Where is the clutch fuse on a 1998 Dodge Ram 1500?

Please try again later. On this 1998 Dodge Ram 1500 I point out to you the location of the AC compressor clutch fuse and a AC compressor clutch relay and also discuss swapping them with the horn fuse and relay to troubleshoot. Loading…

Why is my a / C unit not working in my Dodge Ram?

The condenser fan motor may have died. The condenser fan is designed to keep the heat away from the A/C system. When the fan stops working, Freon will heat up and be unable to cool down quickly, causing the vents to blow hot air at times. To check the condenser fan, open the hood and observe if the fan turns off when the engine is running.

Why does my Dodge Ram have a condenser fan?

The condenser fan is designed to keep the heat away from the A/C system. When the fan stops working, Freon will heat up and be unable to cool down quickly, causing the vents to blow hot air at times. To check the condenser fan, open the hood and observe if the fan turns off when the engine is running.

What causes a fuse to blow on a Dodge Ram?

Figure 1. Dodge Ram under-hood fuse box. Although replacing a damaged fuse will correct the current issues, you should be aware that something caused the fuse to blow and there may be a larger problem in the system’s wiring. If the fuse blows again soon after being replaced, check the wires that routes to it. The refrigerant may be escaping.

Why is the clutch not engaging on my Dodge Ram?

The thing is that my AC clutch will always engage when engine is cold but will shut off about 15-20 after. I can turn it back on by either turning the engine off and let it cool off or turn off the a/c for same amount of time. I can then start AC again for small amount of time.

Why does my AC compressor clutch not engage?

Why AC clutch won’t engage If the clutch doesn’t engage, the problem could be a blown fuse, an open in the wire to the clutch coil, a bad clutch coil, a poor ground, or a low pressure lockout. AC compressor clutches receive power in a number of ways.

What to do if your clutch is not working?

Disconnect that wire connector. Then put the end of the wire connected to the battery into the clutch side of the connector. You should see the front of the clutch pull in and hear a good healthy click.

Why is the compressor not working on my Dodge Ram?

If you end up with a full charge and the compressor still won’t work on it’s own, you have some other electrical problem that will require more diagnosis. But you first need to get enough of a charge that the AC system’s safety switches will allow the electrical part of the system to operate.

Where is the a / C relay on a 2015 Dodge Ram?

I have a 2015 and my A/C sporadically works. I tried to find the Relay and it doesn’t have it in the fuse box, just a 10A fuse. I know it has to have a relay. Does anyone know where it’s located? ac clutch is r2 in the tipm. ac clutch is r2 in the tipm. Click to expand… Can you take a pic like that of actually relays?

Why is the AC not working on my Dodge Ram 1500?

A/C will not direct to any vents. Can feel cool air, but on anything other than the lowest fan setting sound like fan is coming out of cage. Apparently turning the knob to direct air to feet/face has no effect and air is not being directed to either location and is blocked at the fan cage. Dodge really needs to address this problem.

Why is my Fuse Box making a clicking noise?

This can be caused by a computer failure, resistance in the ground wire for the control side of the relay or high resistance in the power supply to the control side of the relay. To find out the source of the problem, you’ll need to run some quick tests using a multimeter.

How can I tell if my Fuse Box is running?

Check for constant ground to the relay. Identify the slot in the fuse box that terminal 85 plugs into. Set your multimeter to read voltage on the 20-volt scale. Plug the negative lead of your multimeter into the slot for terminal No. 85. Touch the positive lead to the positive battery terminal. You should see constant battery voltage.

Why is my fuel pump clicking on and off?

If you don’t know how to use a multimeter, St. Lawrence University has published a good tutorial. Dodge trucks built between 1992 and 1995 have a common problem with the PCM. The main computer board cracks, and it causes the ASD and fuel pump to click on and off constantly. Locate the problem relay.

Why is my AC clutch not working on my Dodge Ram?

One of the most common problems is a low refrigerant charge, the low pressure switch prevents the AC clutch from engaging when the system is low on refrigerant. Definitely check the fuses before replacing anything else. Your interior fuses should be on the drivers side as pictured below in a video from carcarekiosk.com.

What should the compressor pressure be in a Dodge Ram?

I hooked up the guages and while idling it shows about 35 PSI on low and about 180 PSI on hi side. According my repair manual the pressure should be 30-40 and 250. My reading is while idling and i think the correct chrysler reading should be at 2000 rpm which would be even lower and that would mean i’m low in refrigerant.

What’s the fuse in the hood of a Dodge Ram?

Turns out that the 20 amp Horn Relay fuse, in the relay box under the hood, also feeds the AC Compressor clutch relay. New fuse, and I’m chilling again.

Why does my air conditioner keep blowing fuses?

A third possibility is that high demand (i.e. high temperatures) is forcing your system to work harder to push conditioned air through a dirt-clogged HVAC filter, which in turn is putting extra pressure on the system and blowing the fuse. Occasionally, a dirty condenser coil can have a similar effect.

Why does my AC keep tripping circuit breakers?

Still, there are steps you can take to troubleshoot an air conditioner that keeps tripping a circuit breaker: Replace your air filter – A restriction in airflow caused by a clogged air filter will force your cooling system to struggle, which often leads to overheating and potential breaker trips.

Can a bad ignition switch cause a starter relay to fail?

