: 2002 to 2006. Please keep in mind that while some keys or key fobs may look the same, they have different capabilities/frequencies/keyways.

What kind of power does a Sprinter van use?

Electrical Because the starter battery isn’t very big, most conversion vans use a separate 12 volt power system to run lights, a fridge, fans, chargers, power for a diesel heater and so on.

When did my Dodge Sprinter lose its power?