Other

How long does it take to troubleshoot a hydraulic system?

How long does it take to troubleshoot a hydraulic system? This data sheet describes a step-by-step check-out procedure for hydraulic systems which have previously been working satisfactorily but which have developed trouble, usually over a 24-hour working period, which renders them inoperative. It is not intended as a diagnostic check of new systems which may have been incorrectly designed. What to do if you have a faulty hydraulic valve? The faulty valve may later be disassembled and cleaned. Pilot-operated relief valves have small internal orifices which may become blocked with dirt. Blow out all passages with an air hose and...
Other

Why is my diesel engine not working properly?

Why is my diesel engine not working properly? Most of the potential problems in a modern common rail diesel system engine can be explained by a drop in fuel pressure or engine compression, insufficient fuel supply, or fuel contamination. The major culprits are likely to be the fuel injectors, high pressure pump, fuel filter, fuel pressure sensor or regulator, glowplugs, or crankshaft sensor. Why is my fuel pump pushing air instead of diesel? It all has to do with lubrication. With plenty of diesel fuel in the tank, the fuel pump bearings receive plenty of lubrication. With a near-empty tank,...
Other

What is the weight of a Terramite T5C?

What is the weight of a Terramite T5C? SpecificationsMakeModelWeightTerramiteT5C3100 lbsTerramiteT7G4125 lbsTerramiteT5X3100 lbsKubotaBX251542 lbs Where are Terramite built? Xu's Chinese construction equipment company is called Lioning Heavylong, and is headquartered in Anshan in northern China, with about 300 employees. Terramite was founded in 1965 and its small backhoes were popular in the North American equipment rental industry. How wide is a Terramite T5C? SpecificationsMakeModelOverall DimensionsTerramiteT5C13'L x 48"W x 82"HTerramiteT7G15'L x 58"W x 82"HTerramiteT5X13'L x 48"W x 82"HKubotaBX258'L x 45"W x 86"H Where are Terramite backhoes made? When to replace pivot pins on terramite T5C? Terramite T5C tractor loader backhoes are equipped...
Other

Can you filter and reuse hydraulic fluid?

Can you filter and reuse hydraulic fluid? What you need to be worried about when reusing hydraulic fluid is the very small particles in the 2 to 20 micron range. You would need a special filter to filter out those particles. Your normal filter only filters down to the 20 micron range because the filter has to allow the fluid to flow at a certain rate. How do you clean old hydraulic oil? Absorb any excess oil with sawdust or cat litter. If the spill is recent, sprinkle an absorbent material like sawdust, granulated clay, or cat litter over the...
Easy lifehacks

What does steering Power low mean?

What does steering Power low mean? On hydraulic power steering systems, a common reason for the warning light to illuminate is low power steering fluid. You should pull over if you see this light turn on and check the fluid level immediately. Keep in mind that low fluid means a leak is present that needs to be remedied at the earliest. What causes a p0636 power steering circuit low? Causes for this P0636 code may include: Defective power steering pressure switch Defective power steering position switch Faulty power steering control A loose control module ground strap or broken ground wire...
Common questions

How to connect the ECM by Cat communication adapter 3?

How to connect the ECM by Cat communication adapter 3? Click “Start” – “All Programs” – “Caterpillar Comm Adapter 3” – “Comm Adapter 3 Toolkit”, or through shortcut “Comm Adapter 3 Toolkit” on desktop. 3. Once CA3 was detected, close the CAT Communication Adapter 3 Toolkit and open the CAT ET Software. Can you get scanner to connect to ECM? Found TDG while I was trying to research a problem on my 2000 Sterling at9500 with a CAT C12 I have a check engine light on the dash. So I connected my OTC Scanner and it replied not connected!!! I...
Easy lifehacks

Is there such thing as a good morning lift?

Is there such thing as a good morning lift? A common joke in commercial gyms is how often squats are turned into bastardized good mornings, but rarely (if ever) does anyone see a “good” good morning done. Even among the strength and conditioning community, they seem to be a rarely utilized lift. When do the greetings ( good morning, afternoon, and evening )? Good Afternoon 12:00 PM — 4:59 PM Good Evening 5:00 PM — 4:59 AM What is Momentum Dashboard? Momentum is a free Google Chromeand Firefox add-on that breathes life into your New Tab page. In addition to daily greetings,...
Easy lifehacks

How tall is a 1999 Sea Ray caterpillar?

How tall is a 1999 Sea Ray caterpillar? 1999 Sea Ray 370 EC DIESEL classifieds board 1999 SEA RAY 370 EC Engines: T-CAT3116TA Caterpillar (T-340 hp 254 kW)) Overall length 370 11.28 m w/Std. swim platform & pulpit 414 12.60 m Beam 142 4.32 m Draft (inboards) 39 99.1 cm Fuel capacity 350 gal 1,324.8 L What makes a Sea Ray 370 EC a good boat? From the lines of the hull to the appointments of the interior, the 370 EC is a boat that makes a statement. It does so with an elegance that has made Sea Ray one...
Easy lifehacks

What causes an axle shaft to bend?

What causes an axle shaft to bend? This can occur during an auto accident, running over a curb, or even hitting a particularly deep pothole at higher speeds. The result is a bent axle. A badly bent axle will quickly cause damage to CV joints, and it's possible to damage your wheel hubs, bearings and other components. Can you bend an axle back into place? There is NO WAY to CORRECTLY straighten an axle housing once it's bent. You will need more in jigs, heating the tubes, ect. than a new housing will cost. What happens if your rear wheel...
Easy tips

What are the two types of diesel engine?

What are the two types of diesel engine? There are two classes of diesel engines: two-stroke and four-stroke. Most diesel engines generally use the four-stroke cycle, with some larger engines operating on the two-stroke cycle. What are the different types of diesel engines? There are three basic size groups of diesel engines based on power—small, medium, and large. The small engines have power-output values of less than 188 kilowatts, or 252 horsepower. Is a diesel engine internal combustion? Diesel vehicles are similar to gasoline vehicles because they both use internal combustion engines. In a compression-ignited system, the diesel fuel is...