Although it’s unlikely that you’ll ever experience a problem with the starter relay, it is prone to mechanical failure and will need to be replaced by a professional mechanic if it wears out. Most of today’s modern cars and trucks have an electronic ignition switch that is activated by remote key.

Why is a clicking sound coming from the starter relay?

Clicking sound coming from the starter One of the most important – and most forgotten – components of any vehicle’s ignition system is the starter relay. This electrical part is designed to redirect power from the battery to the starter solenoid, which then activates the starter to spin over the engine.

How to fix a 1998 Dodge Ram that wont start?

An expert who has answered 5 questions. Check the asd relay in fuse box under hood look very close at contacts if replacing fuse does not fix wires in box may be burnt under neath You can’t post conmments that contain an email address. An expert who has achieved level 1. An expert that has 1 follower. An expert that has over 10 points.

Where are the fuse panels on a Dodge Ram?

Here you will find fuse box diagrams of Dodge Ram Pickup 1500/2500/3500 1994, 1995, 1996, 1997, 1998, 1999, 2000 and 2001, get information about the location of the fuse panels inside the car, and learn about the assignment of each fuse (fuse layout) and relay.

Why does my ASD relay not start up?

I put a new fuel pump on it and it still won’t start – the fuel pump does not seem to be priming either, so I don’t think there is power there. Also – the codes say there is something wrong with the ASD relay. Thanks. Clicking this will make more experts see the question and we will remind you when it gets answered.

What does it mean when a fuse blows on a Dodge Ram?

The use of a fuse with a rating other than indicated may result in a dangerous electrical system overload. If a properly rated fuse continues to blow, it indicates a problem in the circuit that must be corrected. Your vehicle is equipped with a fuse and relay center located in the engine compartment near the battery.

Is there a fuse for the AC compressor?

Went to heater control panel, have 12 V at ac switch, (with blower on) and so switch is sending it down the line but where it goes to, I don’t know. Can’t find any fuse or breaker labelled AC. Tried running a separate set of wires directly to ac comp, it kicks in fine, draws 3.2 amps.

Why is there no power to my AC compressor?

No 12 volts at comp plug. Went to heater control panel, have 12 V at ac switch, (with blower on) and so switch is sending it down the line but where it goes to, I don’t know. Can’t find any fuse or breaker labelled AC.

Is there a way to test a relay in place?

Relay test – YouTube Access to test a relay in place can be difficult. Here’s a simply way to test the actual relay mounted in the relay box Access to test a relay in place can be difficult. Here’s a simply way to test the actual relay mounted in the relay box Skip navigation Sign in Search Loading… Close This video is unavailable. Relay test

Why does my Dodge Ram Van not start?

If playback doesn’t begin shortly, try restarting your device. Videos you watch may be added to the TV’s watch history and influence TV recommendations. To avoid this, cancel and sign in to YouTube on your computer. An error occurred. Please try again later. (Playback ID: IpBYDyhp9Cwbgn6w)

What should I do if my relay has failed?

Turn the ignition to the “ON” position and jump terminals 87 and 30 the relay is now jumped and the accessory should activate, if so the relay has failed. If no power is observed at either 87 or 30, the fusible link or maxi fuse has shorted.

How do you test a car relay with no power?

If there is no power, the electrical system must be tested starting with the fuse then the relay. If power is present use the test light connected to battery power to check the ground circuit. if these tests check out, the accessory is bad and needs to be replaced.

How many fuses does a Dodge Ram have?

It’s much easier to replace a $1 fuse than an expensive electrical component like the radio or the ECU. When something does stop working, it’s good to know your fuses and which one needs to be replaced. The Dodge Ram has two fuse boxes: the power distribution center and the junction box.

Can you replace just the clutch on a Dodge Ram?

Discussion in ‘ Engine & Performance ‘ started by cheapbeater, Oct 13, 2010 . Can I replace JUST the clutch on my AC compressor? It got fried and now i cant use my AC or defrost because the clutch starts smoking…

Is there an AC compressor for a Dodge Ram?

Junkyard that has a heart will sell ya one on the cheap. 5.7?? Check out myosinner on dt. He has a rolled over o6 night runner may still have the compressor. He has half the truck in hi livng room now lol. pm him. Or go to a pick and pull. Or bite that bullet. myy 2 cts cousin.

Can you replace only the clutch on a Dodge Ram?

By replacing only the clutch, you are saving on labor, compressor and parts like filter drier and expansion valve. Pages with related products. See and discover other items: a/c compressor clutch, compressor clutch, ac compressor clutch, dodge clutch, 2002 dodge 1500 items, jeep air compressor

How to replace AC compressor in Dodge truck?

Dodge truck ac compressor replacement. – YouTube Dodge truck ac compressor replacement. If playback doesn’t begin shortly, try restarting your device. Videos you watch may be added to the TV’s watch history and influence TV recommendations. To avoid this, cancel and sign in to YouTube on your computer.

What kind of clutch does a Dodge 1500 have?

AC Compressor Clutch. Fits; 2004-2007 Dodge Ram 1500 3.7 & 4.7 liter Gas Engine. For OEM compressor only. Made in the USA by Maxsam Clutches.

Can you replace the clutch on an after market compressor?

This Clutch will not fit any after-market compressor………………………. The only component on your compressor, that never stops moving, is your clutch and most failures are the clutch NOT the compressor. Why spend $100.00’s to replace the compressor when for less than $100.00 you can replace the Clutch only?

Where is the clutch fuse on a 1998 Dodge Ram 1500?